Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Lane Departure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports0 fire reports4 injury reports

Forward Collision Avoidance complaints

6 reports

Clear category filter

Mileage unknown · Jun 15, 2023

Electrical SystemForward Collision AvoidanceService Brakes

Read full complaint

My car continued to move even with the brake pedal pressed, and collision avoidance systems did not turn on. This is very unsafe - a car that doesn’t respond when the driver brakes puts everyone else on the road in danger. The first time this happened was on Sep. 6, 2022. I was driving on the highway when the car in front of me stopped abruptly. I started to brake. The distance between our cars was large enough that I should have been able to stop safely, but my car continued to move. I was unable to stop the vehicle and crashed into the car in front of me. At the time, I thought it was my fault. Although there was damage to my car, luckily no one was injured. (This was resolved, and my car was repaired, with help from Shelter Insurance.) On June 13, 2023, I was pulling up to a red light behind another vehicle. I stepped on the brakes and my car jolted to a stop (I had to push the pedal down very hard to get my car to start slowing down). Then my car began to move again, even though I had not released the brake pedal. It was moving at about 1-2 mph. My car got so close to the car in front of us that the parking sensors began to beep. We would have run into the stationary vehicle if I hadn’t put my car in Neutral. When the light switched to green I put my car in Drive again. At the next intersection the brakes were back to normal, and my car was driving as before. I had my car towed to the local Volvo dealership. After an inspection, I was told they hadn’t found anything wrong. I left my car at the dealership for further investigation, and was given a loaner. I don’t know if there is a connection, but both times this happened, I had been driving on the highway at high speeds (70 mph) for a few hours before trying to brake.

NHTSA ODI #11527193

Mileage unknown · Apr 22, 2022

Electrical SystemForward Collision AvoidanceCrashInjury

Read full complaint

The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.

NHTSA ODI #11461792

Mileage unknown · Feb 23, 2022

Electrical SystemForward Collision AvoidanceUnknown Or Other

Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type

NHTSA ODI #11453722

Mileage unknown · Feb 17, 2022

Electrical SystemForward Collision AvoidanceUnknown Or Other

Read full complaint

Today my Sensus in the center console as well as instrument panel that shows the map between the gauges went black and switched my drive mode out of ECO, shutting off my cruise cintrol and turned off my Bluetooth phone call. Rebooted 3 times before becoming stable. This is unsafe and very dangerous. They just did a software update while it was in the dealership recently fixing an unrelated issue for a month. Now I have to try and get a video as they always try to claim they can't duplicate issues... I always have to take videos and recordings now...

NHTSA ODI #11452548

Mileage unknown · Aug 17, 2021

Forward Collision AvoidanceLane DepartureUnknown Or Other

Read full complaint

This is in regards to Pilot Assist. My husband and I purchased this vehicle in May of 2021. We have encountered several incidents (while using Pilot Assist). The car has directed us to different lanes, steered us to guardrails and other cars and has failed to break when cars have been stopped in front of us. We have taken the car in to our local Volvo dealership multiple times and they have still not corrected the issues. The first time we took the car in to the dealership, we were told (by the mechanic) it’s not a good system and it will never operate correctly. They have checked the sensors and hooked the car up to the computer and said it’s not sending off any codes, therefore there is nothing they can do. They have also test driven the car. The latest test drive, the mechanic left notes saying the car did start to drift in to the other lane but was corrected by the driver. However, he claims this is normal operation.

NHTSA ODI #11429521

Mileage unknown · Jul 12, 2021

Forward Collision Avoidance

Read full complaint

On two occasions the automatic breaking/city safety engaged on my Volvo XC60 2021 vehicle. In both incidences there was no need for this to happen. First incident (o/a June 25, 2021) occurred while changing lanes. There was traffic but said traffic was a safe distance in front of me. I was startled by the immediate hard stop breaking and safety belts tightening around me. No accident occurred. Only traffic behind me needing to break to avoid rear ending me. Even though shaken I continued on my way and put it behind me. Second incident (Jul 7,2021) occurred in the I95 tunnel heading to Baltimore. There was no vehicle directly in front of me. Only a vehicle vehicle at least 6 car lengths or more ahead. There was a tractor trailer beside me and vehicles behind me. Again the automatic breaking/city safety engaged. The vehicle came to a hard stop. I was shaken and even more frightened by what happened. No accident occurred. However, the vehicles behind me had to immediately break. I can’t express enough how horrifying these incidents were, especially in the I95 tunnel. I called the Volvo dealership where I bought the vehicle and took it in for service the next day. They ran diagnostics on the vehicle. No codes were shown during testing. I am afraid to drive this vehicle. I was told the automatic breaking/city safety cannot be turned off. I don’t want to sound over dramatic but I fear for my life, my family and others. I don’t want this vehicle. I want a vehicle that I have control over. This safety system has failed!! This system puts my life and others in danger!! The only explanation I received from dealer was that this system works on a camera and radar. I was nonchalantly told a glare from a vehicle or road sign could cause this. This all is alarming to me. What is my recourse?!?! I am aware there were problems with the automatic breaking in Volvos in 2019 & 2020. This was said to have been resolved through recalls. Im worried and afraid of Volvo XC60 2021!

NHTSA ODI #11424387

Official recalls

25V179000 · Electrical System:propulsion System:traction Battery; Electrical System:software

Mar 24, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

Consequence & remedy

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Additional source detail variants (2)

Electrical System:propulsion System:traction Battery

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Electrical System:software

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

23V001000 · Steering

Jan 5, 2023

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.

Consequence & remedy

Consequence: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.

Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.

21V716000 · Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Sep 15, 2021

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.

Consequence & remedy

Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.

Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.

Additional source detail variants (2)

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.

Consequence: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.

Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.

Service Brakes, Hydraulic

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.

21V682000 · Seat Belts; Seat Belts:front:retractor; Seat Belts:rear/other:retractor

Sep 1, 2021

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.

Additional source detail variants (3)

Seat Belts:rear/other:retractor

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.

Seat Belts:front:retractor

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Seat Belts

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

21V001000 · Air Bags; Air Bags: Air Bag/restraint Control Module; Seat Belts:pretensioner

Jan 7, 2021

Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.

Consequence & remedy

Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.

Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.

Additional source detail variants (3)

Air Bags: Air Bag/restraint Control Module

Consequence: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.

Remedy: Volvo Car will notify owners, and dealers will inspect and, as necessary, tighten the SRS control unit mounting screws, free of charge. The recall began February 12, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10068.

Seat Belts:pretensioner

Air Bags

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.