I was at a traffic light today and my rear passenger window just completely spider webbed, while my daughter was in the back seat. I had to pull over and clean as much glass from the window to prevent falling on her and causing any additional damage. There were no other vehicles or pedestrians around. The only thing I can think…
Read full complaint
I was at a traffic light today and my rear passenger window just completely spider webbed, while my daughter was in the back seat. I had to pull over and clean as much glass from the window to prevent falling on her and causing any additional damage. There were no other vehicles or pedestrians around. The only thing I can think of is that it was temperature related from being in the sun for a few hours and then having the AC on for about 5 minutes. I have researched on different volvo forums and threads and see other owners having similar issues. [XXX] [XXX] Thermal stress and expansion: When exposed to high temperatures, the glass expands, and if this expansion is uneven (perhaps due to varying thicknesses or materials), it creates thermal stress, potentially weakening the glass. When I reported the incident to the dealership they denied any other complaints or recalls instantly put the blame on an external impact without even inspecting the vehicle. There has been no official inspection by any party. The soonest the dealer will see it is on 8/12/25 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11679601
1,304 miles · May 31, 2023
Structure
The contact owns a 2023 Volvo C40. The contact spilled an unknown liquid inside the trunk and leaked onto the minor and major control units. The contact took the vehicle to the local dealer, where it was diagnosed with needing the upper and lower control units to be replaced. The vehicle was not repaired. The manufacturer had be…
Read full complaint
The contact owns a 2023 Volvo C40. The contact spilled an unknown liquid inside the trunk and leaked onto the minor and major control units. The contact took the vehicle to the local dealer, where it was diagnosed with needing the upper and lower control units to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 1,304.
NHTSA ODI #11524624
Mileage unknown · Mar 1, 2023
Structure
The hood will indicate it is latched but it only partially latches then while driving it will begin to vibrate violently
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 24, 2026. Owners may contact Volvo Car’s customer service at 1-800-458-1552. Volvo Car's number for this recall is R10333. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 16, 2026. This recall replaces previous NHTSA recall number 25V282. Vehicles previously repaired under recall 25V282 will need to have the new remedy performed.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 Volvo C40 BEV, 2025 EC40, 2023-2024 XC40 BEV, 2020-2026 XC90 PHEV, 2022-2026 XC60 PHEV, 2023-2025 S60 PHEV, 2024-2025 V60 PHEV, and 2025-2026 EX40 and 2025 S90 PHEV vehicles. In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.
Consequence & remedy
Consequence: A loss of brake function increases the risk of a crash.
Remedy: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed. The brake module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10329.
Additional source detail variants (2)
Service Brakes
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 Volvo C40 BEV, 2025 EC40, 2023-2024 XC40 BEV, 2020-2026 XC90 PHEV, 2022-2026 XC60 PHEV, 2023-2025 S60 PHEV, 2024-2025 V60 PHEV, and 2025-2026 EX40 and 2025 S90 PHEV vehicles. In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.
Consequence: A loss of brake function increases the risk of a crash.
Remedy: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed. The brake module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10329.
Service Brakes, Hydraulic:power Assist:electric:control Module:software
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 Volvo C40 BEV, 2025 EC40, 2023-2024 XC40 BEV, 2020-2026 XC90 PHEV, 2022-2026 XC60 PHEV, 2023-2025 S60 PHEV, 2024-2025 V60 PHEV, and 2025-2026 EX40 and 2025 S90 PHEV vehicles. In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.
Consequence: A loss of brake function increases the risk of a crash.
Remedy: Owners are advised not to use "B" Mode (for plug-in hybrid vehicles) or "One Pedal Drive" (for pure electric vehicles) until the repair has been completed. The brake module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed July 15, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10329.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10320.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023-2024 Volvo C40 vehicles. The clamps may be improperly crimped on the driver's side inner far side air bag module (FSAB), which can cause the air bag to deploy improperly.
Consequence & remedy
Consequence: An air bag that deploys improperly may not protect the driver as intended during a crash, increasing the risk of injury.
Remedy: Dealers will replace the driver's side inner FSAB, free of charge. Owner notification letters were mailed January 24, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10296.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).
Consequence & remedy
Consequence: The false warning message could prevent the detection of an actual e-call system failure, which could delay an emergency response during a crash, increasing the risk of injury.
Remedy: Dealers will update the telematics and connectivity antenna module (TCAM) software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Volvo Car's customer service 1-800-458-1552. Volvo Car's number for this recall is R10225.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60, V60CC, V90CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.
Consequence & remedy
Consequence: A reduction in brake support functions can increase the risk of a crash.
Remedy: Volvo will release an over-the-air (OTA) BCM2 software update, free of charge. Owner notification letters are expected to be mailed March 15, 2023. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10217.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2023 Volvo C40BEV Problems, Complaints & Recalls | Skip That Year
Illustration