2022 Volvo XC60

This Volvo XC60 B8 has a serious deficiency with the 12v system and main Battery where it discharges below 10v when the vehicle sits idol for more than a week. Every 7-10 day interval the vehicle must be jump-started and driven for 30 min to recharge the 12v system. The vehicle reports itself in limp-mode until the 12v system charges above 11v then switches to normal drive mode for the remainder of the 30 min drive. I installed a battery tender to the POS and NEG posts under the hood but it charges the mild hybrid battery to full then disables continued charging of the 12v system, leaving the 12v main battery under voltage and draining while the car sits idol. We have to drive the vehicle for 30 minutes every 4-5 days to keep the battery charged. Not even Audi or Lamborghini require this much attention to their 12v systems like this 2022 Volvo. This dis-charging issue happens in all types of weather, all year long, and under any parked condition (locked or unlocked) and the factory battery charger only works on the hybrid battery, not the 12v system battery. I have owned other hybrid vehicles that can sit idol for weeks or months at a stretch and will start without issue. While parked, my Camry XLE (Toyota Synergy system mechanically disconnects their traction battery and simultaneously engages the 12v system to keep the Vehicle "aware" via sensors) will sit for months until I return to drive it normally. Volvo dealerships accept this behavior as normal although my experience with hybrid vehicles implies the opposite. I have not been able to uncover any online research that describes my issue with any resolution from Volvo or successful 3rd party auxiliary internal or external charging systems. it has been researched by Volvo to be 'within normal operating parameters'.

while attempting an OTA software update, the update failed. The instrument cluster was inoperative, it was a complete blank screen. Not able to tell how fast you were going, what gear you were in, how much gas you had. All features displayed on the instrument cluster were not available. Contacted Volvo to attempt a software reset, and all attempts were not successful.

What component or system failed or malfunctioned, and is it available for inspection upon request? -The backup camera system fails to respond intermittently. Often times the screen will remain black for several seconds while backing up before the screen shows any picture. Other times it will come on, and then flash to black while you are backing up. This is a major hazard should a child run/walk behind a car, when this occurs. I'm hoping others have expressed this problem so action can be taking. How was your safety or the safety of others put at risk? -Since Backup cameras are a federal requirement since 5/2018. The Failure to function on these new cars I find to be unacceptable. Even more so given that Volvo is supposed to be a brand dedicated to safety. Has the problem been reproduced or confirmed by a dealer or independent service center? -Indirectly yes, the Volvo dealership acknowledged that the new Google system is slow to respond at times. But they said a new software update would fix it. I have found this to not be the case and it seems to be happening more frequently now. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -yes by the dealer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -no

Feb. 1, 2024: A short drive on electric during below zero weather, a car wash & a couple 100ft drive into a parking lot. Pulling into a parking space, foot on the brake pedal, ICE roared on accelerating the car over a curb, down an embankment & into a 3ft snow drift before I could stop it by pressing the brake pedal with both feet. We stopped 6in from a power pole. If forward crash avoidance system worked, didn't register in the EEPROM per the service tech! Feb. 17, 2024, during below zero weather, no electric charge, operating on ICE over about 2mi, Pulled into a parking space, foot on the brake pedal, ICE surged accelerating the car up over a 6" high curb onto sidewalk. Stopped car by depressing the brake pedal with both feet. Car stopped 2in before hitting a brick building. It didn't seem the forward crash avoidance system functioned to stop us. As a 35-year electronic design and repair professional, I have attempted to merge the two situations to try to find similarities. Two things: unexpected ICE engine acceleration surge & forward collision sensor not kicking on brakes. Per Volvo tech, Feb. 1, no register in EEPROM of forward crash avoidance or ICE issues. Second visit Feb. 22 to service will probably yield same. Obviously, this is not normal operation. We have been in two near collisions caused by the car doing things not designed to do.

The contact owns a 2022 Volvo XC60. The contact stated that on several occasions while the vehicle was turned on, the radio cluster and instrument panel failed to illuminate. Additionally, the contact stated that he and his wife observed a clicking sound coming from the engine compartment when the vehicle was turned off. The vehicle was taken to a dealer however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 1,500.

