Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Wheels complaints

3 reports

Clear category filter

Mileage unknown · Oct 9, 2024

Electrical SystemUnknown Or OtherWheels

Read full complaint

The indirect measurement TPMS system of this car has misdetected low tire pressure on three occasions. Most recently, on October 3 while driving on the freeway at about 70 MPH the TPMS alert illuminated. I checked the information screen and the display showed low pressure in all four tires. Because I have had misdetection of the right front tire twice before, and that it seemed very unlikely that all four tires would deflate at the same time, I disregarded the alert as a false detection. Later I checked the air pressure in all four tires and found it to be exactly correct. In an earlier episode, as I mentioned the TPMS alerted that the right front tire was low. In this instance, I did not have a history of false detections, so I believed the information to be accurate and immediately exited the freeway and returned home where I had a (very accurate) tire pressure gauge. Of course, the pressure was correct in all tires. I then followed the Volvo recalibration procedure and this completed successfully until later that day when the same tire alerted to low pressure again. I rechecked, again pressure was correct, and re-ran the calibration procedure. I did not have any other false detection again until about a year later when the October 3 incident occurred. The car has had at least one “total system update” to the software to address other issues since the first false detection incident, possibly two (not sure). The problem I am having with this is that Volvo apparently decided to change from direct sensor measurement to indirect wheel speed measurement around 2019 or 2020 as a cost saving measure. That is fine, but the indirect measurement system they are using is causing so many false alarms that now the first thing I think when I see an alert is that it is not a real problem. This is not a good situation. Volvo forums are full of complaints by other owners of similar false alarms. Volvo should fix this problem through software or restore direct measurement.

NHTSA ODI #11618880

Mileage unknown · Jul 30, 2023

SteeringWheels

Read full complaint

Hi, 2021 Volvo S60 VIN: [XXX] License plate: [XXX] (PA) Title date 12/7/2021 (bought the Volvo new...) I have barely 11,000 miles on the clock and have already replaced 4 low profile tires owing to potholes in highways and other roads across the United States. I really, truly want to file this complaint. I'm not sure why Volvo included low profile tires in the size 235/40R19 on their S60 models. When I drive, I feel like a downhill skier gliding from left to right, dodging potholes... According to my dealership Keystone Volvo of Doylestown, [XXX] , selling low profile tyres is a thriving industry…. According to AAA Mobile Mechanics, low-profile tyres are more prone to tyre and rim damage since they have less air cushioning to withstand heavy impacts from potholes and uneven places on the road. Low-profile tires are also more sensitive to road damage. Blowouts and tire failure are actually more likely on pothole-infested roadways. Given the state of the US road network, I believe your organization or whoever is in charge should not provide a TYPE certification for cars built within the US or imported from other countries both equipped with low profile tires... Please advise, and I eagerly await your response... Best , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11535353

Mileage unknown · Mar 17, 2023

Wheels

I have had all 3wheels bend 1 wheel blow apart with in 7 months of owning the car . With in 15000 miles .

NHTSA ODI #11512467

Official recalls

25V179000 · Electrical System:propulsion System:traction Battery; Electrical System:software

Mar 24, 2025

Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

Consequence & remedy

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Additional source detail variants (2)

Electrical System:propulsion System:traction Battery

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.

Electrical System:software

Consequence: A short circuit in a high-voltage battery increases the risk of a fire.

23V780000 · Air Bags:frontal

Nov 21, 2023

Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.

Consequence & remedy

Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.

Remedy: Dealers will inspect and tighten the bolts securing the passenger air bag, as necessary, free of charge. Owner notification letters were mailed January 5, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10254.

22V793000 · Engine And Engine Cooling:engine:engine Control Module (ecu/ecm)

Oct 20, 2022

Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.

Consequence & remedy

Consequence: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.

Remedy: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.

21V682000 · Seat Belts; Seat Belts:front:retractor; Seat Belts:rear/other:retractor

Sep 1, 2021

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.

Additional source detail variants (3)

Seat Belts:rear/other:retractor

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.

Seat Belts:front:retractor

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Seat Belts

Consequence: An unsecured child restraint system can increase the risk of injury during a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.