Electrical System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports3 fire reports9 injury reports

Seat Belts complaints

2 reports

Clear category filter

Mileage unknown · Sep 2, 1997

Air BagsElectrical SystemSeat Belts

Read full complaint

IF THE CRASH SENSOR LOCATED IN THE CENTER CONSOLE UNDER THE ORIGINAL EQUIPMENT CUP HOLDER BETWEEN THE TWO FRONT SEATS GETS WET IT WILL DISABLE THE AIR BAGS, AND THE SEAT BELT WILL NOT WORK. THE DEALER WANTS THE OWNER TO PAY 1158 TO CORRECT THE PROBLEM THAT HE IS HAVING WITH THE ELECTRICAL SYSTEM, CAUSING THE AIR BAG AND THE SEAT BELT NOT TO WORK IF EITHER FUNCTION GETS WET. *AK VEHICLE ALSO EXPERIENCED FLASHING LIGHTS AND DEALER STATED THIS WAS DUE TO A FAULTY REGULATOR, CONSUMER FEELS THAT THE CRASH SENSOR DID NOT GET WET DUE TO IT HAD NOT BEEN OPENED FOR INSPECTION, CONSUMER FEELS THAT THERE IS AN ELECRICAL PROBLEM THAT IS CAUSING LIGHTS TO FLASH AND POTENTIAL PROBLEMS WITH THE AIR BAGS. *SLC

NHTSA ODI #815872

Mileage unknown · Nov 14, 1995

Seat Belts

SEAT BELT DOES NOT FASTEN THE CENTURY CHILD SAFETY SEAT SECURELY. *SD

NHTSA ODI #488096

Official recalls

04V368000 · Fuel System, Gasoline:storage

Jul 30, 2004

ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF ALABAMA, ARKANSAS, ARIZONA, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, AND UTAH, AND AS A SERVICE RECALL IN THE OTHER 33 STATES AND THE DISTRICT OF COLUMBIA. THE RECALL BEGAN ON SEPTEMBER 24, 2004. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

94V173000 · Vehicle Speed Control

Sep 13, 1994

UNDER VERY COLD WEATHER CONDITIONS, ICE CRYSTALS CAN FORM AT THE THROTTLE IN THE ENGINE INTAKE SYSTEM, AND PREVENT THE THROTTLE FROM RETURNING TO IDLE.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE LOSS OF SPEED CONTROL AND CAN RESULT IN UNWANTED ACCELERATION AND A POSSIBLE ACCIDENT.

Remedy: DEALERS WILL REPLACE THE THROTTLE BODY, THROTTLE CABLE, CHARGE AIR COOLER PIPING AND CRANKCASE VENTILATION HOSES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA03008 · Fuel Tank Leaks

Opened Jun 11, 2003 · Closed Jul 28, 2004

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage

THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.

PE03003 · Fuel Tank Leaks

Opened Jan 16, 2003 · Closed Jun 11, 2003

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly

THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.