2006 Volvo S60

TL* THE CONTACT OWNS A 2006 VOLVO S60. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD TO SHIFT THE GEAR TO NEUTRAL, TURN OFF AND RESTART THE VEHICLE IN ORDER TO ACCELERATE THE VEHICLE OUT OF THE INTERSECTION. THE VEHICLE WAS TAKEN TO BE DIAGNOSED. THE VEHICLE WAS DIAGNOSED AS NEEDING A NEW FUEL PRESSURE SENSOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 44,500.

MY COMPLAINT IS AGAINST SYLVANIA ULTRA HEADLIGHTS, PURCHASED FROM AUTOZONE. "THE HEADLIGHTS FAILED SHORTLY AFTER 2 MONTHS, THEY ARE THE MOST EXPENSIVE HEADLIGHTS THEY SELL (THINKING THEY ARE THE BEST) I PURCHASED A PAIR. HAD THEM REPLACED AT A LOCAL MECHANIC - THEY WERE INSTALLED CORRECTLY. - THIS ACTION WAS REPEATED FOR 3 SETS OF REPLACEMENTS. THE 4TH TIME AROUND I DID NOT PURCHASE HEADLIGHTS - I TOOK IT TOO THE MECHANIC AND ASKED HIM TO CHECK THE WIRING AND REPLACE THE HEADLIGHTS YET AGAIN. THE MECHANIC CALLED AUTOZONE - THEY ASKED DO YOU WANT THE GOOD ONES OR THE BAD ONES ? THE MECHANIC SAID LOOKING AT ME - THE GOOD ONES OF COARSE. THEN THE SALES PERSON ON THE PHONE DESCRIBED HOW SUCKY THE OTHER ONES ARE TO THE MECHANIC. ABOUT 30 MINS LATER - AUTOZONE DELIVERED THE HEADLIGHTS THAT WERE SYLVANIA BUT NOT THE ULTRA.WHEN I WAS IN AUTOZONE - THEY CLAIMED THESE ULTRAS ARE THE BEST. THESE BOGUS ULTRA HEADLIGHTS ARE A SAFETY HAZARD AND IT APPEARS THEY KNOW THEY ARE BAD - I SMELL A SCAM BEING PERPETRATED AGAINST THE PUBLIC PRODUCING A SAFETY HAZARD AND UNNECESSARY EXPENSE/RIP OFF.

THIS REPORT CONCERNS THE FAILURE OF THE PARKING BRAKE ASSEMBLY ON MID 2000S VOLVO SEDANS AND SPECIFICALLY, A 2006 VOLVO S60, 2.5T. SPECIFICALLY, A DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY, WHICH RESULTS IN A TENDENCY FOR A METAL COMPONENT OF THE SHOE ASSEMBLY TO DISLODGE AND JAM BETWEEN THE BRAKE PAD AND ROTOR, RESULTING IN THE BRAKE SUDDENLY LOCKING UP WITH NO WARNING. WHILE THE EVENT GIVING RISE TO THIS REPORT OCCURRED AT APPROXIMATELY 20MPH, AT HIGH SPEEDS, A BRAKE JAM EVENT OF THIS NATURE COULD RESULT IN SERIOUS INJURY OR DEATH. THE ONSET OF THE DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY OCCURS WITH NO WARNING, OTHER THAN A MILD BUMPING NOISE WHEN THE VEHICLE IS PLACED INTO REVERSE OR DRIVE AT LOW SPEEDS. UPON INQUIRY TO SEVERAL VOLVO-SPECIFIC REPAIR SHOPS, AS WELL AS MULTIPLE REPORTS ON ONLINE VOLVO-SPECIFIC FORUMS, THIS PROBLEM IS KNOWN TO BE A RELATIVELY COMMON ISSUE AFTER APPROXIMATELY 4-8 YEARS OF NORMAL WEAR AND/OR 50,000-100,000 MILES OF USE ON THE EMERGENCY BRAKE SHOES. HOWEVER THERE IS NO SERVICE BULLETIN ISSUED BY VOLVO AS TO THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 VOLVO S60. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE BECAME INVOLVED IN A CRASH WITH ANOTHER VEHICLE AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT HEARD A LOUD BANG AND A BURNING ODOR EMITTED FROM THE AIR BAG. HOWEVER, THE AIR BAG DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

I HAVE MADE A RECENT COMPLAINT REGARDING SAFETY CONCERNS WITH A FAULTY ETM (ELECTRONIC THROTTLE MODULE) ON MY VEHICLE. I DROPPED IT OFF AT MY LOCAL AUTHORIZED DEALER FOR VOLVO AND I DID NOT TELL THEM THAT THE CAR PRODUCED AN ERROR CODE P2135 / ECM-9200 -- THROTTLE POSITION SENSOR --FAULTY SIGNAL, BECAUSE I WANTED TO SEE WHAT ERROR CODES THEY WOULD PULL OFF. IT IS MY UNDERSTAND EVEN IF I RESET THE 'CHECK ENGINE' LIGHT THE DEALER IS ABLE TO PULL THE CODES OF THE COMPUTER. WELL IN THIS CASE THE DEALER CALLED ME TODAY AND ADVISED ME THAT NO CODES COULD BE PULLED BUT WANTED TO KNOW IF THE PERSON WORKING ON MY CAR COULD TAKE IT HOME WITH HIM AND TAKE A READER. I SAID NO, BUT I DID NOT TAKE MY CAR THERE BECAUSE I WANT SOMETHING FOR FREE. I AM BEYOND FRUSTRATED WITH THE VOLVO BECAUSE OF THE FAULTY DESIGN. WHAT WILL IT TAKE NEXT TIME FOR ME TO BE ON THE FREEWAY AND DRIVING AND THE ERROR TO BE DISPLAYED AND CAUSE ME TO DROP MY SPEED DOWN AND GET INTO AN ACCIDENT? I FEAR THAT DAY WILL COME SOMEDAY IF NOT ME SOMEONE ELSE. *TR

