Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
425–50K
1450–75K
475–100K
13100–150K
7150K+
43 reports with mileage · 64 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports6 fire reports2 injury reports
What owners actually said
107 reports
100,000 miles · Oct 31, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 1997 VOLVO 850. THE HEADLIGHTS WOULD NOT ILLUMINATE WHEN THE VEHICLE WAS STARTED. THE HEADLIGHTS WOULD ALSO NOT DIM WHEN THE VEHICLE WAS TURNED OFF. THE HEADLIGHT SWITCH WAS DEFECTIVE, BUT IT WAS NEVER USED BY THE CONTACT. WHEN THE SWITCH WAS ENGAGED, THE HIGH BEAMS WOULD MOMENTARILY ILLUMINATE. HER VI…
Read full complaint
TL*THE CONTACT OWNS A 1997 VOLVO 850. THE HEADLIGHTS WOULD NOT ILLUMINATE WHEN THE VEHICLE WAS STARTED. THE HEADLIGHTS WOULD ALSO NOT DIM WHEN THE VEHICLE WAS TURNED OFF. THE HEADLIGHT SWITCH WAS DEFECTIVE, BUT IT WAS NEVER USED BY THE CONTACT. WHEN THE SWITCH WAS ENGAGED, THE HIGH BEAMS WOULD MOMENTARILY ILLUMINATE. HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V235000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
NHTSA ODI #10207507
150,000 miles · Nov 24, 2006
Electrical SystemVehicle Speed Control
1. LOSS OF ACCELERATION AND SOMETIMES STALLING DURING FREEWAY TRANSITION FROM ON RAMP TO FREEWAY AND OR DURING LEFT TURNING AGAINST TRAFFIC. 2. THE CAR FAILED TO ACCELERATE AND THE ACTION OF PUSHING THE ACCELERATOR CAUSED THE TRANSMISSION TO DOWN SHIFT CAUSING THE EXTREME SLOWING AND SOMETIMES STALLING. THE CONSEQUENCES WERE…
Read full complaint
1. LOSS OF ACCELERATION AND SOMETIMES STALLING DURING FREEWAY TRANSITION FROM ON RAMP TO FREEWAY AND OR DURING LEFT TURNING AGAINST TRAFFIC. 2. THE CAR FAILED TO ACCELERATE AND THE ACTION OF PUSHING THE ACCELERATOR CAUSED THE TRANSMISSION TO DOWN SHIFT CAUSING THE EXTREME SLOWING AND SOMETIMES STALLING. THE CONSEQUENCES WERE THAT TRAFFIC WAS GOING CONSIDERABLY FASTER AND HAD TO TAKE EVASIVE ACTION TO AVOID HITTING THE SLOWING CAR. 3. TODAY THE MEDIA REPORTED A POTENTIAL RECALL OF VOLVO'S DUE TO THIS PROBLEM AND I BELIEVE IT SHOULD BE EXTENDED TO 1997 MODEL 850 GLT. *JB
NHTSA ODI #10174142
132,000 miles · Aug 28, 2006
Air BagsCrash
DT*: THE CONTACT STATED WHILE DRIVING 35MPH ON A CITY STREET, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT COLLISION AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, NO INJURIES WERE SUSTAINED. THERE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT INSPE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 35MPH ON A CITY STREET, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT COLLISION AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, NO INJURIES WERE SUSTAINED. THERE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS NOT ALERTED.
NHTSA ODI #10166716
40,000 miles · Aug 27, 2006
Electrical System
THE TRAC OFF LIGHT COMES ON ON MY 1997 VOLVO 850 GLT TURBO WAGON. APPARENTLY, THE TRAC, NO LONGER WORKS AND I HAVE TO PAY HUNDREDS OF DOLLARS TO GET IT FIXED. THIS SHOULD BE A RECALL AND RELATES DIRECTLY TO A SAFETY CLAIM MADE BY VOLVO. FROM THE LIST SERV THAT I AM ON, APPARENTLY THIS IS A VERY COMMON PROBLEM AMONGST 1996-1998 V…
Read full complaint
THE TRAC OFF LIGHT COMES ON ON MY 1997 VOLVO 850 GLT TURBO WAGON. APPARENTLY, THE TRAC, NO LONGER WORKS AND I HAVE TO PAY HUNDREDS OF DOLLARS TO GET IT FIXED. THIS SHOULD BE A RECALL AND RELATES DIRECTLY TO A SAFETY CLAIM MADE BY VOLVO. FROM THE LIST SERV THAT I AM ON, APPARENTLY THIS IS A VERY COMMON PROBLEM AMONGST 1996-1998 VOLVOS. *JB