TWO PIRELLI SCORPION ZERO TIRES (255/40 R21) RECEIVED ON 2022 VOLVO XC60 RECHARGE AS ORIGINAL EQUIPMENT DEVELOPED MISSING SQUARES/ CHUNKS OF RUBBER IN THE TREAD AREA. THE TWO TIRES MISSING TREAD WERE ORIGINALLY ON THE FRONT AND WERE ROTATED TO THE REAR FOR ADDED SAFETY. ALL 4 MATCHING TIRES WERE DISPOSED AT THE VOLVO DEALER. VOLVO XC60 COULD NO LONGER BE SAFELY DRIVEN AFTER THE REAR DRIVER SIDE TIRE PICKED UP A SCREW. THE SAFETY ISSUE WAS POINTED OUT DURING AN ATTEMPT TO HAVE THE TIRE REPAIRED BECAUSE IT WAS LOSING AIR. THE TECHNICIAN STATED A TIRE REPAIR WOULD INVOLVE CUTTING/SCRAPING THE TREAD FOR INSTALLATION OF A PATCH. THEY BELIEVED THAT THE TIRE WOULD RUPTURE UPON APPLICATION OF A PATCH. SIMILAR DAMAGE WAS FOUND ON THE SECOND TIRE BUT IT WOULD STILL HOLD AIR. ON DIFFERENT OCCASIONS, TWO VOLVO DEALERS AND NTB/MAVIS EXAMINED THE TIRES. ON THE FIRST OCCASION, IT WAS THE VOLVO DEALERS OPINION THE DAMAGE WAS CAUSED BY ALIGNMENT. THEY WOULD NOT REPLACE THE TIRES UNDER WARRANTY. SECOND TIME AT NTB/MAVIS THEY BELIEVED THE TIRE CONSTRUCTION WAS FAULTY AND UNSAFE TO REPAIR. THIRD INSPECTION BY A VOLVO DEALER THOUGHT IT MAY HAVE BEEN CAUSED BY DRIVING OVER GRAVEL/SHARP ROCKS. A LOW PRESSURE WARNING APPEARED ON THE INSTRUMENT PANEL. THE TIRE HAD LOST SOME AIR AND WOULD NOT HOLD AIR LONG WHEN REFILLED. VOLVO'S DEALER REPLACED THE PIRELLI TIRE THAT WOULD NOT HOLD AIR, BUT WOULD NOT REPLACE THE OTHER THREE IN THE SET. MATCHING PIRELLI TIRES COULD NOT BE OBTAINED, SO A SET OF MICHELIN TIRES WERE INSTALLED. OWNER WAS REQUIRED TO PAY FOR THREE, VOLVO COVERED ONE TIRE COST BECAUSE IT WOULD NOT HOLD AIR. NTB/MAVIS ADVISED THEY HAVE DISCONTINUED STOCKING THE PIRELLI SCORPION ZERO TIRE.

Our tires are Continental 255/45R20. It blowouted today when we were on the freeway with the speed at 65 miles per hour. We pulled our car to the shoulder of freeway after the rear driver side tire was blowouted. The tire was completed damage with many explore holes. We can see the bulges too. Our car is only one year old. The tire on right front in the passenger side was blowouted in March this year and we had replaced it. We can prove this tire is a defect tire.

I have had 5 visits with problems with engine , braking sensors, and automatic braking incidents when no obstruction is noted. Propulsion System failure has occurred 3+ times and turtle mode has come on and limited my speed to 30 MPG. It has also started bouncing and shaking while in reverse. I am extremely concerned about the safety threats and lack of consistency when taking it to be repaired.

The vehicle performed an over the air update which failed. The vehicle became inoperable. The vehicle was force started with dash lights indicating multiple system failures. The infotainment system has crashed multiple times rendering climate control non usable. A loaner 2023 XC60 was provided which also resulted in the infotainment center crashing twice. Dealership acknowledged the issue but has no solution for the issue. My concern is there is no guarantee the other safety features are functioning correctly if the most simple electrical component of the vehicle is failing.