I BOUGH THE CAR IN APRIL 2018 AND IN JUNE 2018 WITH THE CAR HAVING 1200 MILES ON BOARD, WHILE I WAS ON A TRIP 85 MILES AWAY FROM HOME, I'VE EXPERIENCED AN ENGINE FAILURE. AFTER A STOP ON THE TRIP, I PROCEEDED TO START THE CAR AND AFTER A FEW SECONDS OF RUNNING IT, A TICKING NOISE COMING FROM THE ENGINE COULD BE HEARD. ( IT SOUND…
Read full complaint
I BOUGH THE CAR IN APRIL 2018 AND IN JUNE 2018 WITH THE CAR HAVING 1200 MILES ON BOARD, WHILE I WAS ON A TRIP 85 MILES AWAY FROM HOME, I'VE EXPERIENCED AN ENGINE FAILURE. AFTER A STOP ON THE TRIP, I PROCEEDED TO START THE CAR AND AFTER A FEW SECONDS OF RUNNING IT, A TICKING NOISE COMING FROM THE ENGINE COULD BE HEARD. ( IT SOUNDED AS IF THE ENGINE WASN'T RECEIVING GAS). WITHIN A MINUTE THE CAR COMPLETED STOPPED. THE ENGINE TURNED OFF ON ITS OWN. I PROCEEDED TO TRY TO TURN THE ENGINE ON A COUPLE OF TIMES BUT THE CAR WOULDN'T COME ON. AT THE THIRD ATTEMPT THE CAR STARTED. AS SOON AS I STARTED TO DRIVE, THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. AFTER CALLING THE VOLVO DEALER SERVICE DEPARTMENT TO SCHEDULE AN APPOINTMENT FOR SERVICE, I WAS ADVISED THAT IT WOULD BE UNSAFE TO DRIVE THE CAR 60 MILES TO THE NEAREST AVAILABLE DEALER. I CONTACTED VOLVO ON CALL BUT BECAUSE THE CLOSEST DEALER WAS ALREADY CLOSED AND A LOANER CAR WAS NOT AVAILABLE, THE CAR WAS TOWNED THE NEXT DAY. THE MECHANIC DETERMINED THAT THE SENSOR TO THE FUEL PUMP NEEDED TO BE REPLACED. I WAS BLESSED THAT THE CAR DIDN'T STOP WHILE DRIVING ON THE FREEWAY OR ANY OTHER ROAD WITH OTHER CARS OR PEOPLE AROUND SINCE THE CONSEQUENCES COULD HAVE BEEN DEADLY.
Volvo Car USA, LLC (Volvo) is recalling certain 2026 XC60MHEV, 2018 and 2025 XC60 vehicles. The front seat bolts may have been improperly tightened, resulting in loose bolts.
Consequence & remedy
Consequence: A seat with loose bolts may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will tighten the front seat bolts, free of charge. Owner notification letters were mailed December 17, 2025. Owners may contact Volvo's customer service at 1-800-458-1552. Volvo's number for this recall is R10345. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 5, 2025.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence & remedy
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Additional source detail variants (2)
Visibility/wiper
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Visibility:windshield Wiper/washer:linkages
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Consequence: The risk of the front wiper arms nut fixation to loosen and not holding the arm in correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 XC60 and S90 vehicles. The driver and passenger front seat rail rear flange nuts may not have been installed during assembly.
Consequence & remedy
Consequence: If the nuts are missing, in the event of a crash, the front seat structure and position may be affected, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect the front seat rails for missing flange nuts, installing them as necessary, free of charge. The recall began May 7, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R19931.
Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 Volvo XC60 vehicles. Under certain conditions and cold temperatures, the tailgate lifting arms may freeze which may cause the lifting arms to separate from the vehicle.
Consequence & remedy
Consequence: If the tailgate lifting arms separate, the arms could project rearward with significant force, increasing the risk of injury.
Remedy: Volvo has notified owners, and dealers will replace the tailgate lift arms with an improved designed, free of charge. The recall began May 14, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89910.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Volvo XC60 Problems, Complaints & Recalls | Skip That Year
Illustration