IllustrationTHE OWNER REPORTS POOR MILEAGE AND DURABILITY OF THE FRONT WHEEL BEARINGS AND HAS HAD A PROBLEM WITH EXCESIVE STEER AXLE WEIGHT, FUEL TANKS AND 5TH WHEEL RAILS MOVE AFT BUT STEER AXLE WEIGHT RUNS ABOUT 13,140 LBS (CUMMINS ENGINE)(REPORTED TO MANUFACTURER). NLM
1998 Volvo 770
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 770 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 39 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
Suspension complaints
19 reportsCONSUMER STATES THE U-BOLT FAILED, HOWEVER IS UNSURE AS TO IF IT FAILED BEFORE OR AS THE RESULT OF VEHICLE CRASH. *MJ
VEHICLE WAS EXPEREINCING NUMEROUS ELECTRICAL PROBLEMS, THE FUSES IN THE DASH WERE CONTINUOUSLY BLOWING BECAUSE OF A LOOSE WIRE ON SEVERAL OCCASSIONS, THE STARTER WAS REPLACED, THERE WERE KEY SWITCH PROBLEMS, AND THE TRAILER POWER CORD WAS INOPERATIVE, DEALER REPLACED THE WIRING HARNESS.*JB
CONSUMER STATES THE TRUCK HAD BROKEN SUSPENSION BOLT. *YH
CONSUMER EXPERIENCING VARIOUS FRONT END PROBLEMS. NEW SPINDLE AND SPRINGS WERE INSTALLED. *TT
EXPERIENCING HEAVY FRONT END, VEHICLE IS ON FOURTH SET OF STEER TIRES, CAB ALIGNMENT THREE TIMES. *TT
THE CONSUMER STATED THAT THE PASSENGER SIDE REAR AXLE HAD A U-BOLT PROBLEMS. *YH
THE TRUCK IS OVER WEIGHT ON THE FRONT END AND THE DEALER MOVED THE FUEL TANK TO THE BACK TO TAKE OFF SOME OF THE WEIGHT. *YH
CONSUMER HAS HAD TO REPLACE 10 OR 11 SETS OF DRIVE AXLE U-BOLTS ALSO THE FRONT AXLE IS OVER WEIGHT. *JG
WHILE DRIVING, THE RIGHT FRONT STEER TIRE EXPERIENCED A BLOWOUT, CAUSING $9990 IN DAMAGES, CONSUMER BARELY AVOIDED A BRIDGE AND TRAFFIC, THE STEER AXLE WEIGHT IS A PROBLEM, POSSIBLY CAUSING TIRE WEAR AND CAUSING VEHICLE TO PULL TO THE RIGHT WITH NO STEERING INPUT. *SLC
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02021 · Front Suspension U-BOLTS Loosen Or Break
Opened Sep 6, 2002 · Closed Nov 6, 2003
Status: closed (inferred from source dates) · Suspension
ODI'SINVESTIGATION DID NOT FIND ANY EVIDENCE THAT LOOSE OR BROKENFRONT SUSPENSION U-BOLTS HAVE CAUSED OR CONTRIBUTED TO ANY CRASHES OR NEAR MISS EVENTS.SEE THE ATTACHED ENGINEERING ANALYSISREPORT FOR FULL TECHNICAL DETAILS.* 1996/1997 BUILT VEHICLES ARE DESIGNATED BY VOLVO AS 1998 MODEL YEAR.
PE01040 · Sleeper Berth Fires
Opened Dec 3, 2001 · Closed Mar 26, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE01041 · Steering Gearbox Or U-JOINT
Opened Dec 3, 2001 · Closed Jun 14, 2002
Status: closed (inferred from source dates) · Steering
No summary supplied.
PE01042 · Steering Axle U-BOLT
Opened Dec 3, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Steering
No summary supplied.
DP01005 · Multiple Defects
Opened Aug 9, 2001 · Closed Oct 3, 2001
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGE THAT THE WIA MODEL INSTRUMENT PANEL AND BLOWER FAN MALFUNCTION AND THE 770 VNL STEERING DIFFICULTIES AND INSTRUMENT PANEL MALFUNCTION