Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1525–50K
3850–75K
3975–100K
36100–150K
13150K+
148 reports with mileage · 57 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports1 fire reports10 injury reports
What owners actually said
205 reports
Mileage unknown · Aug 30, 2005
Electrical System
MY CARS ELECTRONIC THROTTLE HAD TO BE REPLACED. THIS WAS DONE UNDER THE WARRANTY PERIOD BUT I'M WRITING TO MAKE YOU AWARE OF THIS FOR THE BENEFIT OF THE PEOPLE WHOSE CARS SYSTEMS LASTED SLIGHTLY LONGER, OUT OF WARRANTY. VOLVO KNEW THEY HAD ISSUES WITH DEFECTIVE THROTTLES AND SHOULD STAND BEHIND THEIR PRODUCT. THESE CARS ARE NOT…
Read full complaint
MY CARS ELECTRONIC THROTTLE HAD TO BE REPLACED. THIS WAS DONE UNDER THE WARRANTY PERIOD BUT I'M WRITING TO MAKE YOU AWARE OF THIS FOR THE BENEFIT OF THE PEOPLE WHOSE CARS SYSTEMS LASTED SLIGHTLY LONGER, OUT OF WARRANTY. VOLVO KNEW THEY HAD ISSUES WITH DEFECTIVE THROTTLES AND SHOULD STAND BEHIND THEIR PRODUCT. THESE CARS ARE NOT CHEAP AND OWNERS SHOULD NOT BE 'BETA' TESTERS FOR NEW SYSTEMS.*JB
NHTSA ODI #10134802
Mileage unknown · Aug 30, 2005
Latches/locks/linkages
I PURCHASED A NEW 1999 VOLVO S70 GLT SEDAN. ABOUT SIX MONTHS AGO I NOTICED THAT THE HOOD WAS NOT CLOSING. UPON EXAMINATION I DISCOVERED THAT BOTH HOOD LATCHES WERE FAILING BECAUSE OF METAL FATIGUE. AT THIS POINT ONE LATCH HAS FALLEN OFF COMPLETELY AND THE OTHER IS SO WEAKENED IT WILL NOT HOLD THE HOOD. I AM CURRENTLY HOLDING…
Read full complaint
I PURCHASED A NEW 1999 VOLVO S70 GLT SEDAN. ABOUT SIX MONTHS AGO I NOTICED THAT THE HOOD WAS NOT CLOSING. UPON EXAMINATION I DISCOVERED THAT BOTH HOOD LATCHES WERE FAILING BECAUSE OF METAL FATIGUE. AT THIS POINT ONE LATCH HAS FALLEN OFF COMPLETELY AND THE OTHER IS SO WEAKENED IT WILL NOT HOLD THE HOOD. I AM CURRENTLY HOLDING THE HOOD DOWN WITH A BUNGIE CORD. FAILURE OF THE HOOD LATCHES COULD LEAD TO A DANGEROUS SITUATION IF A HOOD FLIES UP AT HIGH SPEED. *NM
NHTSA ODI #10134760
Mileage unknown · Aug 29, 2005
Vehicle Speed Control
VEHICLE SPEED CONTROL: VEHICLE ENGINE DIES FOR NON REASON WHILE UNDER WAY. VEHICLE RESTARTS IMMEDIATELY. NO ERROR CODE SET IN COMPUTER. *JB
NHTSA ODI #10134579
99,500 miles · Aug 26, 2005
Electrical System
ELECTRONIC THROTTLE CONTROL CAUSES CAR TO STALL REPEATEDLY- OFTEN IN SITUATIONS WHERE IT IS UNSAFE TO PULL OVER. *JB
NHTSA ODI #10134321
75,845 miles · Aug 26, 2005
Electrical System
