DT*: THE CONTACT STATED WHILE DRIVING 35MPH ON A CITY STREET, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT COLLISION AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, NO INJURIES WERE SUSTAINED. THERE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT INSPE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 35MPH ON A CITY STREET, THE VEHICLE WAS INVOLVED IN A FRONT IMPACT COLLISION AND THE AIRBAGS DID NOT DEPLOY. THE CONTACT WAS WEARING A SEAT BELT, NO INJURIES WERE SUSTAINED. THERE WAS MINOR DAMAGE TO THE VEHICLE. THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS NOT INSPECTED. THE MANUFACTURER WAS NOT ALERTED.
NHTSA ODI #10166716
125,000 miles · Dec 21, 2004
Air Bags
I WAS DRIVING TO WORK, 7:30 A.M., CLEAR SUNNY COLD DAY. TRAVELING 55 MPH ON I 190 EXTENSION NEAR O'HARE AIRPORT IN CHGO. THE SRS LIGHT CAME ON MY DASHBOARD (WHICH I'VE NEVER SEEN BEFORE) AND AN INSTANT LATER THE PASSENGER SIDE AIRBAG EXPLODED OUT OF THE DASHBOARD. IT RIPPED APART THE DASHBOARD, AND CRACKED THE WINDSHIELD COMP…
Read full complaint
I WAS DRIVING TO WORK, 7:30 A.M., CLEAR SUNNY COLD DAY. TRAVELING 55 MPH ON I 190 EXTENSION NEAR O'HARE AIRPORT IN CHGO. THE SRS LIGHT CAME ON MY DASHBOARD (WHICH I'VE NEVER SEEN BEFORE) AND AN INSTANT LATER THE PASSENGER SIDE AIRBAG EXPLODED OUT OF THE DASHBOARD. IT RIPPED APART THE DASHBOARD, AND CRACKED THE WINDSHIELD COMPLETELY ACROSS. I PULLED OVER TO THE RIGHT SHOULDER, TURNED THE CAR OFF AND QUICKLY GOT OUT. THE FUMES AND DUST FROM THE AIRBAG WERE TERRIBLE. ALTHOUGH DRIVE-ABLE, I HAD THE CAR TOWED TO THE VOLVO OF LISLE, IL DEALER SINCE IT SEEMED TO ME TO BE AN OBVIOUS MANUFACTURER'S DEFECT. NO CRASH, NO ACCIDENT, NO COLLISION, AND A SPLIT SECOND WARNING.*AK THE DEALER REPS HAVE HAD MY CAR FOR 3 WEEKS. THE DEALER INITIALLY SAID THAT THEY COULD FIND NO REASON FOR THE DEPLOYMENT, BUT WOULDN'T BEGIN ANY REPAIR UNLESS I/MY INSURER PAID THE BILL. I WAS IN TOUCH WITH VOLVO OF N.A. WITHIN 24 HOURS. THEY INDICATED THAT THEY WOULD SEND OUT AN ENGINEER TO INVESTIGATE. TO DATE, I'VE NOT GOTTEN A REPORT OR AN ANSWER ON THE STATUS OF THIS INVESTIGATION, MY CAR SITS UNREPAIRED AT THE DEALER, AND I'M ON WEEK 3 WITH A RENTAL CAR THAT I FEEL THEY NEED TO PAY FOR AS WELL. I COULD REALLY USE AN ADVOCATE HERE---I'M GETTING A RUN-AROUND.
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON SOME SEDANS AND STATION WAGONS EQUIPPED WITH SEAT HEATERS, IT IS POSSIBLE THAT EXCESSIVE COMPRESSION OF THE SEAT CUSHION COULD CAUSE DAMAGE TO THE ELECTRICAL WIRING OF THE SEAT HEATER.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DAMAGE COULD RESULT IN A SHORT CIRCUIT THAT COULD CAUSE A FIRE.
Remedy: DEALERS WILL DISCONNECT THE EXISTING WIRES AND INSTALL A NEW ELECTRONIC THERMOSTAT AND CABLE HARNESS. OWNER NOTIFICATION BEGAN ON FEBRUARY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Additional source detail variants (2)
Electrical System
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
Seats:front Assembly:seat Heater/cooler
VOLVO IS CONDUCTING A SAFETY RECALL BASED ON ITS ANALYSIS OF COMPLAINTS AND TECHNICAL INFORMATION DEVELOPED DURING ITS INVESTIGATION.VOLVO'SSURVEY OF VEHICLES ROUTINELY BROUGHT IN FOR MAINTENANCE AT EAST-COAST DEALERSHIPS PRODUCED EVIDENCE THAT BARE METAL WIRES (THAT PROVIDE SUPPORT FOR THE SEAT BOTTOM) CAN CONTACT THE THERMOSTAT AND ELECTRICAL WIRESIN OR BENEATH THE SEAT CUSHION.THIS CAN RESULT IN AN ELECTRICAL SHORT.VOLVO CONFIRMED IN TESTING THAT IF SUCH A CONDITION IS PRESENT, THE SHORT TO THE WIRE SEAT SUPPORT COULD CAUSE BURNING OF THE SEAT CUSHION WITHOUT ACTIVATING (OPENING) THE SEAT HEATER FUSE.VOLVO WILL REPLACE THE ENTIRE THERMOSTAT ASSEMBLY WITH AN ELECTRONIC TIMER DELAY UNIT.
PE02029 · Passenger Compartment Fires
Opened Mar 7, 2002 · Closed Aug 22, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1997 Volvo 850 Problems, Complaints & Recalls | Skip That Year
Illustration