IllustrationVolvo dealer confirmed Excessive oil burn due to bad piston rings. Volvo USA recalled other cars with the same problem but refused to recall mine. They offered instead partial payment for the fix. Should be full payment to repair.
2016 Volvo V60
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all V60 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 14 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Engine complaints
4 reportsTL* THE CONTACT OWNS A 2016 VOLVO V60. WHILE PULLING OUT OF THE DRIVEWAY, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE RPM'S WERE BETWEEN 4,000 TO 5,000. THE FAILURE WAS INTERMITTENT AND OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING; HOWEVER, THE DETAILS OF T…
Read full complaint
TL* THE CONTACT OWNS A 2016 VOLVO V60. WHILE PULLING OUT OF THE DRIVEWAY, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE RPM'S WERE BETWEEN 4,000 TO 5,000. THE FAILURE WAS INTERMITTENT AND OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING; HOWEVER, THE DETAILS OF THE DIAGNOSIS COULD NOT BE PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,502.
TL* THE CONTACT OWNS A 2016 VOLVO V60. WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 1,201.
VEHICLE WAS DRIVEN 150 MILES ROUNDTRIP. ON WAY BACK, ONE MILE FROM FINAL DESTINATION WHILE IN LEFT TURN LANE WAITING FOR ONCOMING TRAFFIC SO LEFT TURN COULD BE COMPLETED, THE AUTO START/STOPPED CAUSED THE ENGINE TO SHUT OFF AS THE CAR CAME TO A STOP. WHEN BRAKE WAS RELEASED CAR FAILED TO TURN BACK ON LEAVING CAR STRANDED IN MIDD…
Read full complaint
VEHICLE WAS DRIVEN 150 MILES ROUNDTRIP. ON WAY BACK, ONE MILE FROM FINAL DESTINATION WHILE IN LEFT TURN LANE WAITING FOR ONCOMING TRAFFIC SO LEFT TURN COULD BE COMPLETED, THE AUTO START/STOPPED CAUSED THE ENGINE TO SHUT OFF AS THE CAR CAME TO A STOP. WHEN BRAKE WAS RELEASED CAR FAILED TO TURN BACK ON LEAVING CAR STRANDED IN MIDDLE OF INTERSECTION. ATTEMPTED TO RESTART CAR UNSUCCESSFULLY. ALSO, CAR INSTRUCTED DRIVER TO PRESS "START BUTTON" UNTIL IT STARTED. HOWEVER, WHILE START BUTTON WAS DEPRESSED THE EMERGENCY FLASHERS/HAZARD LIGHTS WOULD GO OFF AND HAVE TO BE MANUALLY REENGAGED, MAKING IT DOUBLY UNSAFE.
Official recalls
420V378000 · Seat Belts:front
Jun 30, 2020
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
19V849000 · Latches/locks/linkages:doors:latch
Nov 26, 2019
Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.
16V798000 · Seat Belts:front:buckle Assembly
Nov 2, 2016
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
15V555000 · Electrical System:wiring:fuses And Circuit Breakers
Sep 2, 2015
Volvo Cars of North America, LLC. (Volvo) is recalling certain model year 2016 Volvo S60, V60, V60CC, XC60, XC70, and S80 vehicles manufactured April 8, 2015 to August 19, 2015. In certain driving conditions when using the automatic engine stop/start function, the starter motor fuse may blow, preventing the car from restarting when necessary.
Consequence & remedy
Consequence: If the vehicle is unexpectedly unable to be started in the middle of traffic, such as when stopped at an intersection, there is an increased risk of a crash.
Remedy: Volvo will notify owners, and dealers will replace the existing starter motor fuse with a higher amperage fuse, free of charge. The recall began on October 26, 2015. Owners may contact Volvo customer service at 1-800-458-1552 or by visiting http://volvo.custhelp.com. Volvo's number for this recall is R39574.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.