1. I NOTICED THE PROBLEM WHEN I WAS DRIVING ON THE HIGHWAY. THE CAR FELT LIKE IT WAS LOSING POWER OR MISSING LIKE IT WAS GONG TO STOP RUNNING. FORTUNATELY, UNLIKE OTHERS, I WAS NOT STRANDED. 2. MY 75,000 MILE SERVICE WAS DUE SO I TOOK THE CAR IN FOR THAT AND ALSO LET THE VOLVO DEALER KNOW ABOUT THE PROBLEM. 3. THEY RAN DIA…
Read full complaint
1. I NOTICED THE PROBLEM WHEN I WAS DRIVING ON THE HIGHWAY. THE CAR FELT LIKE IT WAS LOSING POWER OR MISSING LIKE IT WAS GONG TO STOP RUNNING. FORTUNATELY, UNLIKE OTHERS, I WAS NOT STRANDED. 2. MY 75,000 MILE SERVICE WAS DUE SO I TOOK THE CAR IN FOR THAT AND ALSO LET THE VOLVO DEALER KNOW ABOUT THE PROBLEM. 3. THEY RAN DIAGNOSTICS AND DETERMINED IT TO BE THE ELECTRONIC THROTTLE MODULE. THEY REPLACED THE PART WITH A NEW REDESIGNED PART. I DO NOT KNOW IF THE OLD PART IS AVAILABLE. P.S. THE DEALERSHIP CALLED VOLVO AND VOLVO AGREED TO PAY FOR THE PART NOT THE LABOR, WHICH SAVED ME ABOUT $500. THAT WAS A GOOD GESTURE. 8JB
NHTSA ODI #10134294
105,000 miles · Aug 25, 2005
Fuel System, Other
I HAVE A 1999 VOLVO S70 THAT I BROUGHT IN TO A VOLVO REPAIR SHOP FOR A 105,000 MILE CHECK UP (MOSTLY FOR THE REPLACEMENT OF THE TIMING BELT). THE CAR WAS OTHERWISE WORKING FINE. FOLLOWING REPLACEMENT OF THE TIMING BELT, TENSIONER, OIL CHANGE, LUBE, ETC. (ALL THE THINGS IN THE STANDARD 105,000 MILE CHECK-UP), THE CAR WOULD NO L…
Read full complaint
I HAVE A 1999 VOLVO S70 THAT I BROUGHT IN TO A VOLVO REPAIR SHOP FOR A 105,000 MILE CHECK UP (MOSTLY FOR THE REPLACEMENT OF THE TIMING BELT). THE CAR WAS OTHERWISE WORKING FINE. FOLLOWING REPLACEMENT OF THE TIMING BELT, TENSIONER, OIL CHANGE, LUBE, ETC. (ALL THE THINGS IN THE STANDARD 105,000 MILE CHECK-UP), THE CAR WOULD NO LONGER IDLE. THE SHOP IDENTIFIED THE PROBLEM AS THE ELECTRONIC THROTTLE MODULE. IT REMAINS UNCLEAR WHY IT FAILED AS PART OF A ROUTINE CHECK-UP. THE PART WAS REPLACED AND THE REPLACEMENT PART ALSO FAILED TO WORK (IT WOULDN'T ACCEPT THE SOFTWARE). THE SECOND REPLACEMENT THROTTLE MODULE DID WORK AND THE CAR IS NOW WORKING. THE COST OF THIS REPAIR, HOWEVER, WAS $902.00--$551.50 FOR THE PART ALONE. THE REPAIR SHOP SPECIALIZES IN VOLVOS AND INDICATED THAT THIS WAS A FREQUENT PROBLEM, CURRENTLY UNDER INVESTIGATION BY YOUR OFFICE (NTSB ACTION # PE05041). I WANTED TO ADD MY EXPERIENCE TO YOUR COMPLAINT FILE. THIS CAN BE VERIFIED THROUGH THE REPAIR SHOP, RANDALL AUTOMOTIVE INC., 1720 WASHINGTON AVE. EXT., RENSSELAER, NY 12144-9482.
