June 4, 2022, 2018 Volvo XC60 - Right rear door lock engaged and would not release from either inside or outside door handle with all doors electronically unlocked. No other doors were affected. The door remained locked until Volvo technician removed inside door panel and made temporary repair on June 6. Replacement lock asse…
Read full complaint
June 4, 2022, 2018 Volvo XC60 - Right rear door lock engaged and would not release from either inside or outside door handle with all doors electronically unlocked. No other doors were affected. The door remained locked until Volvo technician removed inside door panel and made temporary repair on June 6. Replacement lock assembly was not available until Friday, June 10 when it was replaced by the dealer. Lock failure put safety of rear passengers at risk and I did not allow passengers in the back seat until lock was replaced. There was no warning lamp or message indicating lock failure. Dealer service representative said the failure mode was mechanical. Repair made under warranty.
NHTSA ODI #11468783
21,300 miles · Feb 5, 2020
Service BrakesStructure
TL* THE CONTACT OWNS A 2018 VOLVO XC60. THE CONTACT STATED THAT THE DRIVER SIDE DOOR HANDLE ON THE INSIDE OF THE VEHICLE FRACTURED FOR THE SECOND TIME. THE VEHICLE WAS TAKEN TO (GUNTHER VOLVO CARS DELRAY BEACH 2201 N FEDERAL HWY, DELRAY BEACH, FL 33483) TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE BRAKE PADS AND ROUTERS WE…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLVO XC60. THE CONTACT STATED THAT THE DRIVER SIDE DOOR HANDLE ON THE INSIDE OF THE VEHICLE FRACTURED FOR THE SECOND TIME. THE VEHICLE WAS TAKEN TO (GUNTHER VOLVO CARS DELRAY BEACH 2201 N FEDERAL HWY, DELRAY BEACH, FL 33483) TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE BRAKE PADS AND ROUTERS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 21,300. *LN*JB
NHTSA ODI #11307312
4,000 miles · May 14, 2019
Air BagsElectrical SystemElectronic Stability Control (esc)CrashInjury
ON THE EVENING OF NOVEMBER 20, 2018 MY FAMILY AND I WERE IN A CAR ACCIDENT. MY DAUGHTER WAS DRIVING MY HUSBAND'S NEW XC60 THAT HE HAD RECENTLY PURCHASED. AS THE FIVE OF US SAT STOPPED AT A TRAFFIC LIGHT, 2 CARS COLLIDED AND ONE HIT US HARD ENOUGH FROM THE FRONT CORNER THAT THE IMPACT FORCED MY DAUGHTER BACK INTO THE SEAT AND T…
Read full complaint
ON THE EVENING OF NOVEMBER 20, 2018 MY FAMILY AND I WERE IN A CAR ACCIDENT. MY DAUGHTER WAS DRIVING MY HUSBAND'S NEW XC60 THAT HE HAD RECENTLY PURCHASED. AS THE FIVE OF US SAT STOPPED AT A TRAFFIC LIGHT, 2 CARS COLLIDED AND ONE HIT US HARD ENOUGH FROM THE FRONT CORNER THAT THE IMPACT FORCED MY DAUGHTER BACK INTO THE SEAT AND THEN PROPELLED HER FORWARD SLAMMING HER CHEST INTO THE STEERING WHEEL DESPITE HER WEARING HER SEATBELT. NO AIR BAGS DEPLOYED. THE DAMAGE TO THE CAR WAS SO EXTENSIVE IT TOOK OVER 2 MONTHS TO REPAIR. YET NO AIR BAGS DEPLOYED.
NHTSA ODI #11207490
Mileage unknown · Apr 8, 2019
Structure
TL* THE CONTACT OWNS A 2018 VOLVO XC60. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 19V046000 (STRUCTURE) AND STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. RUSNAK VOLVO (2025 E COLORADO BLVD, PASADENA, CA 91107) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFOR…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLVO XC60. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 19V046000 (STRUCTURE) AND STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. RUSNAK VOLVO (2025 E COLORADO BLVD, PASADENA, CA 91107) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
Volvo Car USA, LLC (Volvo) is recalling certain 2026 XC60MHEV, 2018 and 2025 XC60 vehicles. The front seat bolts may have been improperly tightened, resulting in loose bolts.
Consequence & remedy
Consequence: A seat with loose bolts may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will tighten the front seat bolts, free of charge. Owner notification letters were mailed December 17, 2025. Owners may contact Volvo's customer service at 1-800-458-1552. Volvo's number for this recall is R10345. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 5, 2025.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence & remedy
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Additional source detail variants (2)
Visibility/wiper
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Visibility:windshield Wiper/washer:linkages
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 XC60 and S90 vehicles. The driver and passenger front seat rail rear flange nuts may not have been installed during assembly.
Consequence & remedy
Consequence: If the nuts are missing, in the event of a crash, the front seat structure and position may be affected, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect the front seat rails for missing flange nuts, installing them as necessary, free of charge. The recall began May 7, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R19931.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 Volvo XC60 vehicles. Under certain conditions and cold temperatures, the tailgate lifting arms may freeze which may cause the lifting arms to separate from the vehicle.
Consequence & remedy
Consequence: If the tailgate lifting arms separate, the arms could project rearward with significant force, increasing the risk of injury.
Remedy: Volvo has notified owners, and dealers will replace the tailgate lift arms with an improved designed, free of charge. The recall began May 14, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89910.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Volvo XC60 Problems, Complaints & Recalls | Skip That Year
Illustration