2021 Volvo XC60

The contact owns a 2021 Volvo XC60. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact pulled over to the shoulder, and the vehicle continuously turned on and off independently. The check engine warning light was illuminated. The vehicle was towed to the dealer, who determined that the auxiliary battery power was low and that the vehicle needed a software update. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 18,000.

August 23rd, 2024, the car started hesitating when gas was applied. The transmission light came on, then the parking brake light came on saying it was turned off, the check engine light came on, the volvo on call light came on, and the car wouldnt turn off. I moved the shift into different gears, and was able to turn the car off. I waited a while and started the car again. This time the on call, and check engine light stayed on. I called the dealership, was told it was probably a low battery. Had me come in Monday the 26th to have it checked. But Saturday the car wouldn't start right away, and all the warning lights came back on and wouldn't shift gears. Had to call AAA to have it towed. Got a call from the dealership Monday August 26th. Was told they were testing the battery to see if it fails so they could replace it under warranty. They ended up replacing the battery, and told me there was a lot of water in the trunk under the spare tire, where the battery for the on call is located. Said there was a gap in the sunroof weather stripping where tree debris probably clogged the drain pipes. They cleaned that out, and replaced the sunroof weather stripping which was under warrenty. But I was told the water and clogged pipe was not under warrenty, and had to pay for that? September 6th, 30k service and check the on call light that never went off. They found 1.5 inches of water under my front carpet and will be checking for electrical damage and corrosion. They told me this is not covered under the warranty and advised to call my insurance. My safety concern is future electrical issues/ failures while driving. At any time something could malfunction. Thats a huge safety concern and not feeling safe to drive the car. There is nothing about this huge problem in the warranty or maintenance to check the drains !!! September 9th I will call the claims department and notify the adjuster. Also call back the dealership. Prior to this I've had no problems with the car.

6/8/23: Vehicle in shop for 30K warranty service. Front brake pads flagged yellow for wear. Recommendation they be addressed next visit at 40K miles. By 35K, Brake pedal was vibrating and steering wheel shaking upon moderate braking. Made appt. With local dealer which required over a month wait. 1/5/24: Dealer confirmed problem. Despite their own Technical Service Bulletin [XXX], dated [XXX], which recommended warranty replacement of brake pads, the service writer, Joe Barber at Volvo of St. Louis, 7700 Manchester Rd. refused to follow the manufacturer's recommendations. Instead, he quoted me a complete front brake job, to include rotors and pads for $920. I declined. With over 50 years of driving experience, not once have I owned a vehicle with brake/rotor failure with so few actual miles driven (mostly highway). Dealer claims this is normal for Volvo cars. Supposedly, one of the safest cars made for many years. I filed a written complaint with the Service Mgr. when he sent me a customer satisfaction survey. No response. Also filed a complaint with Volvo North America in Mahwah, NJ. They also quickly denied any responsibility, claiming normal wear and tear. Unable to upload documentation from my phone, but can do so by PC scan if allowed. Please advise. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Volvo XC60 equipped with Continental Tires, Tire Line: Cross Contact, Tire Size: 255/45/R20, DOT: (N/A). The contact stated while driving approximately 65 MPH, the rear passenger’s side tire had a blowout. The vehicle was taken to an independent mechanic where it was confirmed that there was a sidewall blowout. The tires were not replaced. The tires were the original tires. The manufacturer was notified of the failure. The approximate failure mileage was 17,000.

While driving, lost power very suddenly. A turtle comes across the dash. My vehicle wouldn’t start for roughly 20 minutes. After the 20 minutes, it starts up, but the check engine light is on. Nervous that my car isn’t safe to drive, I contact corporate Volvo, since there is NO information in the manual for what this means- they told me to contact my local. So I call them and they state it’s safe to drive and they could get me into the schedule 3 weeks out…. Then, I get to my appointment and they then tell me my brakes and rotators are completely shot at 42,000 miles.

My car continued to move even with the brake pedal pressed, and collision avoidance systems did not turn on. This is very unsafe - a car that doesn’t respond when the driver brakes puts everyone else on the road in danger. The first time this happened was on Sep. 6, 2022. I was driving on the highway when the car in front of me stopped abruptly. I started to brake. The distance between our cars was large enough that I should have been able to stop safely, but my car continued to move. I was unable to stop the vehicle and crashed into the car in front of me. At the time, I thought it was my fault. Although there was damage to my car, luckily no one was injured. (This was resolved, and my car was repaired, with help from Shelter Insurance.) On June 13, 2023, I was pulling up to a red light behind another vehicle. I stepped on the brakes and my car jolted to a stop (I had to push the pedal down very hard to get my car to start slowing down). Then my car began to move again, even though I had not released the brake pedal. It was moving at about 1-2 mph. My car got so close to the car in front of us that the parking sensors began to beep. We would have run into the stationary vehicle if I hadn’t put my car in Neutral. When the light switched to green I put my car in Drive again. At the next intersection the brakes were back to normal, and my car was driving as before. I had my car towed to the local Volvo dealership. After an inspection, I was told they hadn’t found anything wrong. I left my car at the dealership for further investigation, and was given a loaner. I don’t know if there is a connection, but both times this happened, I had been driving on the highway at high speeds (70 mph) for a few hours before trying to brake.

1.What component or system failed or malfunctioned, and is it available for inspection upon request? Blind spot sensor repeatedly malfunctioning. Vehicle generates "service required" message, and it appears that blind spot monitors fail to illuminate. Child safety locks also deactivate without driver input. Vehicle is currently available for inspection. 2. Has the problem been reproduced or confirmed by a dealer or independent service center? Dealer has updated the software multiple times but has not attempted to assess the hardware. 3. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. 4. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Drivers side door buttons periodically do not illuminate and do not operate windows or locks. Vehicle cannot be locked at times, or only passenger side doors can be locked. Key fob and manufacturer app only work to lock the vehicle sometimes. Issues began approximately July 2022 and have repeated intermittently. Issues seem to be occurring more frequently and for longer. Issues have been particularly frequent and long lasting in the last week; vehicle last serviced at the dealer approximately 12/22/2022.

I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.