THE LEFT SIDE THE ROOF CAME LOOSE SITTING IN STORAGE FROM WINDS OF A LESSER SPEED THAN IF ONE WAS DRIVING 55 MPH. THERE HAS BEEN CASES WHERE THE ROOF ON THESE MODELS HAVE CAME LOOSE WHILE DRIVING. THE ROOF MEMBRANE IS BIG ENOUGH TO BLOCK A FOLLOWING VEHICLES VIEW IF IT WERE TO COME OFF IN TRAFFIC. THIS IS A COMMON PROBLEM FOR TH…
Read full complaint
THE LEFT SIDE THE ROOF CAME LOOSE SITTING IN STORAGE FROM WINDS OF A LESSER SPEED THAN IF ONE WAS DRIVING 55 MPH. THERE HAS BEEN CASES WHERE THE ROOF ON THESE MODELS HAVE CAME LOOSE WHILE DRIVING. THE ROOF MEMBRANE IS BIG ENOUGH TO BLOCK A FOLLOWING VEHICLES VIEW IF IT WERE TO COME OFF IN TRAFFIC. THIS IS A COMMON PROBLEM FOR THIS MODEL YEAR. IT IS CAUSED BY IMPROPER INSTALLATION AT THE FACTORY. THIS PROBLEM NEEDS TO BE ADDRESSED BEFORE A DEATH OCCURS DUE TO THIS MALFUNCTIONING BODY PART. LAWS IN SOME STATES ARE VERY STRICT IN SECURING LOADS, THIS MALFUNCTION SHOULD BE ADDRESSED BY WINNEBAGO. *TR
NHTSA ODI #10454923
Mileage unknown · Jul 27, 2004
Structure
DEFECTS INVOLVING 1999 WINNEBAGO CHIEFTAIN'S DUCT CONNECTION BETWEEN THE EXTERNAL FRESH WATER TANK AND THE MOTORHOME.*MR THE CONSUMER INDICATED THAT THE OPENING ON THE UNDERSIDE OF THE MOTORHOME ALLOWED DIRT, WATER, INSECTS AND RODENTS COMPLETE ACCESS TO THE INTERIOR OF THE MOTORHOME. THE MANUFACTURER REFUSED TO ACCEPT ANY FIN…
Read full complaint
DEFECTS INVOLVING 1999 WINNEBAGO CHIEFTAIN'S DUCT CONNECTION BETWEEN THE EXTERNAL FRESH WATER TANK AND THE MOTORHOME.*MR THE CONSUMER INDICATED THAT THE OPENING ON THE UNDERSIDE OF THE MOTORHOME ALLOWED DIRT, WATER, INSECTS AND RODENTS COMPLETE ACCESS TO THE INTERIOR OF THE MOTORHOME. THE MANUFACTURER REFUSED TO ACCEPT ANY FINANCIAL RESPONSIBILITY FOR THE REPAIR OF THE PROBLEM. *NM
NHTSA ODI #10083394
12,000 miles · Jun 7, 2003
Structure
ROOF BLEW OFF WHILE DRIVING DOWN THE HIGHWAY. REAR STRUCTURE HAD TO BE REBUILT DUE TO FAULTY STEEL AND CONSTRUCTION. *JB
NHTSA ODI #10021205
Mileage unknown · Apr 27, 2001
StructureCrash
I WILL FAX COMPLETE DETAIL AS IT EXCEEDS 2000 CHARACTERS 04/27/01 AM PLEASE ATTACH TO THIS FORM FAX TO 202-366-7882. NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #744634
Mileage unknown · Jul 16, 1999
Structure
ROOF STRUCTURE WAS POPPING OFF DUE TO IMPROPER FACTORY INSTALLATION. MJS
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO IS RECALLING MY 1999-2002 ULTIMATE ADVANTAGE, ULTIMATE FREEDOM, MY 1999-2001 CHIEFTAIN, MY 2000-2001 BRAVE, MY 2001 JOURNEY MY 2000 MINNIE WINNIE, MY 2000-2002 ITASCA HORIZON, MY 1999 SUNCRUISER, MY 2001 SUNFLYER, AND MY 2000 SUNRISE MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
Consequence & remedy
Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 442, 443, 452, EV452, 453, 462, EV462, 463, EV463, 482, EV482, 483, EV483, 874, AND 875. THESE REFRIGERATORS CAN EXPERIENCE A BREAK DOWN IN A RUBBER SEAL WITHIN THE GAS VALVE. AS THE RUBBER SEAL AGES, A LEAK MAY OCCUR, ALLOWING PROPANE GAS TO ACCUMULATE IN THE BURNER AREA.
Consequence & remedy
Consequence: THE CONSEQUENCE CAN RESULT IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT GAS VALVE FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR WINNEBAGO AT 641-585-3535.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Winnebago Chieftain Problems, Complaints & Recalls | Skip That Year
Illustration