2016 Volvo XC90

The contact owns a 2016 Volvo XC90. The contact stated that both oil and coolant would frequently be added to the engine as both the check engine and oil warning lights would appear on the instrument panel. The vehicle was taken to the dealer on multiple occasions where the crank shaft seal and fuel injectors were replaced; however, the failure persisted. One day while driving at 50 MPH, the vehicle began to hesitate upon depression of the accelerator pedal as the turtle warning light appeared on the instrument panel which indicated that there was reduced engine performance. The contact managed to drive the vehicle to Herb Chambers Volvo Cars of Norwood(1120 Providence Hwy #1, Norwood, MA 02062) where they were informed that contact that the fourth engine chamber had burned out which lead to engine failure. The manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 93,000.

The left rear door of my vehicle flew open while we were moving with my 10-year-old daughter sitting adjacent to the door. Fortunately, she had her seat belt on otherwise the result would have been tragic. On [XXX] my daughter got into the back of my vehicle, suddenly, her door flew open, I immediately stopped the vehicle. My daughter was unable to shut the door and after many attempts I got the door to shut. When we arrived at home both rear doors would not open and my now trapped daughter exited through the front door. On [XXX], I went to Volvo in Rochester NY and explained the situation expecting the service person to be extremely concerned. Much to my surprise he said “that happens all the time” and that when it gets cold out sometimes the latches don’t respond. I anticipated that my car would go in immediately but was told “how is Thursday to bring your car in.” I dropped my car off and received a call that afternoon with “great news” that the issue was a faulty door latch, the part was in stock and came with a “lifetime warranty.” He told me the cost was $734.00 per door meaning with sales tax the cost would be over $1,500 and I would still have two doors at risk for flying open in the future. I asked how this life safety issue which has failed on countless other vehicles is not covered by the manufacturer nor has there been a recall. He said Volvo has recognized the door latch safety issue and designed a fix. When the door latch fails, this new replacement part, that the consumer pays for, solves the problem. Volvo recognized a safety problem, designed the fix, yet has chosen not to recall the vehicles that have these problems but rather waits until the door latch fails before the consumer must pay to replace it. I arrived the next day to pick up my vehicle, sat down with the service manager who was empathetic, but reiterated this is an issue that has repeatedly occurred. This needs to be addressed and not paid by consumers INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

The engine is burning oil due to a factory design defect in the piston ring design, as verified by Volvo through a technical bulletin. In the bulletin, Volvo states that there is a free oil consumption test available for up to 100k miles. However, once I brought the car in for the test, they denied doing it for free and did not send any notice by mail. Burning oil can lead to a fire risk and loss of power while driving on the highway, which can cause serious accidents. Their published bulletin confirms the issue. The car has not been inspected, and there are no warning lights.

Hi, I had a 2016 XC90 which has serious safety problems. The sunroof has a factory defect, leaking water into the car and causing failures in electronic systems and airbags. Many other owners have sued Volvo and won their cases. Additionally, the issue has been certified by the court, and there are technical bulletins published by Volvo addressing the problem. Yes. The water leak can damage entire electronic systems, such as airbags, the start-stop system, braking system, and lidar system. Once water enters any of these systems, it can lead to accidents and fires due to short circuits, posing a deadly risk. This issue can cause accidents or fires. No, but Volvo has published a bulletin, and there have been many court cases filed against Volvo since 2016. No, the vehicle has not been inspected. It's causing numerous random errors on the dashboard. This issue occurred approximately two weeks after I purchased the vehicle. link for class action [XXX] .) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car has a factory fault with the Windshield Wiper or Turn Signal contact switch, which is causing the inability to use the left/right signal and the wipers. The entire part is factory faulty, rendering the vehicle unable to operate safely. This affects visibility during wet conditions because the wipers cannot be activated due to the malfunctioning switch, which can lead to serious accidents. Additionally, malfunctioning left/right turning signals can also cause serious accidents, as it is a crucial function. Yes, the vehicle is available upon request. I contacted Volvo, but they declined to fix the issue. They have published a technical bulletin regarding the problem but are not recalling the vehicles. Many other Volvo models have the same factory defect, as can be found on the internet. The technical bulletin confirms their fault. I have attached the file. No, the vehicle has not been inspected. Yes, the vehicle shows a "turn indicator malfunction" message on the main screen. This issue started around 89k miles.

It started with the right rear passenger door not opening from the inside or outside of the car. At first you could lock the doors from the inside and then open the door, but now the door will not open at all. My left rear passenger door has started to do the same thing this week. It will only open about 50% of the time. The door handles are in good order, and this is not related to an accident. This is an extremely dangerous situation for my kids! If we were in a car accident or if there was a fire in the car they would not be able to escape. I have attempted to contact customer service, but have not been able to get a hold of them.

This Volvo was bought in Worcester, Massachusetts. We used to live in USA before moving to our home country The Netherlands. Taking the Volvo with us. For many months the car consumes extreme amounts of oil. Indicating low oil every time. We need to refill every 1200-2000 km. We notified our Volvo dealer over and over again when having scheduled maintenance. No thorough inspection was done. We felt unsafe when traveling long distances, afraid the engine would break down or insecure about the oil consumption and what was causing it. We had an independent Volvo specialist inspect the car and he knew there is a design flaw in the cylinder pistons. The full problem was described by Volvo in technical journal [XXX]. Due to the fact that the Volvo dealer did not take the problem seriously, we had been driving with this problem way too long causing extreme cylinder defects resulting in having to replace the entire engine with a new one. We feel this matter should have been addressed better by Volvo and we request compensation for the costs made. We also don’t understand why Volvo didn’t recall this batch of cars that were designed with too small cylinder pistons for the capacity of the engine causing heavy oil consumption. We look forward to your reaction. As we live in The Netherlands, kindly e-mail. The Volvo importer of The Netherlands was also contacted, but they redirected us to you as the car was bought in the USA. We have a full repair report that can be shared upon request. Also the faulty engine is still with the Volvo specialist as proof of the described problems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rear driver's side door has the door lock motor fail and the door is unable to be opened from either the inside or outside. I was not in an accident, but had I been this would have been incredibly dangerous for passengers in the back seat of the car. Per discussions with my repair shop, this component should not fail and they have done numerous repairs on this problem on other cars of the same model.