2022 Volvo XC90

The electrical/infotainment display failure causes the factory rearview camera image not to display when the vehicle is shifted into reverse. The center infotainment display on my 2022 Volvo XC90 intermittently goes completely black and remains inoperable for days at a time. When the screen is black, the factory rearview camera image does not display when the vehicle is shifted into reverse. All sound, including warning signals, is inoperable. Climate controls are also inaccessible through the screen, and inoperable. This has happened repeatedly: the screen goes dark for several days, returns temporarily, then goes dark again. The failure affects rear visibility during backing events and creates a safety risk because the driver cannot see the rear camera image. I brought the vehicle to a Volvo dealer. The dealer stated that the infotainment head unit must be replaced and quoted approximately $4,000 to replace it with the same non-Google system. Volvo corporate denied assistance. I believe this is a safety-related defect because the failed infotainment display disables the rearview camera function.

There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months after the fix, the SAME issue is happening.

My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as required, and taken care of it as responsible vehicle owners. Beginning around June or July of 2025, I began seeing the "check engine" light, so I called the dealership where I purchased the vehicle and took it in for servicing. After a day, they said it was fixed and that it was a blown fuse or two, and it was good to go. Not even 3 weeks to a month later, the "check engine" light came on again. I called and took it back to the dealership. Same story, after less than a day they called me back after fixing something else (don't remember off the top of my head what they said it was, but it was allegedly minor). Now, about 3 days ago, Sept. of 2025, I began seeing the "check engine" light again, so for the 3rd time in less than 3 months I arranged for it to be serviced by the dealership again on 9/30. A day later, another "Propulsion System/maintenance required!!!" light came on as well, so I called to get servicing sooner because obviously the message is scary. I was told to bring it in, they would "work me in" but had no loaners I could use to get to and from work. So, at that point, I got my husband involved and now no one from the dealership is returning either of our calls, AND I'm being told there is no recall on my car, even though a simple google search reveals there is a recall on my same make/model/year SUV. I'm getting the same messages people got about the recall, so no clue why my vehicle isn't considered as part of the recall when I am having the SAME issues as the recalled vehicles are having. I am beyond frustrated and ready to dump this SUV if they are unable to properly repair it!!!!!

I park my Volvo in my driveway which has a blind exit to a pedestrian sidewalk. When I start the car and put it in D or B mode, it does not make any sound. This happens in any of the vehicle modes including "Pure" electric where the ICE is not engaged unless the battery runs out. There is no way for oncoming pedestrians to hear the vehicle or to understand that it might pull out of the blind corner. According to the NHTSA Federal Motor Vehicle Safety Standard Number 141 "The final rule requires hybrid and electric vehicles to emit sound at minimum levels while the vehicle is stationary (although not when the vehicle is parked, i.e., when the transmission is in “park”), while in reverse, and while the vehicle is in forward motion up to 30 km/h. (sic) full compliance should be by September 1, 2020" Our 2022 XC90 T8 Recharge does not make any sound while stationary in N, D, or B tranmission modes or while in Hybrid or Pure drive modes. I see this as a serious safety issue and wanted to report it before I have an actual safety incident. Volvo claims that my vehicle is in compliance with all NHTSA safety standards. Their response is attached.

The contact owns a 2022 Volvo XC90. The contact received notification of NHTSA Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I received an SRS airbag, service urgent, drive to workshop warning. I took the car in six times the first two times they said it was a software update and they failed to update the software the third time they updated the software. It didn’t work the fourth time they said it was the passenger seat and the scale wasn’t working or connecting so it was throwing off the airbag. They fixed that, it didn’t change that warning. I still got the warning. And the last time they said it was a battery issue the battery wires weren’t connecting. They fix that, but after five minutes of driving out of the dealership and a repair shop, the warning came up again.I’ve sent an email to Corporate asking for either a refund or or a new car in accordance with the lemon law of California. They want me to take it in the seventh time which I refuse to do because the car is on safe safe to drive and I have two kids that I cannot keep driving in this car.

There have been three incidents where the following happens: While driving in regular suburban driving, the entire infotainment system and cluster panel (all digital--odometer, tachometer, everything) shut off entirely (go black) and the climate system also shuts off. It goes through some reset cycle and then eventually restarts after several seconds. Both times it has been right after pressing some button on the steering wheel that controls the infotainment or doing some operation with the infotainment system such as skipping a track or making a call. Apple Car Play has not been in use. The first time it was 4-5 months ago (2024). The second time was about 2 months ago. The third time was on June 6, 2024. This third time, while at a red light, everything went black and even the car shut off. Luckily, the car was not moving and within a couple of seconds, without touching anything or changing anything, it restarted itself and the infotainment system and cluster rebooted. I am concerned that this may eventually happen while the car is moving. Will be taken to the dealer for review/repair immediately.

The contact owned a 2022 Volvo XC90. The contact stated that while driving in stop-and-go traffic, the odor of smoke was suddenly present inside the vehicle and moments later smoke was viewed coming from under the hood. The vehicle was stopped and moments after exiting the vehicle the vehicle was engulfed in flames. The fire department was called to the scene and extinguished the flames. During the incident, the vehicle and property inside the vehicle were destroyed. A fire report was taken at the scene and the vehicle was towed to the local towing yard. The cause of the fire was not yet determined. The manufacturer was not yet notified of the failure. The local dealer was contacted. The failure mileage was 11,000