IllustrationVehicle is slightly off-balance no matter if I do an alignment ball joints seem to always get affected. I’m not sure if the hydraulics are working correctly. Yesterday I just started leaking antifreeze fluid.
2006 Volvo XC90
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Volvo XC90 do not stand out strongly from the model-year median of 34.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC90 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
525–50K
350–75K
275–100K
14100–150K
5150K+
41 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports4 fire reports3 injury reports
Exterior Lighting complaints
4 reportsTL* THE CONTACT OWNS A 2006 VOLVO XC90. THE CONTACT STATED THAT THE HEADLIGHTS HAD MALFUNCTIONED AND WOULD NOT ILLUMINATE. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HER THAT THE COMFORT ELECTRONIC MODULE (CEM) WOULD NEED TO BE REPLACED. IN ADDITION, THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. AFTER THE DIAGNO…
Read full complaint
TL* THE CONTACT OWNS A 2006 VOLVO XC90. THE CONTACT STATED THAT THE HEADLIGHTS HAD MALFUNCTIONED AND WOULD NOT ILLUMINATE. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HER THAT THE COMFORT ELECTRONIC MODULE (CEM) WOULD NEED TO BE REPLACED. IN ADDITION, THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. AFTER THE DIAGNOSIS, THE TECHNICIAN ADVISED THAT THE CEM ALSO WAS THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000. THE VIN WAS UNAVAILABLE.
2006 VOLVO XC90 HEADLAMP FAILURE. WA.STATE VOLVO REP. DENIES INTERMITTENT HEADLAMP FAILURE EXISTS. THIS IS A HUGE SAFETY ISSUE. THE VOLVO HEADLIGHTS JUST FAIL WHEN THE VEHICLE IS BEING DRIVEN! I AND MANY OTHERS APPROX.93,487 OWNER'S OF THIS VEHICLE HAVE SPENT THOUSANDS OF DOLLARS HAVING VOLVO SERVICE DEALER'S UNABLE TO CORRECT T…
Read full complaint
2006 VOLVO XC90 HEADLAMP FAILURE. WA.STATE VOLVO REP. DENIES INTERMITTENT HEADLAMP FAILURE EXISTS. THIS IS A HUGE SAFETY ISSUE. THE VOLVO HEADLIGHTS JUST FAIL WHEN THE VEHICLE IS BEING DRIVEN! I AND MANY OTHERS APPROX.93,487 OWNER'S OF THIS VEHICLE HAVE SPENT THOUSANDS OF DOLLARS HAVING VOLVO SERVICE DEALER'S UNABLE TO CORRECT THE SERIOUS PROBLEM. THIS SHOULD BE A PRIORITY SAFETY RECALL AND VOLVO SHOULD IMMEDIATELY SEND OUT A SERVICE BULLETIN TO ALL DEALERSHIPS. APPARENTLY VOLVO DOES KNOW THIS PROBLEM EXISTS AND HAS PURPOSELY CHOSEN TO NOT CORRECT THE PROBLEM OR TO ACKNOWLEDGE THE SERIOUS SAFETY ISSUE. VOLVO OWNER'S ARE AT RISK OF SERIOUS INJURY OR DEATH. WHILE DRIVING THE VOLVO THE HEADLAMPS FLICKER AND FAIL . THE DRIVER USUALLY A MOTHER WITH CHILDREN IN THE CAR IS SUDDENLY PLUNGED INTO DARKNESS AT ANY GIVEN SPEED AND AT NIGHT. PLEASE HELP ALL OF US MOTHERS WHO BELIEVE WE MADE THE BEST DECISION TO PROVIDE" SAFETY FIRST" FOR OUR FAMILY'S . THIS NEEDS TO BE A PRIORITY SAFETY RECALL . HAVING THE HEADLIGHTS FAIL WHILE DRIVING IS PUTTING INNOCENT LIVES IN GRAVE DANGER. *TR
INTERMITTENT LIGHTING FAILURE IN THE VOLVO XC90 2006 MODEL. THE HEADLAMPS JUST FAIL. VOLVOS ARE SUPPOSED TO BE SAFE. MY FAMILY AND I COULD HAVE BEEN SERIOUSLY INJURED OR WORSE. I HAVE SPENT THOUSANDS OF DOLLARS TO FIX THE ISSUE AND I STILL HAVE THE PROBLEM. I CAN NOT DRIVE AT DUSK OR AT NIGHT BECAUSE OF THIS. *TR
Official recalls
310V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
06V155000 · Steering:linkages:tie Rod Assembly
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V144000 · Visibility:windshield Wiper/washer
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.