Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 111 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports9 fire reports8 injury reports
What owners actually said
111 reports
93,000 miles · Jul 29, 2005
Engine And Engine Cooling
DT: RECEIVED MANUFACTURER'S RECALL S139032105, TOOK VEHICLE TO DEALER FOR RECALL REPAIRS. AFTER AN EMISSION TEST WAS DONE VEHICLE DID NOT PASS IT. VEHICLE WAS TAKEN BACK TO DEALER FOR A CHECK UP. THE DEALER SAID THAT PART FOR THE EMISSION WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER STATED THE SAME THING. THIS WA…
Read full complaint
DT: RECEIVED MANUFACTURER'S RECALL S139032105, TOOK VEHICLE TO DEALER FOR RECALL REPAIRS. AFTER AN EMISSION TEST WAS DONE VEHICLE DID NOT PASS IT. VEHICLE WAS TAKEN BACK TO DEALER FOR A CHECK UP. THE DEALER SAID THAT PART FOR THE EMISSION WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER STATED THE SAME THING. THIS WAS DONE ON JULY 18, 2005. CONSUMER BELIEVED THIS PART SHOULD BE INCLUDED IN THE RECALL BECAUSE IT WAS RELATED TO THE DEFECTIVE PART MENTIONED IN THE RECALL. *AK
NHTSA ODI #10130598
Mileage unknown · May 23, 2005
Electrical SystemFire
UPON STARTING THE VEHICLE, AND BACKING OUT THE DRIVE WAY, CONSUMER SAW SMOKE, SEEMED TO BE COMING FROM UNDER DRIVER'S SEAT. CONSUMER THEN WENT INTO THE HOUSE TO GET WATER. UPON RETURNING TO THE VEHICLE IT WAS ENGULFED IN SMOKE, AND FIRE.*AK *BF *NM
NHTSA ODI #10115446
Mileage unknown · Apr 29, 2005
Fuel System, Gasoline
CONSUMER RECEIVED A RECALL NOTICE FOR 1995 VOLVO 850 IN WHICH SHE SOLD. CONSUMER WANTS THE NEW OWNER CONTACTED IN REFERENCE TO THE RECALL.***NO ANSWER REQUIRED***. *MR BEFORE THE CONSUMER SOLD THE VEHICLE SHE COMPLAINED OF A GAS ODOR, BUT THE DEALER ALWAYS STATED THERE WAS NOTHING WRONG. *JB
NHTSA ODI #10120387
168,000 miles · Feb 25, 2005
Engine And Engine CoolingFire
WHILE ATTEMPTING TO START THE VEHICLE IT CAUGHT FIRE IN THE ENGINE COMPARTMENT WITHOUT WARNING. THE CONSUMER STATES THAT THERE WAS EXCESSIVE FUEL LEAKAGE. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM
NHTSA ODI #10113069
200,000 miles · Aug 23, 2004
Fuel System, Diesel
GAS WAS LEAKING ONTO THE GROUND DUE TO HEAT SHIELD BEING PUNCTURED. *AK
NHTSA ODI #10089472
95,204 miles · Jul 30, 2004
Fuel System, GasolineFuel System, Other
I PURCHASED A USED VEHICLE AND FILLED THE TANK FULL UNTIL AUTO PUMP KICKED OFF, DROVE LESS THAN 1 MILE HOME AND PARKED IN THE GARGE. THE NEXT MORNING, GARAGE FILLED WITH GAS FUME ODOR, NO VISIBLE LEAK, RESEARCHED HAYNED REPAIR MANUAL, FOUND ACCESS COVER TO FUEL TANK SENDING UNIT AND FUEL PUMP INSIDE VEHICLE, REMOVED COVERS, FOUN…
Read full complaint
I PURCHASED A USED VEHICLE AND FILLED THE TANK FULL UNTIL AUTO PUMP KICKED OFF, DROVE LESS THAN 1 MILE HOME AND PARKED IN THE GARGE. THE NEXT MORNING, GARAGE FILLED WITH GAS FUME ODOR, NO VISIBLE LEAK, RESEARCHED HAYNED REPAIR MANUAL, FOUND ACCESS COVER TO FUEL TANK SENDING UNIT AND FUEL PUMP INSIDE VEHICLE, REMOVED COVERS, FOUND FUEL LEAK AT FUEL PUMP COVER.*AK
NHTSA ODI #10083015
88,000 miles · Jun 23, 2004
Fuel System, Other
CONSUMER SAW/SMELLED FUEL LEAKING FROM THE FUEL TANK. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10079731
Mileage unknown · Mar 15, 2004
Structure
WHEN SHUTTING BOTH FRONTAL DOORS CONSUMER NOTICED THAT THE DOOR HINGES BROKE FROM THE FRAME OF THE VEHICLE. THIS WAS CAUSING THE DOORS NOT TO CLOSE. CONSUMER WILL CONTACT THE DEALERSHIP ABOUT THIS ISSUE. *AK
NHTSA ODI #10063161
Mileage unknown · Mar 11, 2004
SeatsFire
CONSUMER'S HEATED SEAT CAUGHT ON FIRE. THE SEATS FABRIC CONTAINED THE FIRE. *AK *NM
NHTSA ODI #10057945
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingSeat BeltsUnknown Or Other
THE FRONT SEATS HAVE BROKEN THREE TIMES. THE BAND THAT KEEPS THE BACKS IN POSITION EITHER FAILS AND THE SEAT WILL NOT RETURN TO A PREVIOUS POSITION OR IT SLIPS AND FAILS TO ADJEST THE SEATS. THIS WAS FIXED AND PAID FOR TWICE. NOW WITHIN 15 MONTHS IT HAS FAILED AGAIN AND SMYTHE VOLVO WILL ONLY OFFER A 10% REDUCTION IN THE COST…
Read full complaint
THE FRONT SEATS HAVE BROKEN THREE TIMES. THE BAND THAT KEEPS THE BACKS IN POSITION EITHER FAILS AND THE SEAT WILL NOT RETURN TO A PREVIOUS POSITION OR IT SLIPS AND FAILS TO ADJEST THE SEATS. THIS WAS FIXED AND PAID FOR TWICE. NOW WITHIN 15 MONTHS IT HAS FAILED AGAIN AND SMYTHE VOLVO WILL ONLY OFFER A 10% REDUCTION IN THE COST. THIS SHOULD LAST MONGER THEN 15 MONTHS. I WOULD LIKE TO KNOW IF ANYONE ELSE HAS HAD THIS PROBLEM. WE WEIGH 124 AND 145 RESPECTIVELY. WE HAVEN'T ADJUSTED THE SEATS VERY OFTEN. WOULD LIKE TO KNOW HOW COMMON THIS PROBLEM IS. VOLVO SAYS IT IS NOT COMMON. WE THINK IT IS DEFECTIVE REPAIR OR DEFECTIVE DESIGN AND THEY SHARE IN THE RESPONSIBILITY. PLEASE ADVISE.
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
SOME OF THE JACKS SUPPLIED WITH THE VEHICLES DO NOT HAVE THE NECESSARY LOAD CAPACITY.
Consequence: A RAISED VEHICLE CAN FALL OFF THE JACK INCREASING THE LIKELIHOOD FOR PERSONAL INJURY OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT AND REPLACE SUSPECT JACKS WITH A JACK MEETING THE LOAD REQUIREMENTS FOR THESE CARS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA03008 · Fuel Tank Leaks
Opened Jun 11, 2003 · Closed Jul 28, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.
THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1995 Volvo 850 Problems, Complaints & Recalls | Skip That Year
Illustration