2012 Volvo S80

A batch of metal used for the steering wheel trim prematurely wears down at the base of the steering wheel in 2 locations out of sight with normal use and becomes razor sharp. When turning the wheel, the spinning razor edge can cause the driver to lose control due to sudden pain due to slicing into the fingers. The metal slices into the skin drawing blood much like that of a papercut. I have experienced sudden cuts in turning on 2 separate occasions recently having to re-grab the steering wheel due to involuntary pain reflex release to prevent total loss of control and the problem has not been confirmed by the dealer. There is no prior warning when this issue suddenly occurs.

MY WIFE KAREN WAS ON HER WAY TO WORK ON FEBRUARY 24, 2020 WHEN THE DRIVER SIDE-VIEW MIRROR DETACHED, HIT THE PAVEMENT AND SHATTERED. THE INCIDENT OCCURRED AT ABOUT 7:45 AM. THE VEHICLE HAD BEEN PARKED IN OUR DRIVEWAY AT 140 STATESIR PLACE FOR 60 HOURS WITHOUT BEING USED AND THE MIRROR SHOWED NO SIGN OF DAMAGE PRIOR TO BEING DRIVER. THE INCIDENT OCCURRED ABOUT 800 FEET FROM OUR RESIDENCE AS SHE WAS TURNING FROM STATESIR PLACE ONTO PINE STREET NEARER TO THE CORNER .

TL* THE CONTACT OWNS A 2012 VOLVO S80. WHILE DRIVING 35 MPH, THE CONTACT STATED THAT THE WHEEL STUDS FRACTURED FROM THE TIRE. AS A RESULT, THE VEHICLE SLID ONTO THE ROAD SHOULDER AND THE FENDER WAS RIPPED OFF. THERE WAS NO CRASH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THEN TAKEN TO DEMONDTROND VOLVO (VOLVO BUILDING, 14101 NORTH FWY, HOUSTON, TX 77090, (281) 607-0382). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 138,000.

THE PASSENGER DOOR CONTINUES TO OPEN AT HIGHWAY SPEEDS. I HAVE THE OPTION FOR DOORS TO LOCK WHEN CAR BEGINS TO MOVE. THE LOCK REMAINS "LOCKED" HOWEVER DOOR OPENS WITH INTERIOR LIGHTS AND DASHBOARD WARNING. I HAVE CONTACTED VOLVO TO NO END... I SEE A MULTITUDE OF DOOR OPENING ISSUES ON VOLVO FORUM SITES, AND MECHANIC STATES COMMON PROBLEM WITH VOLVO.

DRIVERS SIDE REAR SUSPENSION LINK ARM FAILURE. VEHICLE TRAVELING STRAIGHT AHEAD ON EXPRESSWAY AT POSTED SPEED, 70MPH, ROAD CONDITIONS DRY AND CLEAR. NO IMPACTS OR SUDDEN MANEUVERS PRIOR TO FAILURE, I.E. CHUCK HOLE OR DEBRIS. NO TIRE OR WHEEL DAMAGE SUSTAINED PRIOR TO OR AFTER SUSPENSION FAILURE. NO IMPACT EVIDENCED UNDERNEATH VEHICLE.

TL* THE CONTACT OWNS A 2012 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE WOULD JERK VIOLENTLY WHEN ACCELERATING TO A HIGH SPEED. IN ADDITION, THE TACHOMETER FLUCTUATED CAUSING THE VEHICLE TO JERK VIOLENTLY. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V317000 (POWER TRAIN). THE APPROXIMATE FAILURE MILEAGE WAS 45,800.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS 21 JUL 2013 - SUNDAY EVENING THE TIRE LOW PRESSURE WARNING LIGHT CAME ON WHEN I PARKED MY CAR IN THE GARAGE. I LOOKED AT ALL FOUR TIRES AND FOUND NOTHING WRONG. 22 JUL 2013 - MONDAY AS SAFETY PRECAUTION I TOOK THE VEHICLE IN FOR SERVICE AND HAD THE SENSOR CHECKED. THE VOLVO SERVICE DEPARTMENT STATED; THEY CHECK THE PRESSURE IN ALL TIRES FOR LEAKS, PROPER INFLATION AND THE LIGHT WENT OUT. 23 JUL 2013 - TUESDAY MORNING ON MY WAY TO WORK THE LIGHT CAME BACK ON. AGAIN; I LOOKED AT ALL FOUR TIRES AND FOUND NOTHING WRONG. *TR