Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
MY DIESEL VW TOUAREG NEEDS THE NOX SENSOR REPLACED. WHY IS THIS NOT CONSIDERED PART OF THE WARRANTY FOR THE EMISSIONS SYSTEM ? SINDE THE EPA HAS DESIGNATED THE VW DIESELS MUST BE EITHER BUYBACK OR REPLACED/REPAIRED IT SEEMS APPARENT THAT THIS SENSOR IS JUST AS IMPORTANT TO THE FUNCTION OF THE EMISSIONS SYSTEM BUT IT IS NOT A CO…
Read full complaint
MY DIESEL VW TOUAREG NEEDS THE NOX SENSOR REPLACED. WHY IS THIS NOT CONSIDERED PART OF THE WARRANTY FOR THE EMISSIONS SYSTEM ? SINDE THE EPA HAS DESIGNATED THE VW DIESELS MUST BE EITHER BUYBACK OR REPLACED/REPAIRED IT SEEMS APPARENT THAT THIS SENSOR IS JUST AS IMPORTANT TO THE FUNCTION OF THE EMISSIONS SYSTEM BUT IT IS NOT A COVERED PART. THIS PART IS VERY EXPENSIVE AND FUNCTIONS ALONG WITH THE AD-BLUE PUMP WHICH IS COVERED.
NHTSA ODI #10960193
77,000 miles · May 31, 2016
Unknown Or OtherInjury
WHILE DRIVING AT APPROXIMATELY 60MPH ON A SMOOTH TWO LANE WIDE HIGHWAY THE FRONT SUNROOF PANEL (PANORAMIC) SHATTERED. THERE WERE NO OTHER VEHICLES ON THE ROAD, NO OVERPASSES AND NO TREES ABOVE. IT WAS AROUND 65-70 DEGREES FAHRENHEIT. IT WAS NOT HAILING OR RAINING AT THE TIME. NO OBJECTS WERE RECOVERED FROM INSIDE OF THE VEHI…
Read full complaint
WHILE DRIVING AT APPROXIMATELY 60MPH ON A SMOOTH TWO LANE WIDE HIGHWAY THE FRONT SUNROOF PANEL (PANORAMIC) SHATTERED. THERE WERE NO OTHER VEHICLES ON THE ROAD, NO OVERPASSES AND NO TREES ABOVE. IT WAS AROUND 65-70 DEGREES FAHRENHEIT. IT WAS NOT HAILING OR RAINING AT THE TIME. NO OBJECTS WERE RECOVERED FROM INSIDE OF THE VEHICLE. THE GLASS APPEARED TO HAVE BROKEN UPWARDS INSTEAD OF INWARDS. FIANC AND TWO DOGS (TRUNK AREA) WERE INSIDE OF THE CRUCIBLE. GLASS CAUSED VERY MINOR CUTS. VEHICLE RECENTLY DETAILED AND ALSO CLEANED BY MYSELF. NO ROCK CHIPS PRESENT IN SUNROOF GLASS. NO VISIBLE CRACKS PRIOR TO INCIDENT.
NHTSA ODI #10871581
600 miles · Aug 28, 2013
SteeringUnknown Or Other
AT HIGHWAY SPEEDS, 60-75MPH, THE STEERING WHEEL SHAKES DRAMATICALLY. DEALER RE-BALANCED, STILL SHOOK. DEALER REPLACED EAGLE LS2'S AT 32K MILES WITH SAME TIRES AND ROAD-FORCE BALANCED...STILL SHOOK. BASED ON OTHERS WITH SAME PROBLEM, I RECOMMENED THEY TRY GY LATITUDES...ALONG WITH ROAD-FORCE BALANCE AND NITRO FILL, SHAKING HAS…
Read full complaint
AT HIGHWAY SPEEDS, 60-75MPH, THE STEERING WHEEL SHAKES DRAMATICALLY. DEALER RE-BALANCED, STILL SHOOK. DEALER REPLACED EAGLE LS2'S AT 32K MILES WITH SAME TIRES AND ROAD-FORCE BALANCED...STILL SHOOK. BASED ON OTHERS WITH SAME PROBLEM, I RECOMMENED THEY TRY GY LATITUDES...ALONG WITH ROAD-FORCE BALANCE AND NITRO FILL, SHAKING HAS BEEN GONE FOR PAST 15K MILES. BUT THIS IS A REPEATABLE EVENT ON FLAT/SMOOTH ROAD SURFACES, AT SPEED. MANY DEALERS APPARENTLY UNABLE TO CORRECT, BASED ON FEEDBACK AT VARIOUS TOUAREG FAN SITES (VW VORTEX, CLUB TOUAREG, ETC.) SEEMS TO IMPACT TDI LUX (MY TRIM) MORE THAN OTHERS, FROM 2011-2013. *TT
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2016 Touareg vehicles. The brake pedal pivot pin may be missing a securing clip, allowing the pivot pin to move and the brake pedal to dislodge.
Consequence & remedy
Consequence: If the brake pedal dislodges, the driver may not be able to apply the brakes, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the brake pedal assembly to verify the presence of the securing clip and install any missing securing clips, free of charge. The recall began on April 27, 2016. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 46G4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration