TL*THE CONTACT OWNS A 2002 WINNEBAGO JOURNEY DL. WHILE DRIVING LESS THAN 40 MPH, THE CONTACT NOTICED THAT THE REAR BEDROOM SLIDE WAS PROTRUDING APPROXIMATELY 3 INCHES. HE PULLED OVER AND EXITED THE VEHICLE IN AN ATTEMPT TO RETRACT THE SLIDE AND NOTICED SMOKE RISING FROM THE ENGINE COMPARTMENT. MINUTES LATER, HE HEARD AN EXPLO…
Read full complaint
TL*THE CONTACT OWNS A 2002 WINNEBAGO JOURNEY DL. WHILE DRIVING LESS THAN 40 MPH, THE CONTACT NOTICED THAT THE REAR BEDROOM SLIDE WAS PROTRUDING APPROXIMATELY 3 INCHES. HE PULLED OVER AND EXITED THE VEHICLE IN AN ATTEMPT TO RETRACT THE SLIDE AND NOTICED SMOKE RISING FROM THE ENGINE COMPARTMENT. MINUTES LATER, HE HEARD AN EXPLOSION NEAR THE REAR OF THE VEHICLE AND REALIZED THAT THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE WITHIN ONE MINUTE. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE MANUFACTURER STATED THAT SINCE THE VEHICLE WAS OUT OF WARRANTY, THEY WERE NOT RESPONSIBLE FOR THE FAILURE. THE CONTACT BELIEVED THAT THE FIRE WAS CAUSED BY THE HYDRAULIC LINES RUNNING ACROSS THE EXHAUST SYSTEM. THE HYDRAULIC LINE BEGAN TO LEAK ONTO THE EXHAUST SYSTEM AND CAUSED THE ENGINE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 50,000. UPDATED 10/03/07 *TR
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
Consequence & remedy
Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.
VEHICLE DESCRIPTION: MOTOR HOMES (MODELS WKP36L, WKP36LD, AND IKP36LD). FOUR NUTS MAY HAVE LOOSENED FROM THE FOUR BOLTS THAT CONNECT THE LIQUID PROPANE (LP) TANK TO THE MOTOR HOME. IF THE ATTACHMENT HARDWARE IS LOOSENED, THE ROAD VIBRATION COULD PRODUCE UNDUE STRESS ON THE WELD JOINTS OF THE BRACKETS AND THEY COULD BREAK.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE TANK COULD FALL OFF, RESULTING IN A ROAD HAZARD OR A FIRE.
Remedy: DEALERS WILL INSPECT THE LP TANK ATTACHMENT AND RE-TIGHTENED THE FASTENERS IN ADDITION TO ADDING LOCK NUTS. OWNER NOTIFICATION BEGAN AUGUST 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Winnebago Journey Dl Problems, Complaints & Recalls | Skip That Year
Illustration