I PURCHASED VEHICLE 8 MONTHS AGO I NOW HAVE PROBLEMS WITH THE FRONT AND BACK SUSPENSION. THE AIR TURNS ON ITS OWN, THE AXLE HAS BROKEN, THE SUNROOF OPENS WHEN IT WANTS TO OPEN, CHECK ENGINE LIGHT HAS TURNED ON ALONG WITH MAINTENANCE LIGHT, MY DOORS WILL UNLOCK THEMSELVES WHEN I LOCK THEM AND THE ALARM WILL ENGAGE, THE LEFT WIN…
Read full complaint
I PURCHASED VEHICLE 8 MONTHS AGO I NOW HAVE PROBLEMS WITH THE FRONT AND BACK SUSPENSION. THE AIR TURNS ON ITS OWN, THE AXLE HAS BROKEN, THE SUNROOF OPENS WHEN IT WANTS TO OPEN, CHECK ENGINE LIGHT HAS TURNED ON ALONG WITH MAINTENANCE LIGHT, MY DOORS WILL UNLOCK THEMSELVES WHEN I LOCK THEM AND THE ALARM WILL ENGAGE, THE LEFT WINDOW DOES NOT WORK , SOMETIMES I CANT UNLOCK THE DOORS HAVE TO UNLOCK WITH MY HAND. MY CRUISE CONTROL DOES NOT WORK, THE BATTERY STOPS WORKING OFTEN, THE INSIDE LIGHTS WORK SOMETIMES. IT IS RUNNING TERRIBLE , IDLE UP AND DOWN I KNOW ALL HAS SOMETHING TO DO WITH RECALL PLEASE HELP! *TR
NHTSA ODI #10488858
117,900 miles · Mar 15, 2010
Suspension
TL*THE CONTACT OWNS A 2001 VOLVO S80. WHILE DRIVING 5MPH TRAVELING OVER A SPEED BUMP THE LEFT FRONT TIRE SUDDENLY SEPARATED FROM THE LOWER BALL JOINT DAMAGING THE FRONT END OF THE VEHICLE .THE VOLVO MANUFACTURER HAD NOT BEEN CONTACTED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 117,900.
NHTSA ODI #10319917
71,000 miles · Jan 23, 2009
Fuel System, GasolinePower TrainSuspension
UPPER STRUT BUSHINGS CRACKED FRONT LOWER CONTROL ARM BUSHINGS FRONT LINK RODS REAR LINK RODS FLAME TRAP BOX LEAKING OIL THIS 2001 S80 VOLVO IS A PIECE OF JUNK TRIED TO HAVE THIS VOLVO WORK DONE PER THE EXTENDED WARR ULTIMATE I HAVE A PIECE OF JUNK. *TR
NHTSA ODI #10256112
Mileage unknown · Jan 12, 2007
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
MY 2001 VOLVO S80 T6 COST ME AROUND $3,500 IN REPAIRS/MAINTENANCE AFTER PURCHASE IN THE LAST 3 MONTHS. THIS CAR HAS SOMETHING GOING WRONG ONE THING AFTER ANOTHER. TO MENTION SOME: FRONT SWAY-BAR LINKS, TURBO CHARGER DRAIN, BAD ALTERNATOR (THAT CAUSE OTHER ELECTRONICS TO MALFUNCTION I.E. THE VEHICLE'S ENTIRE HEATING SYSTEM), IN-C…
Read full complaint
MY 2001 VOLVO S80 T6 COST ME AROUND $3,500 IN REPAIRS/MAINTENANCE AFTER PURCHASE IN THE LAST 3 MONTHS. THIS CAR HAS SOMETHING GOING WRONG ONE THING AFTER ANOTHER. TO MENTION SOME: FRONT SWAY-BAR LINKS, TURBO CHARGER DRAIN, BAD ALTERNATOR (THAT CAUSE OTHER ELECTRONICS TO MALFUNCTION I.E. THE VEHICLE'S ENTIRE HEATING SYSTEM), IN-CAR SENSOR FAILURE FOR INTERIOR AIR QUALITY , ELECTRONIC THROTTLE MODULE FAILURE