Tires. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports9 fire reports8 injury reports

Fuel/propulsion System complaints

1 reports

Clear category filter

147,000 miles · Mar 12, 2013

Fuel/propulsion System

Read full complaint

TL* THE CONTACT OWNS A 1995 VOLVO 850. THE CONTACT STATED THAT THE ODOR OF GASOLINE FUEL WAS EMITTED INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE FUEL HOSE WAS LEAKING. THE HOSE WAS REPLACED HOWEVER, THE CONTACT CONTINUED TO SMELL FUEL. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC AND ANOTHER CRACKED HOSE WAS REPLACED BUT TO NO AVAIL. THE CONTACT STATED THAT HE COLD SEE GASOLINE FUEL LEAKING FROM UNDER THE FUEL TANK WHENEVER REFUELING THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V368000 (FUEL SYSTEM, GASOLINE) AND THE VEHICLE WAS TAKEN TO A DEALER FOR REPAIR. HE WAS INFORMED THAT AN EXHAUST PIPE WOULD OCCASIONALLY STRIKE THE FUEL TANK, CAUSING A STRESS FRACTURE IN THE TANK. AS A RESULT, THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 147,000.

NHTSA ODI #10502506

Official recalls

04V368000 · Fuel System, Gasoline:storage

Jul 30, 2004

ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

95V050000 · Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift; Equipment:mechanical:integrated Jack/leveler/stabilizer

Mar 10, 1995

SOME OF THE JACKS SUPPLIED WITH THE VEHICLES DO NOT HAVE THE NECESSARY LOAD CAPACITY.

Consequence & remedy

Consequence: A RAISED VEHICLE CAN FALL OFF THE JACK INCREASING THE LIKELIHOOD FOR PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND REPLACE SUSPECT JACKS WITH A JACK MEETING THE LOAD REQUIREMENTS FOR THESE CARS.

Additional source detail variants (2)

Equipment:mechanical:integrated Jack/leveler/stabilizer

SOME OF THE JACKS SUPPLIED WITH THE VEHICLES DO NOT HAVE THE NECESSARY LOAD CAPACITY.

Consequence: A RAISED VEHICLE CAN FALL OFF THE JACK INCREASING THE LIKELIHOOD FOR PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND REPLACE SUSPECT JACKS WITH A JACK MEETING THE LOAD REQUIREMENTS FOR THESE CARS.

Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift

SOME OF THE JACKS SUPPLIED WITH THE VEHICLES DO NOT HAVE THE NECESSARY LOAD CAPACITY.

Consequence: A RAISED VEHICLE CAN FALL OFF THE JACK INCREASING THE LIKELIHOOD FOR PERSONAL INJURY OR PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND REPLACE SUSPECT JACKS WITH A JACK MEETING THE LOAD REQUIREMENTS FOR THESE CARS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA03008 · Fuel Tank Leaks

Opened Jun 11, 2003 · Closed Jul 28, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage

THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.

PE03003 · Fuel Tank Leaks

Opened Jan 16, 2003 · Closed Jun 11, 2003

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.

PE99040 · Inadvertent Side Air Bag Deployment

Opened Jun 7, 1999 · Closed Oct 27, 1999

Status: closed (inferred from source dates) · Air Bags:side/window

No summary supplied.