IllustrationREAR DRIVE AXLE CAUGHT FIRE. (OHIO TRAFFIC CRASH REPORT).
1996 Western Star Conventional
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Conventional years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Power Train complaints
1 reportsOfficial recalls
396V124003 · Suspension
Aug 1, 1996
THE EQUALIZING BEAM SHAFT OF THE TANDEM AXLE SUSPENSION WERE MANUFACTURED FROM AS-ROLLED SAE4140 STEEL RATHER THAN THE SPECIFIED ANNEALED SAE4140. THESE SHAFTS CAN FRACTURE INSIDE THE BEAM AT THE TOE OF THE WELD.
Consequence & remedy
Consequence: VEHICLES ARE SUBJECT TO VEHICLE TILT AND POSSIBLE ROLLOVER IN THE EVENT THAT BOTH EQUALIZING BEAMS, ON THE SAME SIDE OF THE VEHICLE, EXPERIENCE A SIMULTANEOUS SHAFT FAILURE. AFFECTED SUSPENSIONS CAN ALSO DROP AND CONTACT THE ROAD SURFACE GENERATING SPARKS WHICH COULD IGNITE FLAMMABLE MATERIAL.
Remedy: OWNER NOTIFICATION IS BEING CONDUCTED BY NEWAY ANCHORLOK. DEALERS WILL INSPECT AND REPLACE ALL SUSPENSION SUSPENSION BEAMS WITH SUSPENSION BEAMS CONTAINING APPROPRIATE SHAFTS.
96V100000 · Electrical System:wiring:interior/under Dash
Jun 17, 1996
THE WINDSHIELD WIPER ARM CAN INTERFERE WITH THE MAIN CAB DASH HARNESS WHICH PASSES BEHIND THE CENTER DASH SECTION. THE WIPER ARM CAN WEAR THROUGH ONE OR MORE OF THE WIRES IN THE HARNESS AND CAUSE A SHORT CIRCUIT.
Consequence & remedy
Consequence: IN ELECTRONIC ENGINES (CATERPILLAR ONLY) OR DDA ENGINES, THE ENGINE WOULD STOP. IF THE ENGINE WERE TO STOP SUDDENLY WHEN THE VEHICLE WAS TRAVELING AT A HIGH RATE OF SPEED AND MANEUVERING THROUGH TRAFFIC, THERE WOULD BE A POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL MODIFY THE MAIN CAB WIRING HARNESS ROUTING.
96V053000 · Service Brakes, Air
Mar 27, 1996
THESE TRUCKS WERE NOT BUILT WITH INVERSION VALVES DUE TO A PROGRAMMING ERROR. THE INVERSION VALVE PROVIDES MODULATED SPRING BRAKE APPLICATION DURING EMERGENCY BRAKING WHEN THE "A" PORTION OF THE AIR BRAKE SYSTEM HAS FAILED.
Consequence & remedy
Consequence: IN AN EMERGENCY SITUATION, THE BRAKE SYSTEM WOULD NOT WORK PROPERLY INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSTALL AN INVERSION VALVE IN THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.