NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
11 reportsClear category filter82,000 miles · Jan 27, 2009
Engine And Engine CoolingPower Train
OUR 2000 VOLVO XC70 STATIONWAGON EXPERIENCED SLUGGISH SPEED ON A WEDNESDAY - IT DID NOT LIKE TO ACCELERATE. IT WAS ALSO GOING THROUGH OIL, WHICH THE VOLVO DEALERSHIP SAID WAS "NORMAL" FOR A CAR OF THIS AGE - IT ONLY HAD 80,000 MILES ON IT. ON THURSDAY, THE CAR WOULD NOT START (IT WAS VERY COLD). WE TOOK THE CAR TO THE REPAIR …
Read full complaint
OUR 2000 VOLVO XC70 STATIONWAGON EXPERIENCED SLUGGISH SPEED ON A WEDNESDAY - IT DID NOT LIKE TO ACCELERATE. IT WAS ALSO GOING THROUGH OIL, WHICH THE VOLVO DEALERSHIP SAID WAS "NORMAL" FOR A CAR OF THIS AGE - IT ONLY HAD 80,000 MILES ON IT. ON THURSDAY, THE CAR WOULD NOT START (IT WAS VERY COLD). WE TOOK THE CAR TO THE REPAIR SHOP AND THEY FOUND THAT IT HAS OIL PUMP PROBLEM THAT DOES NOT GET OIL INTO THE ENGINE. WE THEREFORE NEED A NEW ENGINE. HE ALSO NOTED ISSUES WITH THE DRIVE TRAIN. *TR
NHTSA ODI #10256458
51,272 miles · May 19, 2007
Power Train
CONSISTENT GRINDING SOUND WHEN DRIVING. IT WAS DRIVESHAFT FAILURE. 2000 VOLVO XC HAD ONLY 56,021 MILES ON IT AND WAS DRIVEN 4 1/2 YEARS WHEN THIS BEGAN HAPPENING. PARTS/LABOR REPLACED. *AK
NHTSA ODI #10191244
98,490 miles · Apr 8, 2007
Power Train
ANGLE GEAR BROKE IN THE VOLVO V70XC AFTER 90000 MILES. *AK
NHTSA ODI #10187284
64,745 miles · Mar 13, 2007
Power Train
TL*- WHILE PARKING HER VEHICLE THE CONTACT HEARD A CRACKING NOISE COMING FROM UNDER THE HOOD OF THE 2000 VOLVO V70 XC. THE CRACKING NOISE WAS DUE TO THE TRANSMISSION ANGLE GEAR CRACKING. FIRST TIME THE CONTACT HAD TO REPLACE THE ANGLE GEAR WAS ON 04/17/03 AT 64,745 MILES, PART NUMBER WAS 8601587-2. THE CONTACT COULD PROVIDE…
Read full complaint
TL*- WHILE PARKING HER VEHICLE THE CONTACT HEARD A CRACKING NOISE COMING FROM UNDER THE HOOD OF THE 2000 VOLVO V70 XC. THE CRACKING NOISE WAS DUE TO THE TRANSMISSION ANGLE GEAR CRACKING. FIRST TIME THE CONTACT HAD TO REPLACE THE ANGLE GEAR WAS ON 04/17/03 AT 64,745 MILES, PART NUMBER WAS 8601587-2. THE CONTACT COULD PROVIDE INVOICE IF NEEDED. THE CURREN MILEAGE WAS 148,000.*AK
NHTSA ODI #10184950
45,597 miles · Nov 9, 2005
Power TrainVehicle Speed Control
E-MAIL: VEHICLE GOES INTO LIMP MODE, ETM LIGHT COMES ON, REPLACED TWICE, X REF 10129414, SMCH.*AK
NHTSA ODI #10143178
53,000 miles · Oct 24, 2005
Power TrainVehicle Speed Control
FAILURE OF THE THROTTLE CONTROL MODULE ON A 2000 VOLVO V70 CROSS COUNTRY, BEVEL GEAR FAILURE IS LIKELY AS WELL, BOTH ARE FREQUENT FAILURES AMONG OWNERS. *NM
NHTSA ODI #10140647
74,000 miles · Sep 14, 2005
Power Train
I PURCHASED A 2000 VOLVO XC AND HAVE HAD MANY PROBLEMS WITH THIS VEHICLE. I UNDERSTAND SOME OF THEM ARE VERY VERY COMMON AND I WAS TOLD I SHOULD REPORT THIS TO YOU. PROBLEM 1 ETS SYSTEM LIGHT IS NOW ON. PROBLEM 2..HAD TO REPLACE AWD UNIT. PROBLEM 3 HAD TO REPLACE BLOWER MOTOR FOR HEAT/AC. *JB
NHTSA ODI #10136460
Mileage unknown · Sep 8, 2005
Power Train
SUDDEN LOSS OF SPEED AND RANDOM STALLING. *NM
NHTSA ODI #10135874
61,000 miles · Jun 6, 2005
Power Train
WHILE ON A VACATION IN MONTANA OUR 2000 VOLVO XC70 HAD ROUGHT IDLE, STALLING, NO RESPONSE TO ACCELERATOR (WOULD NOT GO ABOVE 20 MPH) AND EVENTUALLY WOULD NOT START. THERE WERE NO VOLVO DEALERS IN MONTANA FOR REPAIR AND A LOCAL MECHANIC INSTRUCTED US TO PULL THE MAIN FUSE TO RE-SET THE COMPUTER. THIS WOULD GET US GOING AGAIN B…
Read full complaint
WHILE ON A VACATION IN MONTANA OUR 2000 VOLVO XC70 HAD ROUGHT IDLE, STALLING, NO RESPONSE TO ACCELERATOR (WOULD NOT GO ABOVE 20 MPH) AND EVENTUALLY WOULD NOT START. THERE WERE NO VOLVO DEALERS IN MONTANA FOR REPAIR AND A LOCAL MECHANIC INSTRUCTED US TO PULL THE MAIN FUSE TO RE-SET THE COMPUTER. THIS WOULD GET US GOING AGAIN BUT IT WOULD HAPPEN AGAIN EVERY 50 OR SO MILES. DEALERSHIP BACK AT HOME REPLACE THE ELECTRONIC THROTTLE MODULE AT A COST OF $1200. THERE APPEARS TO BE A HIGH NUMBER OF ETM FAILURES IN THESE CARS AND IT IS A KNOWN PROBLEM WITH VOLVO.
NHTSA ODI #10124360
88,100 miles · Jul 16, 2004
Power Train
DRIVE LINE ANGLE GEAR FAILED, CAUSING A BRAKING EFFECT ON CAR AS WELL AS "STICKING" WHEELS A LOW SPEED.CAR WAS VERY DIFFICULT TO MANUEVER WHEN THIS OCCURRED. WAS INFORMED BY VOLVO THIS IS A VERY COMMON AS WELL AS EXPENSIVE PROBLEM. DESIGN WAS CHANGED IN 2001 AS A RESULT OF THIS ISSUE. *AK
NHTSA ODI #10081219
NHTSA investigations
2EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
Illustration