2012 Volvo C70

While in transit, the passenger door periodically unlatches on its own. There is a safeguard that prevents the door from completely swinging open when this happens. This problem has not been inspected by a professional. The warning light appears after the door unlatches while in motion. Because I never have a passenger, I am not able to immediately close the door. The last time this happened was at 65 mph on [XXX]. This problem has existed for years. The vehicle is available for inspection upon request. The cause is unknown, and timing is unpredictable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car developed an electronic communication issue that would cause random failure messages for the ABS, anti-skid system, transmission control and a "brake failure" message that would put the car into limp mode even at highway speeds. If you come to a complete stop, it would not allow you to pull away at any speed which makes you a traffic hazard and at risk for a rear end collision. I took the car to the dealer and they said it was the steering module so I had them replace it which ended up not resolving the problem. More alarming, the mechanic said that the factory original windshield had become unbonded and needed resealed. He showed me by flexing the windshield out at the top. I paid a windshield shop to reseal the windshield but I am reporting this since it's bond to the body is integral to keeping occupants from being ejected in the event of a rollover and the owner is unlikely to ever notice the issue.

There is a know defect with the chassis used for several Volvo car models. My car is a Volvo C70, year 2012. My car is affected by this defect. The defect wasn't disclosed to me at time of sale. I only learned about it literally 10 years later when Volvo of Gilbert (dealership) advised me to install a costly part on the rear suspension of my car because of "excessive negative camber". According to the Volvo repair department, they've known for years of an internal repair "recommendation" memo issued by Volvo that Volvo actually pays for on other models, but won't pay for on mine, to correct this "negative camber" on the rear of the car. ***** The negative camber causes tire walls to fail early and abnormally wear the internal edges of the tires. I've experienced early tire failure on multiple sets of tires on my Volvo C70 and never knew why. Now I know. **Volvo has always known.** I have to replace all of my tires almost every two years due to the inside edges wearing out, despite faithfully rotating my tires several times a year. My tires have worn down to the belt on the inside edges despite having plenty of good tread left in the middle of the tire itself. About two years ago I had a dangerous blowout on the freeway because of a tire that failed early -- now I know it's because of the negative camber. More recently, two of my tires wore down all the way to the belts despite being less than two years old. ***** Volvo knows about this issue. There is a good paper trail of the issue being documented both by Volvo and their customers, but they failed to warn us of the dangerous car suspension and failed to provide the fix to all of us (while providing the fix to some of their customers). ***** Please listen to this 2-minute recording with the Volvo technician (Judd) who disclosed the known defect to me: [XXX] ***** This needs to be rectified for all of us with the faulty chassis'. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This occurred after driving for about an hour. While driving at a fairly high rate of speed, I felt the driver's door move slightly. The dome light came on indicating that the door had opened. The windows were down so I cannot state if they would have slightly lowered as they normally do when the door is opened. I pushed outward on the door to see if it was fully open. The latch held the door. Using the interior door handle, I then opened and closed the door. The doors were then locked as extra security. Approximately 30 minutes later this happened again on a busier highway. I then had to worry about the door opening on me again while I was driving, however, there was no further occurrence. Later after returning home, I performed an internet search to see if something like this had happened to others. After seeing other comments of C70 doors opening & door latch problems, I decided to report the problem to get it on record.

The doors open when driving, first the passenger door opened about 3 months ago. The warning light comes on and stated that the door is open. The safety on the door keeps it from completely opening but the door is ajar just not completely opened. Last month it happened twice to the drivers door while in drive. I am aware that there is no recall but Volvo recalled 144,937 S60 sedans and V60 wagons from the 2011 through 2017 model years because their doors may open unexpectedly while the car is in motion. I had to pay $2000 to have this flaw fixed when in actuality it should have been a safety recall.