THAT CAUSED ME TO HAVE THE VEHICLE TOWED TO THE VOLVO DEALERSHIP FOR $190, CATALYTIC CONVERTER FAILURE, OXYGEN SENSOR FAILURE, THE FRONT STRUTS AND MOUNTS NEED TO BE REPLACED, YET. MAINTENANCE WISE, THE 60K MAINTENANCE, WHICH THE DEALERSHIP NEVER MENTIONED THAT IT HAD BEEN COMPLETED ON THIS VEHICLE ( NO PAPER WORK FOR THE VEHICLE WAS PROVIDED TO ME AT THE TIME OF PURCHASE), THE BRAKES WENT BAD IN TWO WEEKS AFTER PURCHASE, THE TIRES NEEDED TO BE REPLACED, TOTAL COST: AROUND $2,000. I DON'T KNOW WHAT MORE TO EXPECT TO HAVE GONE WRONG ON THIS VEHICLE. THIS CAR HAS PUT ME THROUGH LOTS OF STRESS, WASTE OF TIME, AND LOSS OF MONEY. I BOUGHT THE VEHICLE FOR $14,000 AND HAS PUT IN ALMOST $3,500 AND IT'S NOT EVEN WORTH $17,000 IN THE MARKET AT THIS POINT. VOLVO NEEDS TO HAVE A RECALL ON THEIR SUSPENSION PROBLEMS (STRUTS, SWAY BAR LINKS, BUSHINGS) WHICH HAPPEN QUITE OFTEN AS I HAVE HEARD AND READ ON THE CONSUMER COMPLAINTS ONLINE, AND ALSO FOR THE ALTERNATOR FAILURE AND CAUSE AFTERWARDS. ALSO, IF THE CAR HAD TO BE TOWED BECAUSE OF A RECALL PROBLEM, THEY SHOULD COVER THE COST OF TOW SINCE THE PROBLEM WAS CAUSED BY THEIR RECALL ITEM. *NM
NHTSA ODI #10178602
Mileage unknown · Jul 8, 2005
Electrical SystemEngine And Engine CoolingExterior Lighting
2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVER…
Read full complaint
2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVERAL ELECTRICAL REPAIRS DONE ON THE VEHICLE, SUCH AS THE INTERIOR LIGHTS, THE POWER WINDOWS, THE BATTERY WAS DEFECTIVE WHICH HAD TO BE REPLACED TWICE, THE ALARM WOULD GO OFF FOR NO REASON, THE HEAD LIGHT BULBS AND TAIL LIGHT BULBS WERE REPLACED. THE KEY WOULD NOT TURN IN THE IGNITION, THE ENGINE LIGHT ILLUMINATED, THERE WAS A FRONT SUSPENSION NOISE WHEN GOING OVER BUMPS. THERE WAS A POWER STEERING LEAK DUE TO A LOOSE HOSE CLAMP. THE PARKING BRAKE NEEDED TO BE ADJUSTED, IT DID NOT HOLD ON AN INCLINE. *JB
NHTSA ODI #10130227
Mileage unknown · Feb 26, 2001
Suspension
WHEN TRAVELING OVER 45 MPH VEHICLE WONDERS TO LEFT OR RIGHT. IF HITTING ANY BUMPS IN ROAD CAR WILL GO IN THAT DIRECTION. *AK
NHTSA ODI #881404
Mileage unknown · Feb 23, 2001
Suspension
DEFECT WITHIN STEERING AND SUSPENSION. VEHICLE WILL NOT TRACK STRAIGHT, IT WILL WANDER TO LEFT AND RIGHT, CAUSING AN UNSAFE CONDITION. DEALER ATTEMPTED TO FIX DEFECT 3 TIMES , TIRE PRESSURE,ALIGNMENT AND ADJUSTED SUSPENSION, BUT DEFECT KEEPS OCCURRING. *AK
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2001 Volvo S80 Problems, Complaints & Recalls | Skip That Year
Illustration