NHTSA ODI #10134245
83,250 miles · Aug 25, 2005
Power TrainCrash
CAR STALLS RANDOMLY AND THIS TIME I HIT A CURB
NHTSA ODI #10134214
101,312 miles · Aug 23, 2005
Vehicle Speed Control
PART OF 10133805, SECOND VEHICLE S70, CATASTROPHIC FAILURE, STALLED WHILE GOING 35 IN MODERATE TRAFFIC. IF IT HAD FAILED 20 SECONDS LATER THERE COULD HAVE BEEN AN ACCIDENT. RESTARTED 30 SECONDS LATER IN LIMP HOME MODE, ETM REPLACED. *SMCH. *AK
NHTSA ODI #10134508
87,000 miles · Aug 23, 2005
Electrical System
ETS LIGHTS COMES ON/OFF. CAR CONTINUES TO BREAK DOWN, LAST TIME ON INTERSTATE. DEALER SAYS DOESN'T KNOW WHAT'S WRONG.
NHTSA ODI #10133850
87,000 miles · Aug 22, 2005
Engine And Engine Cooling
THE ENGINE THROTTLE CONTROL LIGHT ACTIVATED SPORADICALLY BEGINNING IN JULY, 2005. I NOTICED THAT THE CAR WAS NOT PERFORMING ADEQUATELY WHEN GOING UPHILL OR IN SEVERE HEAT. MY HUSBAND CONTACTED THE VOLVO DEALERSHIP IN ALLENTOWN, PA WHERE WE PURCHASED THE VEHICLE. HE WAS TOLD THAT THE COST TO REPAIR SAME WOULD BE OVER $800. WE…
Read full complaint
THE ENGINE THROTTLE CONTROL LIGHT ACTIVATED SPORADICALLY BEGINNING IN JULY, 2005. I NOTICED THAT THE CAR WAS NOT PERFORMING ADEQUATELY WHEN GOING UPHILL OR IN SEVERE HEAT. MY HUSBAND CONTACTED THE VOLVO DEALERSHIP IN ALLENTOWN, PA WHERE WE PURCHASED THE VEHICLE. HE WAS TOLD THAT THE COST TO REPAIR SAME WOULD BE OVER $800. WE DECIDED TO PASS ON THIS REPAIR DUE TO THE COST AND THOUGHT THAT ANOTHER AUTO SERVICE MECHANIC COULD PERFORM THE REPAIRS AT A LESSER PRICE. APPROXIMATELY 3 WEEKS LATER, THE ETS LIGHT WAS ACTIVATED ON EVERY OCCASION THAT THE VEHICLE WAS USED. SINCE A SECOND MECHANIC (NOT AFFILIATED WITH VOLVO) STATED THAT HE WAS UNABLE TO DO THE REPAIRS, WE DECIDED TO CONTACT ANOTHER VOVLO DEALERSHIP. THE REPAIR OF THE THROTTLE BODY AND ETM "RELOAD" WAS PERFORMED BY A VOLVO OF FORT WASHTINGTON, PA AT A COST OF OVER $800 ON AUGUST 17, 2005. AFTER READING THE NUMBER OF COMPLAINTS THAT NHTSA RECEIVED ON THIS VERY SAME PROBLEM AND THE POTENTIAL FOR INJURY, WE DECIDED TO HAVE THE REPAIR PERFORMED. WE DID CONTACT VOLVO IN ROCKLEIGH, NJ VIA EMAIL AND RECEIVED AN INITIAL RESPONSE FROM A MR. JOHN WILLETS REQUESTING INFORMATION ON OUR VIN NUMBER AND MILEAGE. WE SUPPLIED SAID INFORMATION ON THE SAME DATE (AUGUST 10, 2005). WE DID NOT HEAR BACK FROM HIM DESPITE REPEATED REQUESTS VIA EMAIL. WE HAD TO PAY THIS EXPENSIVE REPAIR BILL TO ENSURE THE SAFETY OF OUR FAMILY.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
VEHICLE DESCRIPTION: ALL-WHEEL-DRIVE SEDANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILTER BRACKET CONFIGURATION MARGINS ARE INSUFFICIENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, FUEL LEAKAGE COULD OCCUR. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL FILTER PROTECTION BRACKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1999 Volvo S70 Problems, Complaints & Recalls | Skip That Year
Illustration