Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Remedy: Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Consequence & remedy
Consequence: IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Remedy: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN TRUCKS, THE WHEEL SPACER MAY BECOME DISTORTED FROM HEAT WHICH POTENTIALLY COULD LEAD TO A LOSS OF CLAMP THAT MAY RESULT IN LOOSE WHEEL NUTS.
Consequence & remedy
Consequence: IF THE WHEEL NUTS LOOSEN FOR ANY REASON, DAMAGE TO THE WHEEL STUDS AND WHEEL MAY OCCUR, AND MAY LEAD TO A COMPLETE SEPARATION OF THE WHEELS FROM THE TRUCK WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WHEEL SPACERS AND THE WHEEL EQUIPMENT (WHEELS,STUDS, AND HUB) WILL BE INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
Consequence & remedy
Consequence: IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY-DUTY CLASS 8 TRUCKS, THE ASSEMBLED ENGINE PRE-HEATER JUMPER WIRING HARNESS WAS INCORRECTLY ASSEMBLED.
Consequence & remedy
Consequence: THE ENGINE PRE-HEATER COULD OVERHEAT RESULTING IN DAMAGE TO THE PRE-HEATER AND OTHER ENGINE HEAT SENSITIVE COMPONENTS NEAR THE PRE-HEATER AND THE ABILITY TO RE-START THE ENGINE COULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPAIR THE AFFECTED CIRCUITS IN THE JUMPER WIRING HARNESS CONNECTOR. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.
Consequence & remedy
Consequence: IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL REPLACE THE BRACKET PINS AND REPAIR INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JOST INTERNATIONAL AT 616-846-7700 OR BY EMAIL TO RECALL@JOSTINTERNATIONAL.COM OR VOLVO TRUCK AT 800-528-6586.
CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH AN OPTIONAL TWO-MAN PASSENGER BENCH SEAT FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." ON THE TWO-MAN PASSENGER BENCH SEAT INBOARD (CENTER) POSITION, SEAT BELT D-RING MOUNTING BRACKET WELDNUT, THE WELD IS NOT SUFFICIENT TO MEET THE SEAT BELT PULL REQUIREMENTS .
Consequence & remedy
Consequence: THESE TRUCKS DO NOT COMPLY WITH THE REQUIREMENTS.
Remedy: DEALERS WILL REPLACE THE SEAT BELT D-RING MOUNTING BRACKET. OWNER NOTIFICATION BEGAN ON APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS WITH VOLVO B-RIDE REAR SUSPENSION, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT COULD BREAK ALLOWING THE AFFECTED AXLE TO SHIFT OUT OF ALIGNMENT.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN LOSS OF AXLE STABILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE UPPER AXLE SEAT ON BOTH REAR DRIVE AXLES. OWNER NOTIFICATION BEGAN JANUARY 14, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
ON CERTAIN HEAVY DUTY CLASS 8 AXLE BACK VEHICLES, THE TELESCOPING STEERING SHAFT IN SOME DRIVING SITUATIONS COULD BOTTOM OUT AND SIDE LOAD THE STEERING GEAR INPUT SHAFT WHENEVER THE ADJUSTABLE STEERING COLUMN IS ADJUSTED TO THE LOWER POSITION.