NHTSA ODI #10166684
60,000 miles · Aug 17, 2006
SuspensionTires
DT*: THE CONTACT STATED THE VEHICLE VIBRATED AND THE STEERING WAS ERRATIC. THE CONTACT NOTICED UNUSUAL HYDROPLANING IN SMALL PUDDLES OF WATER ON THE HIGHWAY. THE CONTACT NOTICED CHUNKS ON THE OUTSIDE RIM OF THE PASSENGER SIDE TIRE. A LOCAL REPAIR SHOP DETERMINED THERE WAS UNUSUAL WEAR ON THE TIRES. THE DEALERSHIP DETERMINED …
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE VIBRATED AND THE STEERING WAS ERRATIC. THE CONTACT NOTICED UNUSUAL HYDROPLANING IN SMALL PUDDLES OF WATER ON THE HIGHWAY. THE CONTACT NOTICED CHUNKS ON THE OUTSIDE RIM OF THE PASSENGER SIDE TIRE. A LOCAL REPAIR SHOP DETERMINED THERE WAS UNUSUAL WEAR ON THE TIRES. THE DEALERSHIP DETERMINED THE ALIGNMENT WAS BAD ON THE VEHICLE THAT WAS THE PROBLEM WITH THE TIRES. THE TIRE MANUFACTURER WAS MICHELIN. MODEL: ENERGY. SIZE: 195/60/R15.*AK
NHTSA ODI #10165735
103,000 miles · Oct 6, 2005
Electrical System
CAR WOULD NOT START - APPEARED TO BE DEAD BATTERY - REPLACED BATTERY - CAR STARTED, NEXT DAY CAR BATTERY DEAD - JUMPED BATTERY, CAR STARTED-2 HOURS LATER CAR BATTERY DEAD - TESTED NEW BATTERY TESTED OK. JUMPED BATTERY TOOK CAR TO VOLVO DEALER - LAWRENCE MOTORS IN WALNUT CREEK - TOOK SERVICE DEPARTMENT 1 DAY? TO DIAGNOSE - "WIRIN…
Read full complaint
CAR WOULD NOT START - APPEARED TO BE DEAD BATTERY - REPLACED BATTERY - CAR STARTED, NEXT DAY CAR BATTERY DEAD - JUMPED BATTERY, CAR STARTED-2 HOURS LATER CAR BATTERY DEAD - TESTED NEW BATTERY TESTED OK. JUMPED BATTERY TOOK CAR TO VOLVO DEALER - LAWRENCE MOTORS IN WALNUT CREEK - TOOK SERVICE DEPARTMENT 1 DAY? TO DIAGNOSE - "WIRING HARNESS NEEDS TO BE REPLACED AT $2,000 COST!! CAR TO BE READY IN 3 TO 4 WEEKS (SEPTEMBER 1ST), THEN DELAYED (UNKNOWN REASONS), DELAYED TO OCT 1ST, AS OF TODAYS CALL OCT 6, 2005 WAS ADVISED CAR NOT AVAILABLE UNTIL POSSIBLY NOV 1ST. WHY WOULD A CAR WITH 100,000 MILES AND 8 YEARS OLD (ALWAYS PROPERLY SERVICED) REQUIRE A NEW WIRING HARNESS? AND AT SUCH A COST? AND WHY DOES THE PART TAKE OVER 90 DAYS TO RECEIVE?*JB
NHTSA ODI #10138908
70,000 miles · Aug 9, 2005
Electrical System
HEATING AND COOLING FAN STARTED COMING ON, 7/7/2003, CAR OVER HEATED 10/04, DEALER REPLACED FAN AT MY COST. SHIFT OVER DRIVE LIGHT CAME ON 12/04 DEALER REPLACED SOLENOID SWITCH, 6/05 SHIFT OVER DRIVE SWITCH CAME BACK ON, NOW 2 SOLENOIDS ARE NOT WORKING AND MY CAR IS IN LIMP HOME MODE. NO 1ST OR 2 GEAR. *NM
NHTSA ODI #10132151
51,000 miles · Jun 13, 2005
Service Brakes, Air
ABS CONTROL MODULE FAILURE ON 1987 VOLVO 850
NHTSA ODI #10125178
Mileage unknown · May 30, 2005
Seat Belts
SEAT BELT RETRATOR ON BACK PASSENGER SEAT IS STUCK. THE SEAT BELT CANNOT BE USED.
NHTSA ODI #10122456
Mileage unknown · May 2, 2005
Exterior Lighting
HEADLIGHTS FAILED WHILE ON HIGHWAY. HEADLIGHT SWITCH DID NOT WORK. I PHONED VOLVO TO HONOR THE RECALL NHTSA CAMPAIGN ID NUMBER : 99V235000. VOLVO INFORMED ME THIS VOLVO DID NOT QUALIFY.*AK
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Additional source detail variants (2)
Electrical System
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
PE02029 · Passenger Compartment Fires
Opened Mar 7, 2002 · Closed Aug 22, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1997 Volvo 850 Problems, Complaints & Recalls | Skip That Year
Illustration