IllustrationThe rain water leaking through windshield. It could cause rust in the frame, then cause the failure of whole structure. I checked the Volvo forums, seems there are many Volvo owners have similar issues. I owned other cars, it’s the first time I had leaking water through perimeter of windshield.
2012 Volvo XC60
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Volvo XC60 do not stand out strongly from the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC60 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 46 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
Structure complaints
4 reportsMy left front door failed to open using the outside handle. I have tried unsuccessfully to fix the problem by removing the inside door panel, the door window, and the surrounding hardware and electrical components. I contend that this is a safety hazard because a)a rescuer would fail to get the driver out of the vehicle in cas…
Read full complaint
My left front door failed to open using the outside handle. I have tried unsuccessfully to fix the problem by removing the inside door panel, the door window, and the surrounding hardware and electrical components. I contend that this is a safety hazard because a)a rescuer would fail to get the driver out of the vehicle in case of an accident and b)the door could open while driving because the latch contains a defective part. Other Volvo models have been recalled because of this problem, but my Vin number is currently not included in the recall. I contend that it should be recalled for my vehicle.
MY WINDSHIELD STARTED LEAKING ON THE DRIVER SIDE DURING A HEAVY RAIN STORM. WATER WAS DRIPPING IN STREAMS AND IMPEDED VISIBILITY. I HAD IT EVALUATED AND THERE IS A BREAK IN THE FACTORY SEAL. THE WINDSHIELD IS ORIGINAL EQUIPMENT. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS OR HAD ANY INJURIES. I SEE THAT THIS HAS BEEN A PROBLEM WI…
Read full complaint
MY WINDSHIELD STARTED LEAKING ON THE DRIVER SIDE DURING A HEAVY RAIN STORM. WATER WAS DRIPPING IN STREAMS AND IMPEDED VISIBILITY. I HAD IT EVALUATED AND THERE IS A BREAK IN THE FACTORY SEAL. THE WINDSHIELD IS ORIGINAL EQUIPMENT. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS OR HAD ANY INJURIES. I SEE THAT THIS HAS BEEN A PROBLEM WITH OTHER VOLVOS AS WELL.
I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DEPLOY ANYWHERE ON THE VOLVO. T…
Read full complaint
I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DEPLOY ANYWHERE ON THE VOLVO. THANKFULLY, NOBODY WAS SERIOUSLY HURT AS ALL WERE WEARING SEATBELTS. BASED ON THE SEVERITY AND SPEED OF THE IMPACT, I AM VERY SUPRISED AND CONCERNED THE AIRBAG SYSTEM DIDN'T FUNCTION.
Official recalls
320V378000 · Seat Belts:front
Jun 30, 2020
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
12V101000 · Structure:body
Mar 14, 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLES UNDERCARRIAGE.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE UNDERBODY COATING MAY PENETRATE THE FUELS LINES AND CAUSE FUEL LEAKAGE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
12V075000 · Electrical System:wiring
Feb 28, 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.
Consequence & remedy
Consequence: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.
Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.