TL*THE CONTACT OWNS A 1997 VOLVO 850 WAGON. THE VEHICLE WAS TAKEN TO A SERVICE STATION FOR TIRE REPAIR AND THE FOLLOWING FAILURES WERE DISCOVERED: BOTH REAR BRAKES AND CALIPERS WERE SEIZED AND COMPLETELY INOPERABLE, THE EMERGENCY BRAKE WAS ALSO INOPERABLE, AND BOTH FRONT INNER AND OUTER TIE RODS NEEDED TO BE REPLACED. THE EST…
Read full complaint
TL*THE CONTACT OWNS A 1997 VOLVO 850 WAGON. THE VEHICLE WAS TAKEN TO A SERVICE STATION FOR TIRE REPAIR AND THE FOLLOWING FAILURES WERE DISCOVERED: BOTH REAR BRAKES AND CALIPERS WERE SEIZED AND COMPLETELY INOPERABLE, THE EMERGENCY BRAKE WAS ALSO INOPERABLE, AND BOTH FRONT INNER AND OUTER TIE RODS NEEDED TO BE REPLACED. THE ESTIMATED REPAIR COST WAS $1,230. THE VOLVO DEALER DIAGNOSED THE FOLLOWING FAILURES: BOTH FRONT LOWER CONTROL ARMS AND THE DRIVER SIDE TIE RODS FAILED, AN ALIGNMENT WAS NEEDED, THE FRONT AND REAR BRAKES FAILED, INCLUDING THE ROTOR AND CALIPERS, AND THERE WAS AN EMISSIONS ISSUE AS WELL. THE VEHICLE NEEDS COMPLETE EMISSION REPAIR. THE VEHICLE WAS PURCHASED ON JUNE 21, 2008 AND PASSED INSPECTION ON JUNE 25, 2008. THE FAILURE MILEAGE WAS 127,700.
NHTSA ODI #10234149
Mileage unknown · Nov 5, 2002
Power TrainStructure
THE CONSUMER WAS PULLING OUT OF THE DRIVEWAY AND NOTICED THAT THE VEHICLE WAS NOT SHIFTING FROM FIRST GEAR INTO SECOND. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TRANSMISSION FAILED. THE CONSUMER RECEIVED NO WARNING LIGHTS . *SCC
NHTSA ODI #567844
Mileage unknown · Jan 7, 2002
Power Train
WHEN VEHICLE IS SHIFTED IN TO GEAR, THE VEHICLE WILL GO IN THAT DIRECTION WITHOUT CONSUMER PUSHING CLUTCH AND GAS IN, VEHICLE DOES THIS ALL THE TIME, CONTACTED DEALER, AND THEY WERE NOT WILLING ASSIST. *AK WHEN THE CONSUMER TURNED ON THE IGNITION, THE VEHICLE MOVED IN REVERSE, AND DRIVER DOOR AND FENDER WERE DAMAGED, THE DEALER…
Read full complaint
WHEN VEHICLE IS SHIFTED IN TO GEAR, THE VEHICLE WILL GO IN THAT DIRECTION WITHOUT CONSUMER PUSHING CLUTCH AND GAS IN, VEHICLE DOES THIS ALL THE TIME, CONTACTED DEALER, AND THEY WERE NOT WILLING ASSIST. *AK WHEN THE CONSUMER TURNED ON THE IGNITION, THE VEHICLE MOVED IN REVERSE, AND DRIVER DOOR AND FENDER WERE DAMAGED, THE DEALER STATED THIS HAPPENED BECAUSE THE MANUFACTURER FAILED TO INSTALL A SAFETY SWITCH ON MANUAL TRANSMISSION. *YH
NHTSA ODI #8001674
Mileage unknown · Jul 14, 2001
Power Train
LEFT HUB-BEARING ASSEMBLY WAS REPLACED AT 44,490 MILES AND THEN HAD TO BE REPLACED AGAIN AT 55,000. *AK
NHTSA ODI #748473
Mileage unknown · May 22, 2000
Power Train
WHEN VEHICLE WAS PUT IN REVERSE IT DID A 360* TURN, CAUSING CONSUMER TO FIGHT WITH THE STEERING WHEEL TO MAINTAIN CONTROL. ENGINE WAS RACING, DRIVER TURNED IGNITION OFF TO STOP VEHICLE. *AK *ML
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Additional source detail variants (2)
Electrical System
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
PE02029 · Passenger Compartment Fires
Opened Mar 7, 2002 · Closed Aug 22, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1997 Volvo 850 Problems, Complaints & Recalls | Skip That Year
Illustration