ETM FAILS CAUSING ME TO LIMP HOME OR HAS ERRATIC THROTTLE BEHAVIOR, HAD REPAIRED BASICALLY THEY JUST STATED IT HAD TO BE CLEANED BUT THE INJECTORS WHERE FINE. AFTER SPENDING OVER $600.00 DOLLARS NOW THEY ARE STATING I NEED TO SPEND ANOTHER $600.00 ON THE PART TO REPLACE BECAUSE THE MOTOR IS CAUSING IT TO FAIL. I AM USUALLY DRIVING DOWN THE ROAD AND THEN A MESSAGE WILL DISPLAY 'REDUCE ENGINE PERFORMANCE CAUSING ME TO GO FROM 65 DOWN TO 40 MILES PER HOUR AND I FEAR THAT ONE DAY IT IS GOING TO CAUSE AND ACCIDENT DUE TO A MECHANICAL FAILURE ON BEHALF OF VOLVO ETM FIASCO. VOLVO HAS KNOWN THIS IS A FAULTY DESIGN BECAUSE BACK IN 1999 TO 2002 THERE WAS A RECALL AND THEY WERE ISSUED A 10 YEAR WARRANTY OR 200,000 MILE WARRANTY AFTER REPEAT FAILURES. I AM FILING A COMPLAINT BASED ON SAFETY CONCERNS AND DEMAND A RECALL AND BASED ON THE SAME ISSUE 'FAULTY DESIGN' AND VOLVO HAS KNOWN THIS CONTINUES TO BE A PROBLEM. 2006 SEEM TO HAVE A VERY HIGH REPAIR AND THIS SO HAPPENS TO BE ONE OF THOSE CARS. THANKS! *TR

IN MY 2006 VOLVO S60 THE ETM WENT OUT AFTER ONLY 48000 MILES. THE ENGINE HAS A ROUGH IDLE AND WON'T GO OVER 40 MPH. IT'S IN LIMP MODE. A REPLACEMENT FOR THE ETM IS UPWARDS OF $1,000 AND THE DEALER NEEDS TO BE THE ONE TO SERVICE TO MATE THE ETM TO THE CAR. LOOKING ON THE FORUMS AND AROUND IT AMAZES ME HOW COMMON THIS PROBLEM IS. THE RECALL THAT WAS FOR 1999-2002 MODELS SHOULD BE EXTENDED TO ALL MODEL YEARS THAT ARE AFFECTED BY THIS FAULTY PART TO ENSURE THAT ALL VOLVO OWNERS ARE SAFE FROM THIS POTENTIALLY DANGEROUS PROBLEM. *TR

I WAS DRIVING MY 2006 VOLVO S60 AND THE ENGINE SHUT OFF WITHOUT WARNING. THE ELECTRICAL SYSTEM SHUT OFF AND I WAS NOT EVEN ABLE TO PUT THE FLASHERS ON SO THAT OTHER DRIVERS COULD KNOW THAT THERE WAS A PROBLEM. I WAS ABLE TO PULL THE CAR TO THE SIDE OF THE ROAD (WITH DIFFICULTY SINCE THE POWER STEERING NO LONGER WORKED) AND PUT THE CAR IN PARK AND RESTART IT. *TR

THE ELECTRONIC THROTTLE MODULE HAD TO BE REPLACED IN MY 2006 VOLVO S60. THE CAR ONLY HAS 72,702 MILES! THIS IS AFTER HAVING PAID SEVERAL HUNDRED DOLLARS TO HAVE THE ETM CLEANED SEVERAL MONTHS AGO. THE COST TO REPLACE THE ETM WAS OVER $800. AS I SEARCH THE INTERNET, THESE CARS SEEM TO HAVE PROBLEMS WITH THIS PARTICULAR PART. IT'S RIDICULOUS TO THINK THAT I'M GOING TO HAVE TO KEEP PAYING FOR THIS PART, ESPECIALLY WHEN THE CAR IS ONLY 5 YEARS OLD AND HAS FAR LESS THAN 100,000 MILES!!! I DEMAND A RECALL AND WARRANTY REPLACEMENT! THE SERVICE MANAGER AT MY LOCAL VOLVO DEALERSHIP TELLS ME THESE UNITS NEED TO BE CLEANED OR SERVICED ABOUT EVERY 30K MILES. I HAVE A COPY OF MY RECEIPT FROM THIS WEEKS SERVICE. THIS PART SHOULD BE COVERED UNDER A WARRANTY BY THE MANUFACTURER! BELIEVE ME, I'M ACTIVE ON THE WEB AND I'M GOING TO TELL EVERYONE I KNOW TO STAY AWAY FROM VOLVOS. *TT