Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
5 reports
225,000 miles · Mar 6, 2019
Fuel/propulsion System
TL* THE CONTACT OWNS A 1996 VOLVO 854. WHEN THE CONTACT FILLED UP THE TANK WITH FUEL, HE SMELLED FUEL FUMES WITHOUT GETTING CLOSE TO THE VEHICLE. THE CONTACT CALLED DYER & DYER VOLVO CARS (5260 PEACHTREE BLVD, CHAMBLEE, GA 30341, (800) 552-7023) AND WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE MANUFACTURER WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 1996 VOLVO 854. WHEN THE CONTACT FILLED UP THE TANK WITH FUEL, HE SMELLED FUEL FUMES WITHOUT GETTING CLOSE TO THE VEHICLE. THE CONTACT CALLED DYER & DYER VOLVO CARS (5260 PEACHTREE BLVD, CHAMBLEE, GA 30341, (800) 552-7023) AND WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 225,000.
NHTSA ODI #11184648
Mileage unknown · May 4, 2018
Fuel/propulsion System
TL* THE CONTACT OWNS A 1996 VOLVO 854. THE CONTACT STATED THAT THERE WAS A STRONG ODOR OF FUEL PROGRESSING FOR AN EXTENDED PERIOD OF TIME. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #11091747
Mileage unknown · Jul 23, 2003
Service Brakes, Hydraulic
YET ANOTHER 1996 VOLVO 850 SUFFERING FROM ABS CONTROL UNIT FAILURE.*AK
NHTSA ODI #10028969
Mileage unknown · Mar 10, 1998
Tires
TIRE AND RIM COMBINATION CAUSES BLOW OUTS IN THE FRONT TIRES WHEN GOING OVER ROAD HAZARDS.
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Additional source detail variants (2)
Electrical System
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
1996 Volvo 854 Problems, Complaints & Recalls | Skip That Year
Illustration