While driving, I experienced a sudden loss of braking assist with no warning. The brake pedal became extremely hard to press, accompanied by a hissing/air sound. Despite applying full pressure, the vehicle did not slow as expected and continued moving. At one point, after stopping, the vehicle began to move forward again while …
Read full complaint
While driving, I experienced a sudden loss of braking assist with no warning. The brake pedal became extremely hard to press, accompanied by a hissing/air sound. Despite applying full pressure, the vehicle did not slow as expected and continued moving. At one point, after stopping, the vehicle began to move forward again while my foot remained firmly on the brake. The issue occurred immediately upon or shortly after starting the vehicle, with no prior warning indicators. This created a serious safety hazard.
NHTSA ODI #11732913
Mileage unknown · Mar 10, 2026
Service Brakes
Driving on a 45 mph road and brakes felt squishy, like air was going out of them. It was slow to stop and had to pump then stomp to get it to stop before crashing. Was fortunate to not hit anything. Pulled into gas station and had it towed to Volvo. There were no warning lights or other indication of problem- the brakes just fa…
Read full complaint
Driving on a 45 mph road and brakes felt squishy, like air was going out of them. It was slow to stop and had to pump then stomp to get it to stop before crashing. Was fortunate to not hit anything. Pulled into gas station and had it towed to Volvo. There were no warning lights or other indication of problem- the brakes just failed. Volvo said the vacuum pump failed which pushed oil into the brake booster causing it to fail. The car has 74,000 miles and has been serviced regularly.
NHTSA ODI #11723187
78,500 miles · Nov 28, 2025
Service BrakesService Brakes, Hydraulic
The contact owns a 2021 Volvo XC90. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle failed to respond unless the brake pedal had been released for 2-3 seconds. Additionally, the contact stated that upon starting the vehicle and releasing the brake pedal to reverse out of the driveway, the …
Read full complaint
The contact owns a 2021 Volvo XC90. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle failed to respond unless the brake pedal had been released for 2-3 seconds. Additionally, the contact stated that upon starting the vehicle and releasing the brake pedal to reverse out of the driveway, the vehicle rolled back at a faster speed, and the vehicle failed to respond as intended upon depression of the brake pedal. The contact noticed a pattern with the brakes malfunction. The contact stated that the brake pedal required to be depressed 2-3 seconds after the first depression for the brakes to operate as intended. The contact stated that he was a master mechanic and had concluded that the failure was considered a safety issue because the vehicle was only designed with electronic braking, which left the driver with no manual option for braking. The contact stated that the failure had only occurred upon starting the vehicle. The contact related the failure to NHTSA Campaign Number: 25V392000 (Service Brakes, Hydraulic, Service Brakes); however, the VIN was not included. The vehicle was taken to the dealer, where it was diagnosed that the brakes had failed and Software Update Number: 3.5.14 was needed. The vehicle was not repaired. The manufacturer was informed of the failure, and it was confirmed that the repair was not covered under the recall or under warranty. The failure mileage was approximately 78,500.
NHTSA ODI #11701862
Mileage unknown · Sep 9, 2024
Forward Collision AvoidanceService BrakesWheels
The brakes did not work when the automatic emergency braking turned on. When I pressed the brakes all the way down, the brakes didn’t respond because it was still in automatic mode. I was able to swerve into the next lane to not hit the vehicle in front of me. The automatic emergency braking also turned on when I was reversing f…
Read full complaint
The brakes did not work when the automatic emergency braking turned on. When I pressed the brakes all the way down, the brakes didn’t respond because it was still in automatic mode. I was able to swerve into the next lane to not hit the vehicle in front of me. The automatic emergency braking also turned on when I was reversing from a parked location when there was a vehicle waiting to park behind me and my vehicle stoped and didn’t come off of brake/park mode. I had to turn my vehicle on and off again to get it to move again. I have taken my vehicle in twice for shaking. My back rotors were replaced 2 weeks ago but my vehicle still shakes. This car only has around 21,000 miles to have so many issues already with rotors and shaking.
NHTSA ODI #11613402
Mileage unknown · Jul 16, 2023
Electrical SystemService BrakesUnknown Or Other
The infotainment system has locked up and has shut completely off while driving. When it shuts down (screen goes black) or glitches, the car actually loses power. Luckily it powered right back on but it was scary and could happen again and be much worse. The screen/ infotainment system has had this issue for awhile. We’ve even t…
Read full complaint
The infotainment system has locked up and has shut completely off while driving. When it shuts down (screen goes black) or glitches, the car actually loses power. Luckily it powered right back on but it was scary and could happen again and be much worse. The screen/ infotainment system has had this issue for awhile. We’ve even told Volvo of Tulsa about it when it was in for service but they said they couldn’t do anything about it because they couldn’t reproduce the issue. We have also had the brakes and rotors replaced twice at the dealership because they seem to be lemons or faulty. We are currently dealing with vibration once again (conveniently now the warranty is out).
NHTSA ODI #11532602
Mileage unknown · Sep 27, 2022
Service Brakes
My Xc90 is shuttering at interstate speeds as well as below. When I purchased, they had to machine the rotors and said they balanced the front tires. It did not help much. The brakes shake less. I'm sure the entire rotors are warped. All this with 12k miles on the vehicle.
NHTSA ODI #11486819
2,000 miles · Jan 20, 2021
Forward Collision AvoidanceService Brakes
ELECTRIC PARKING BRAKE ENGAGING VIOLENTLY AT HIGHWAY SPEEDS AT LEAST. 3 TIMES. RESULTING IN ABRUPT STOP IN MOVEING TRAFFIC! DEALER IN NO HURRY TO REPAIR SUGGESTING BRING BACK WHEN THEY ARE ABLE! AM NOTIFYING VOLVO, DEALER , THEY WILL ASSUME ALL LIABILITY FOR INJURY OR DEATH FOR THIS DEFECT AND LACK OF CONCERN IN REPAIRING…
Read full complaint
ELECTRIC PARKING BRAKE ENGAGING VIOLENTLY AT HIGHWAY SPEEDS AT LEAST. 3 TIMES. RESULTING IN ABRUPT STOP IN MOVEING TRAFFIC! DEALER IN NO HURRY TO REPAIR SUGGESTING BRING BACK WHEN THEY ARE ABLE! AM NOTIFYING VOLVO, DEALER , THEY WILL ASSUME ALL LIABILITY FOR INJURY OR DEATH FOR THIS DEFECT AND LACK OF CONCERN IN REPAIRING ( TOLD A SOFTWARE PROBLEM , BUT ALSO TOLD CAUSED DAMAGE TO OTHER COMPONENTS DUE TO VIOLENT AND ABRUPT STOPS! VERY UNCOMFORTABLE ESPECIALLY SINCE REPAIR MGR IS SO ARROGANT!
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence & remedy
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Electrical System:software
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Consequence & remedy
Consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Consequence & remedy
Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Service Brakes, Hydraulic
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Additional source detail variants (3)
Seat Belts:rear/other:retractor
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Seat Belts:front:retractor
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Seat Belts
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence & remedy
Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
Additional source detail variants (3)
Air Bags: Air Bag/restraint Control Module
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
Seat Belts:pretensioner
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
Air Bags
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2021 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration