Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1525–50K
3850–75K
3975–100K
36100–150K
13150K+
148 reports with mileage · 57 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports1 fire reports10 injury reports
What owners actually said
205 reports
105,000 miles · Sep 11, 2005
Electrical System
1999 VOLVO S70 T5, DURING 2004 CAR STARTED AN IDLE/SURGE PROBLEM. TOOK IT TO DEALER WHO SAID THE MASS AIR FLOW CONTROL REGULATOR NEEDED CLEANING. PAID AROUND $200 AND CAR SEEMED FINE FOR AWHILE. IN JAN 2005 THE PROBLEM RETURNED, BUT WORSE. TOOK IT TO TWO DIFFERENT VOLVO CERTIFIED MECHANICS WHO SAID THERE WERE NO CODES IN COMPUT…
Read full complaint
1999 VOLVO S70 T5, DURING 2004 CAR STARTED AN IDLE/SURGE PROBLEM. TOOK IT TO DEALER WHO SAID THE MASS AIR FLOW CONTROL REGULATOR NEEDED CLEANING. PAID AROUND $200 AND CAR SEEMED FINE FOR AWHILE. IN JAN 2005 THE PROBLEM RETURNED, BUT WORSE. TOOK IT TO TWO DIFFERENT VOLVO CERTIFIED MECHANICS WHO SAID THERE WERE NO CODES IN COMPUTER, THEY COULD SEE THERE WAS A PROBLEM BUT HAD NO CLUE WHAT WAS CAUSING IT, JUST OPINIONS ON A COUPLE OF PART WE COULD TRY REPLACING. IN MARCH 05 THE VEHICLE STALLED WHILE DRIVING IN TRAFFIC, RESTARTED AND SEEMED TO RUN FINE, ASIDE FROM THE SURGING. HOWEVER, SURGING CONTINUED AND STALLING, IN TRAFFIC, OCCURRED AGAIN TWO WEEKS AGO. DOING MY OWN RESEARCH, I'M NOW FINDING THIS IS A KNOWN AND DANGEROUS PROBLEM WITH THIS MODEL VEHICLE. DUE TO FINANCIAL RESTRAINTS AT THIS MOMENT, I CANNOT AFFORD TO REPLACE THE ELECTRONIC THROTTLE CONTROL MODULE AND SO MY CAR MOSTLY SITS, BEING DRIVEN ONLY IF ABSOLUTELY NECESSARY. LUCKILY WE HAVE A SECOND VEHICLE. WE PURCHASED OUR VOLVO, DESPITE THE REPUTATION FOR PRICEY MAINTENANCE, WITH FAITH IN VOLVO'S REPUTATION FOR SAFETY AND RELIABILITY. A REPUTATION BUILT, IN PART, BY RATINGS SUPPLIED BY SEVERAL CONSUMER REPORTING AGENCIES, INCLUDING YOUR OWN. THE MANUFACTURER NEEDS TO TAKE RESPONSIBILITY FOR THIS DEFECTIVE EQUIPMENT, AND CONSUMER ADVOCACY AGENCIES SHOULD SEE TO IT THAT THEY DO. *NM
NHTSA ODI #10136138
57,000 miles · Sep 9, 2005
Vehicle Speed Control
DT: THE RPMS WOULD DROP TO 500 OR BELOW, AND THE CAR WOULD STALL. TOOK VEHICLE TO THE DEALER, AND THEY CLEANED THE THROTTLE. WITHIN 2-3 MONTHS, IT WAS THE SAME PROBLEM OR WORSE. THIS WAS A SAFETY ISSUE. THE CONSUMER SENT VOLVO A LETTER, AND THEY SAID NHTSA WAS IN THE MIDDLE OF AN INVESTIGATION AND WOULDN'T DO ANYTHING UNTIL THE…
Read full complaint
DT: THE RPMS WOULD DROP TO 500 OR BELOW, AND THE CAR WOULD STALL. TOOK VEHICLE TO THE DEALER, AND THEY CLEANED THE THROTTLE. WITHIN 2-3 MONTHS, IT WAS THE SAME PROBLEM OR WORSE. THIS WAS A SAFETY ISSUE. THE CONSUMER SENT VOLVO A LETTER, AND THEY SAID NHTSA WAS IN THE MIDDLE OF AN INVESTIGATION AND WOULDN'T DO ANYTHING UNTIL THE RESULTS WERE PUBLISHED.*AK
NHTSA ODI #10135966
80,000 miles · Sep 9, 2005
Vehicle Speed Control
DT: 1999 VOLVO S70. THE CONSUMER STATED THERE WAS AN INVESTIGATION OPEN FOR THE VEHICLE SPEED CONTROL. THE ELECTRONIC THROTTLE CONTROL HAD TO BE REPLACED ALTHOUGH THE VEHICLE DID NOT STALL. THIS HAPPENED APPROXIMATELY MARCH 26, 2004. THE CHECK ENGINE LIGHT CAME ON, BUT VEHICLE SEEMED TO BE RUNNING FINE. WHEN THE CONSUMER…
Read full complaint
DT: 1999 VOLVO S70. THE CONSUMER STATED THERE WAS AN INVESTIGATION OPEN FOR THE VEHICLE SPEED CONTROL. THE ELECTRONIC THROTTLE CONTROL HAD TO BE REPLACED ALTHOUGH THE VEHICLE DID NOT STALL. THIS HAPPENED APPROXIMATELY MARCH 26, 2004. THE CHECK ENGINE LIGHT CAME ON, BUT VEHICLE SEEMED TO BE RUNNING FINE. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY STATED IT WAS BECAUSE OF THE ELECTRONIC THROTTLE CONTROL. THE CONSUMER PAID FOR THE REPLACEMENT. THIS ONLY HAPPENED ONCE. *AK
NHTSA ODI #10131738
72,000 miles · Sep 9, 2005
Fuel System, Gasoline
DT: WHILE DRIVING ON A FREEWAY, THE VEHICLE SURGED. IT WAS IMPOSSIBLE TO CONTROL THE VEHICLE. CONSUMER E PULLED THE VEHICLE OFF OF THE ROAD AND CALLED THE DEALERSHIP, THEY TOLD HIM TO BRING THE VEHICLE IN THEY REPLACED THE ELECTRONIC FUEL REGULATOR. THIS OCCURRED IN SEPTEMBER 22, 2004. THIS HAS NOT HAPPENED SINCE, BUT HE …
Read full complaint
DT: WHILE DRIVING ON A FREEWAY, THE VEHICLE SURGED. IT WAS IMPOSSIBLE TO CONTROL THE VEHICLE. CONSUMER E PULLED THE VEHICLE OFF OF THE ROAD AND CALLED THE DEALERSHIP, THEY TOLD HIM TO BRING THE VEHICLE IN THEY REPLACED THE ELECTRONIC FUEL REGULATOR. THIS OCCURRED IN SEPTEMBER 22, 2004. THIS HAS NOT HAPPENED SINCE, BUT HE CONSUMER WAS CONCERNED IT MAY HAPPEN AGAIN. THERE WAS CURRENTLY AN INVESTIGATION OPEN REGARDING THIS PROBLEM, PE05041.*AK *JB
NHTSA ODI #10131036
70,000 miles · Sep 9, 2005
Vehicle Speed Control
DT: CONTACT STATED ON 3 OR 4 OCCASIONS WOULD LOSE O POWER INTERMITTENTLY, USUALLY AFTER SLOWING DOWN AND ACCELERATING. IT HAPPENED ABOUT 4 TIMES OVER THE LAST YEAR. TOOK VEHICLE TWICE TO DEALER, AND THEY COULD NOT T FIND ANYTHING WRONG. VEHICLE WILL BE FINE FOR A COUPLE OF MONTHS AND THEN IT WILL HAPPEN AGAIN. WAS ABLE TO RE…
Read full complaint
DT: CONTACT STATED ON 3 OR 4 OCCASIONS WOULD LOSE O POWER INTERMITTENTLY, USUALLY AFTER SLOWING DOWN AND ACCELERATING. IT HAPPENED ABOUT 4 TIMES OVER THE LAST YEAR. TOOK VEHICLE TWICE TO DEALER, AND THEY COULD NOT T FIND ANYTHING WRONG. VEHICLE WILL BE FINE FOR A COUPLE OF MONTHS AND THEN IT WILL HAPPEN AGAIN. WAS ABLE TO RESTART THE CAR AFTER ONLY A FEW MINUTES.*AK *NM
NHTSA ODI #10131035
Mileage unknown · Sep 8, 2005
Structure
DASHBOARD BEGAN MAKING VERY LOUD NOISES. DEALERSHIP INFORMED ME THAT THE DASH HAS COME LOOSE FROM THE FIREWALL. DEALERSHIP INFORMED ME THAT THIS IS VERY COMMON IN THE 1997 AND 1998 MODELS. DEALERSHIP SAID THAT I NEED A NEW DASHBOARD BECAUSE THE CLIPS HOLDING IT ARE BROKEN. VOLVO IS WELL AWARE OF THIS DEFECT AND STATED THAT I…
Read full complaint
DASHBOARD BEGAN MAKING VERY LOUD NOISES. DEALERSHIP INFORMED ME THAT THE DASH HAS COME LOOSE FROM THE FIREWALL. DEALERSHIP INFORMED ME THAT THIS IS VERY COMMON IN THE 1997 AND 1998 MODELS. DEALERSHIP SAID THAT I NEED A NEW DASHBOARD BECAUSE THE CLIPS HOLDING IT ARE BROKEN. VOLVO IS WELL AWARE OF THIS DEFECT AND STATED THAT IF THE DASH HAD COME LOOSE FROM THE FIREWALL DURING THE FIRST 4 YEARS OR 50000 MILES IT WOULD HAVE BEEN COVERED UNDER WARRANTY. THE EXTENDED WARRANTY DOES NOT COVER STRUCTURAL DEFECTS OR DESIGN FLAWS. WITH THIS BEING A COMMON PROBLEM I THINK THAT VOLVO SHOULD STAND BEHIND ITS CARS AND OFFER TO REPLACE THE DEFECTIVE PART. I AM ASSUMING THAT IF I DO NOT HAVE THIS VERY COSTLY REPAIR DONE THE DASH WILL EVENTUALLY SEPARATE FROM THE FIREWALL COMPLETELY AND FALL OFF. I AM SURE THAT THIS DASHBOARD WILL NOT PROVIDE ANY PROTECTION IN THE EVENT OF A HEAD ON COLLISION. MY VOLVO WAS NOT BUILT FOR SAFETY, BUT FOR PROFIT USING DEFECTIVE DESIGNS AND PARTS. *JB
NHTSA ODI #10135802
50,000 miles · Sep 7, 2005
Electrical System
ROUGH IDLE ETS LIGHT CAME ON CAR DIED REPLACED ETM. *NM
NHTSA ODI #10135538
Mileage unknown · Sep 3, 2005
Electrical System
ELECTRONIC THROTTLE MODULE HAD TO BE REPLACED DUE TO FAILURE. THE WARNING LIGHTS CAME ON AND THE CAR REPEATEDLY JERKED DURING DRIVING. DEALER ASSESSED SITUATION AND HAD NO CHOICE BUT TO REPLACE. *JB
NHTSA ODI #10135236
63,000 miles · Sep 2, 2005
Electrical System
ST: VEHICLE STALLED/DIED/LOST POWER WHILE DRIVING AT 20 MPH. DEALER REPLACED THROTTLE BODY. *AK *JB
NHTSA ODI #10131951
87,500 miles · Aug 30, 2005
Fuel System, Gasoline
THE CAR STALLED IN HIGHWAY TRAFFIC LOSING PARTIAL CONTROL OF THE AUTOMOBILE SCARED DRIVER AND CAR LUCKILY RESTARTED OR COULD HAVE BEEN MAJOR ACCIDENT - FOUND OUT THROTTLE BODY MODULE WAS TO BLAME. THIS IS ONE SIGNIFICANT EXAMPLE THE CAR OFTEN STALLED AT STOP LIGHTS AND GOING AROUND CORNERS. *JB
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
VEHICLE DESCRIPTION: ALL-WHEEL-DRIVE SEDANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILTER BRACKET CONFIGURATION MARGINS ARE INSUFFICIENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, FUEL LEAKAGE COULD OCCUR. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL FILTER PROTECTION BRACKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1999 Volvo S70 Problems, Complaints & Recalls | Skip That Year
Illustration