Electrical SystemEngine And Engine CoolingExterior Lighting
2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVER…
Read full complaint
2001 VOLVO S80 SERIES DEVELOPED PROBLEMS WITH THE STEERING AND THE BRAKING SYSTEM.***NO ANSWER REQUIRED***. *MR WHILE EXITING A PARKING LOT, THE VEHICLE CEASED TO OPERATE. THE VEHICLE TOWED AND THE CONSUMER WAS ASSURED THE PROBLEM HAD BEEN RESOLVED, HOWEVER 8 MONTHS LATER THE INCIDENT HAPPENED AGAIN. THE CONSUMER HAD SEVERAL ELECTRICAL REPAIRS DONE ON THE VEHICLE, SUCH AS THE INTERIOR LIGHTS, THE POWER WINDOWS, THE BATTERY WAS DEFECTIVE WHICH HAD TO BE REPLACED TWICE, THE ALARM WOULD GO OFF FOR NO REASON, THE HEAD LIGHT BULBS AND TAIL LIGHT BULBS WERE REPLACED. THE KEY WOULD NOT TURN IN THE IGNITION, THE ENGINE LIGHT ILLUMINATED, THERE WAS A FRONT SUSPENSION NOISE WHEN GOING OVER BUMPS. THERE WAS A POWER STEERING LEAK DUE TO A LOOSE HOSE CLAMP. THE PARKING BRAKE NEEDED TO BE ADJUSTED, IT DID NOT HOLD ON AN INCLINE. *JB
NHTSA ODI #10130227
50,026 miles · Apr 3, 2005
Engine And Engine Cooling
MESSAGE IN VEHICLE DISPLAYED "NO OIL PRESSURE PULL OVER ASAP." WHILE PULLING OVER "ASAP" A BLUE PLUME OF SMOKE AND SHARDS OF METAL EJECTED FROM THE REAR OF THE CAR. VOLVO DEALERSHIP TOLD ME THAT THE CAR HAD THROWN A ROD AND THAT IT WILL COST $9,000 TO FIX THE CAR. *AK
NHTSA ODI #10116298
58,780 miles · Jun 9, 2004
Engine And Engine Cooling
DROVE 2001 VOLVO S 80 ON 6/6/04, WHEN PARKED IN GARAGE: COOLANT LEAKED OUT, ALL AT ONCE. REFILLED COOLANT AND DROVE TO DEALER ON MONDAY (6/7/04). CAR WAS JUST IN FOR 60,000 MILE SERVICE AT SAME DEALER A FEW WEEKS AGO. *AK DEALER STATED (QUOTE FROM RECEIPT): "ECM 6110, AND FAULT TRACED TO FAILED ENGINE COOLING FAN MODULE. RE…
Read full complaint
DROVE 2001 VOLVO S 80 ON 6/6/04, WHEN PARKED IN GARAGE: COOLANT LEAKED OUT, ALL AT ONCE. REFILLED COOLANT AND DROVE TO DEALER ON MONDAY (6/7/04). CAR WAS JUST IN FOR 60,000 MILE SERVICE AT SAME DEALER A FEW WEEKS AGO. *AK DEALER STATED (QUOTE FROM RECEIPT): "ECM 6110, AND FAULT TRACED TO FAILED ENGINE COOLING FAN MODULE. REPLACED ENGINE COOLING FAN MODULE AS DIAGNOSED TO REPAIR". (OLD PART LEFT AT DEALER) COST TO REPLACE: $505
NHTSA ODI #10075118
30,000 miles · Jan 15, 2004
Engine And Engine CoolingPower Train
COOLING SYSTEM PROBLEM MESSAGE DISPLAYED AT 29,500 MILES ...DEALER FOUND AND REPLACED CRACKED HOSES THAT CAUSED COOLANT LEAK. TRANSMISSION SERVICE URGENT MESSAGE CAME UP. DEALER REPLACED TRANSMISSION VALVE BODY PER VOLVO. TRANSMISSION FAILED AGAIN 36 HOURS LATER. NOW IN SHOP HAVING COMPLETE TRANSMISSION REPLACED AT 31000 MILES!…
Read full complaint
COOLING SYSTEM PROBLEM MESSAGE DISPLAYED AT 29,500 MILES ...DEALER FOUND AND REPLACED CRACKED HOSES THAT CAUSED COOLANT LEAK. TRANSMISSION SERVICE URGENT MESSAGE CAME UP. DEALER REPLACED TRANSMISSION VALVE BODY PER VOLVO. TRANSMISSION FAILED AGAIN 36 HOURS LATER. NOW IN SHOP HAVING COMPLETE TRANSMISSION REPLACED AT 31000 MILES! TRANSMISSION PROBLEM OCCURRED RIGHT AFTER 30,000 MILE SERVICE AT VOLVO AT COST OF $600. I ASKED VOLVO FOR DISCOUNT ON EXTENDED WARRANTEE... THEY REFUSED SAYING IF THEY DID IT FOR ME THEY WOULD HAVE TO DO IT FOR OTHERS.
NHTSA ODI #10069309
30,000 miles · Aug 19, 2003
Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control
AS THE CONSUMER WAS PULLING AWAY FROM CURB AT 3 MPH VEHICLE SUDDENLY ACCELERATED WITHOUT TOUCHING THE GAS. BRAKES WERE NOT FUNCTIONAL, AND VEHICLE SHOT THROUGH THREE INTERSECTIONS BEFORE THE EMERGENCY BRAKE WAS PULLED. MECHANIC INFORMED THE CONSUMER THAT MASS AIR FLOW SENSOR WAS FAULTY.*AK
NHTSA ODI #10034188
44,000 miles · Jul 28, 2003
Electrical SystemEngine And Engine CoolingVehicle Speed Control
ELECTRONIC THROTTLE ON 2001 VOLVO S80 FAILED AS I ATTEMPTED TO PASS SOMEONE. ENGINE WAS PROGRAMMED TO SHUT DOWN COMPLETELY. I WAS LEFT SPEEDING DOWN THE FREEWAY AT 70MPH WITHOUT STEERING!*AK
NHTSA ODI #10030298
38,000 miles · Jan 6, 2003
Engine And Engine Cooling
WHILE DRIVING AT ANY SPEED, VEHICLE WILL JUST SHUT DOWN. CONSUMER HAD VEHICLE SERVICED BY THE DEALERSHIP, THEY REPLACED THE MAS AIR FLOW SENSOR, BUT THE PROBLEM RECURED 2 MONTHS LATER. PLEASE PROVIDE MORE DETAILS. PH
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: SEDANS AND WAGONS. THE REAR OUTBOARD SEAT BELT ANCHORAGE BOLTS MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE ANCHORAGE BOLTS AND TIGHTEN TO THE CORRECT TORQUE LEVEL. OWNER NOTIFICATION BEGAN MAY 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2001 Volvo S80 Problems, Complaints & Recalls | Skip That Year
Illustration