Consequence & remedy
Consequence: OVER TIME, THIS CONDITION COULD DAMAGE THE STEERING GEAR INPUT SHAFT RESULTING IN LOSS OF VEHICLE CONTROL AND A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A RE-DESIGNED STEERING SHAFT, WHICH WILL NOT BOTTOM OUT DURING VEHICLE OPERATION REGARDLESS OF WHERE THE ADJUSTABLE STEERING COLUMN IS POSITIONED. OWNER NOTIFICATION BEGAN JUNE 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06054 · Inoperable Tail Lights
Opened Nov 16, 2006 · Closed Feb 7, 2007
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH THE TSB.VOLVO ALSO NOTED IN THEIR IR RESPONSE THAT THE TAIL LIGHT CONFIGURATION IS USED ALMOST EXCLUSIVELY ON TRACTORS THAT ARE NORMALLY ATTACHED TO SEMI TRAILERS.THEREFORE, THE TRACTOR LIGHTS ARE NORMALLY NOT THE REAR MOST LIGHTS ON THE VEHICLE.IN A NORMAL APPLICATION, EVEN IF ONE TAIL LIGHT ON THE TRACTOR WAS OUT, THE TAIL LIGHT ON THE TRAILER WOULD CONTINUE TO ILLUMINATE AND PROVIDE OTHER DRIVERS OF THE INTENTIONS OF THE SEMI TRAILER DRIVER.PURSUANT TO 49 CFR 396.11 & 13, A COMMERCIAL VEHICLE OPERATOR IS REQUIRED TO PERFORM A PRE-TRIP AND POST-TRIP INSPECTION, WHICH INCLUDES CHECKING THE FUNCTIONALITY OF THE TAIL LIGHTS.GIVEN THE ABOVE INFORMATION, ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH THE TSB.VOLVO ALSO NOTED IN THEIR IR RESPONSE THAT THE TAIL LIGHT CONFIGURATION IS USED ALMOST EXCLUSIVELY ON TRACTORS THAT ARE NORMALLY ATTACHED TO SEMI TRAILERS.THEREFORE, THE TRACTOR LIGHTS ARE NORMALLY NOT THE REAR MOST LIGHTS ON THE VEHICLE.IN A NORMAL APPLICATION, EVEN IF ONE TAIL LIGHT ON THE TRACTOR WAS OUT, THE TAIL LIGHT ON THE TRAILER WOULD CONTINUE TO ILLUMINATE AND PROVIDE OTHER DRIVERS OF THE INTENTIONS OF THE SEMI TRAILER DRIVER.PURSUANT TO 49 CFR 396.11 & 13, A COMMERCIAL VEHICLE OPERATOR IS REQUIRED TO PERFORM A PRE-TRIP AND POST-TRIP INSPECTION, WHICH INCLUDES CHECKING THE FUNCTIONALITY OF THE TAIL LIGHTS.GIVEN THE ABOVE INFORMATION, ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH THE TSB.VOLVO ALSO NOTED IN THEIR IR RESPONSE THAT THE TAIL LIGHT CONFIGURATION IS USED ALMOST EXCLUSIVELY ON TRACTORS THAT ARE NORMALLY ATTACHED TO SEMI TRAILERS.THEREFORE, THE TRACTOR LIGHTS ARE NORMALLY NOT THE REAR MOST LIGHTS ON THE VEHICLE.IN A NORMAL APPLICATION, EVEN IF ONE TAIL LIGHT ON THE TRACTOR WAS OUT, THE TAIL LIGHT ON THE TRAILER WOULD CONTINUE TO ILLUMINATE AND PROVIDE OTHER DRIVERS OF THE INTENTIONS OF THE SEMI TRAILER DRIVER.PURSUANT TO 49 CFR 396.11 & 13, A COMMERCIAL VEHICLE OPERATOR IS REQUIRED TO PERFORM A PRE-TRIP AND POST-TRIP INSPECTION, WHICH INCLUDES CHECKING THE FUNCTIONALITY OF THE TAIL LIGHTS.GIVEN THE ABOVE INFORMATION, ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal
ODI OPENED THIS INVESTIGATION BASED ON A TECHNICAL SERVICE BULLETIN AND EWR DATA. EWR WARRANTY DATA IS AGGREGATE DATA AND INDIVIDUAL REPORTS ARE NOT SUBMITTED.VOLVO REVIEWED THEIR WARRANTY DATA AND DETERMINED THAT ONLY 63 OF THE EWR WARRANTY CLAIMS RELATED TO THE SUBJECT VEHICLES DISPLAYED SYMPTOMS CONSISTENT WITH THE TSB.VOLVO ALSO NOTED IN THEIR IR RESPONSE THAT THE TAIL LIGHT CONFIGURATION IS USED ALMOST EXCLUSIVELY ON TRACTORS THAT ARE NORMALLY ATTACHED TO SEMI TRAILERS.THEREFORE, THE TRACTOR LIGHTS ARE NORMALLY NOT THE REAR MOST LIGHTS ON THE VEHICLE.IN A NORMAL APPLICATION, EVEN IF ONE TAIL LIGHT ON THE TRACTOR WAS OUT, THE TAIL LIGHT ON THE TRAILER WOULD CONTINUE TO ILLUMINATE AND PROVIDE OTHER DRIVERS OF THE INTENTIONS OF THE SEMI TRAILER DRIVER.PURSUANT TO 49 CFR 396.11 & 13, A COMMERCIAL VEHICLE OPERATOR IS REQUIRED TO PERFORM A PRE-TRIP AND POST-TRIP INSPECTION, WHICH INCLUDES CHECKING THE FUNCTIONALITY OF THE TAIL LIGHTS.GIVEN THE ABOVE INFORMATION, ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2002 Volvo Vhd Problems, Complaints & Recalls | Skip That Year
Illustration