THE SIDE CASE LOCK FAILED, CAUSING THE SIDE CASE (SADDLEBAG) TO FALL OPEN WHILE RIDING. THIS CAUSED THE MOTORCYCLE TO SWERVE, NEARLY CAUSING A CRASH. I REPAIRED THE LOCK BY ADDING A LOCK WASHER AND LIQUID LOCKTITE TO THE SINGLE SCREW HOLDING THE LOCK IN PLACE. TWO WEEKS AGO, I EXPERIENCED THE SAME PROBLEM ON THE OPPOSITE SIDE CA…
Read full complaint
THE SIDE CASE LOCK FAILED, CAUSING THE SIDE CASE (SADDLEBAG) TO FALL OPEN WHILE RIDING. THIS CAUSED THE MOTORCYCLE TO SWERVE, NEARLY CAUSING A CRASH. I REPAIRED THE LOCK BY ADDING A LOCK WASHER AND LIQUID LOCKTITE TO THE SINGLE SCREW HOLDING THE LOCK IN PLACE. TWO WEEKS AGO, I EXPERIENCED THE SAME PROBLEM ON THE OPPOSITE SIDE CASE. LUCKILY, THIS TIME IT HAPPENED AT VERY SLOW SPEED IN MY DRIVEWAY. IF THIS HAPPENED AT HIGH SPEED, OR IN A TURN, IT COULD BE DEADLY. I CONTACTED YAMAHA AND WAS TOLD THAT THEY WOULD NOT REPLACE THE LOCK MECHANISM UNLESS THERE WAS A VEHICLE SAFETY RECALL ORDERED BY NHTSA. ACCORDING TO THEIR PARTS WEBSITE, THEY HAVE REPLACED THE ORIGINAL LOCK MECHANISMS WITH A DIFFERENT ONE ON NEWER MODELS AND NO LONGER SELL THIS PART. PART NUMBER IS 5P5-28406-01-00. THIS NEW PART IS A REPLACEMENT FOR THE ORIGINAL, DEFECTIVE PART- PART NUMBER 5JW-W9451-02-00. *TR
NHTSA ODI #10426681
Mileage unknown · Jan 30, 2008
Electrical SystemStructure
THE TURN SIGNAL INDICATORS ARE THE SIZE OF PENCIL ERASERS AND ARE LOCATED OUT OF VIEW ON THE INSTRUMENT CLUSTER. THEY ARE NOT VISIBLE WITH PERIPHERAL VISION DURING NORMAL DRIVING WITH THE EYES ON THE ROAD. IN ORDER TO SEE THEM THE DRIVER MUST TAKE HIS EYES OFF THE ROAD AND TILT HIS HEAD AND HELMET DOWN. THEY ARE NOT SELF CANC…
Read full complaint
THE TURN SIGNAL INDICATORS ARE THE SIZE OF PENCIL ERASERS AND ARE LOCATED OUT OF VIEW ON THE INSTRUMENT CLUSTER. THEY ARE NOT VISIBLE WITH PERIPHERAL VISION DURING NORMAL DRIVING WITH THE EYES ON THE ROAD. IN ORDER TO SEE THEM THE DRIVER MUST TAKE HIS EYES OFF THE ROAD AND TILT HIS HEAD AND HELMET DOWN. THEY ARE NOT SELF CANCELING. THEY HAVE NO AUDIBLE OR TACTICAL INDICATORS AND THE VISUAL INDICATORS ARE INSUFFICIENT. CONSEQUENTLY AFTER MAKING A TURN THE DRIVER IS UNAWARE THAT THE TURN SIGNALS ARE STILL ON AND MAY DRIVE FOR MANY MILES THIS WAY. MY SELF AND OTHER DRIVERS OF THE 06-07 FJR1300 SERIES HAVE HAD NUMEROUS INCIDENTS AND CLOSE CALLS OF VEHICLE TRAFFIC ENTERING OUR PATH BECAUSE THEY THOUGHT WE WERE ABOUT TO MAKE A TURN. *TR
YAMAHA IS RECALLING CERTAIN MODEL YEAR 2006-2009 FJR1300 MOTORCYCLES MANUFACTURED FROM FEBRUARY 2006, THROUGH MARCH 2009. THE GROUND JOINT CONNECTOR OF THE WIRE HARNESS COULD OVERHEAT AND BECOME DEFORMED, POSSIBLY CAUSING AN INTERMITTENT GROUND WIRE CONNECTION. IF THE ELECTRICAL SYSTEM IS NOT PROPERLY GROUNDED, THE IGNITION SYSTEM AND/OR OTHER ELECTRICAL COMPONENTS COULD MALFUNCTION, WHICH COULD CAUSE THE ENGINE TO STALL.
Consequence & remedy
Consequence: IF THE MOTORCYCLE STALLS WHILE BEING RIDDEN, THERE COULD BE A CRASH RESULTING IN INJURY OR DEATH.
Remedy: YAMAHA DEALERS WILL INSTALL AN ADDITIONAL WIRE SUB-LEAD OR, IF THE GROUND JOINT CONNECTOR HAS ALREADY BEEN DAMAGED FROM OVERHEATING, DEALERS WILL INSTALL A NEW MAIN WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2011. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.
YAMAHA IS RECALLING 9,300 MY 2006-2009 FJR1300 MOTORCYCLES. THE INTERNAL SWITCH WIRING COULD BECOME DISCONNECTED. IF THIS OCCURS ELECTRICAL CURRENT FLOW WILL BE STOPPED AND THE ENGINE COULD STALL.
Consequence & remedy
Consequence: IF THE ENGINE STALLS, THE OPERATOR MAY BE UNABLE TO START OR RESTART THE ENGINE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 16, 2009. OWNERS MAY CONTACT YAMAHA AT 1-800-962-7926.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Yamaha FJR1300 Problems, Complaints & Recalls | Skip That Year
Illustration