Electronic Stability Control (esc)EngineFuel/propulsion System
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS DOING FINE EXCEPT NOW THE EMI…
Read full complaint
I WAS DRIVING ON THE HIGHWAY @ 70MPR WHEN ALL OF A SUDDEN WITHOUT WARNING THE CAR STARTS ACTING SLUGGISH FOR A MIN THEN BACK TO NORMAL, AND RANDOMLY FOR THE NEXT HOUR OR SO DOES(I HAD A WAYS TO GO) THIS A FEW MORE TIMES. I GOT TO MY DESTINATION AND LET HER REST FOR THE NIGHT. THE NEXT MORNING IT WAS DOING FINE EXCEPT NOW THE EMISSION CONTROL LIGHT CAME ON AND STAYED ON. BY THIS TIME IT WAS TIME FOR THE 100,000 MILE MAINTENANCE TO BE DONE AND IT DID GREAT UNTIL ABOUT 6 MONTHS LATER I WAS DRIVING @ 35MPR WHEN IT STARTED LOOSING POWER, THO I ONLY LOST A LITTLE BIT OF POWER STEERING WAS FORCED TO COME TO A STOP, WHICH JUST HAPPEN TO BE A ONE WAY BRIDGE, BABY IN THE CAR AND HAD TO PUSH MYSELF THE REST OF THE WAY ACROSS IT. ONCE OFF THE BRIDGE I TURNED THE CAR OFF (IT STAYED ON TIL I DID THIS) LET IT REST A MINUTE AND IT STARTED UP FINE AND LET ME GO A FEW BLOCKS STILL SLUGGISH AND THEN LOST POWER AGAIN. I REPEATED THIS PROCESS FOR ABOUT 5 MILES OR SO WHEN I WAS FORCED TO PARK IT CUZ I DIDN'T WANT TO RISK CROSSING THE HIGHWAY AGAIN. HAD IT TOWED TO DEALERSHIP WHERE THEY DID THE FLANGE RECALL, THAT DIDNT' FIX THE PROBLEM SO HAD TO REPLACE BOTH FUEL PUMPS AND THAT WAS ROUGHLY @ 103,000. 8 MONTHS LATER IT HAPPENS AGAIN THIS TIME AROUND 107,000. DEALERSHIP TOOK 4 HOURS TO DIAGNOSE ONLY TO TELL ME I NEED THE FUEL TANK REPLACED BECAUSE SOMEHOW ALL THE WIRES, CONNECTORS, AND CAPS THAT HAVE TO DO WITH THE FUEL LINES/TANK/PUMPS ARE EITHER MISSING, CRACKED, OR DAMAGED SO I NEED A WIRING HARNESS AS WELL. THEY ARE QUOTING A ME $5000 FIX!!!
NHTSA ODI #11229973
Mileage unknown · Apr 5, 2016
Electrical SystemElectronic Stability Control (esc)Steering
THE EMERGENCY BRAKE ALARM WAS GOING OFF MORE FREQUENTLY AND TO SILENCE IT I WOULD PULL THE SPING ON THE BRAKE UP. THE BRAKE ALARM RANDOMLY WAS ANOYING BUT NOT A MAJOR CONCERN. I HADN'T HAD ANY MECHANICAL ISSUES WITH MY CAR UNTIL 01/23/16 I ATTEMPTED TO START MY CAR AND RECIEVED AN ERROR MESSAGE THE READ STEERING DEFECT AND IT W…
Read full complaint
THE EMERGENCY BRAKE ALARM WAS GOING OFF MORE FREQUENTLY AND TO SILENCE IT I WOULD PULL THE SPING ON THE BRAKE UP. THE BRAKE ALARM RANDOMLY WAS ANOYING BUT NOT A MAJOR CONCERN. I HADN'T HAD ANY MECHANICAL ISSUES WITH MY CAR UNTIL 01/23/16 I ATTEMPTED TO START MY CAR AND RECIEVED AN ERROR MESSAGE THE READ STEERING DEFECT AND IT WOULDN'T ALLOW YOU TO START THE CAR BEYOND THE ERROR MESSAGE. I HAD MY CAR TOWED TO VOLKSWAGON MENTOR OHIO AFTER HOLDING MY CAR FOR MORE THAN A WEEK I WAS FINALLY OFFERED A DIAGNOSIS THAT THE ACCESS MODULAR WAS NOT FUNCTIONING MEANING THE BRAIN OF THE VEHICLE WASN'T FUNCTIONING AND THE VW DEALERSHIP SERVICE DEPARTMENT DIDN'T HAVE ANSWER TO HOW THIS HAPPENED THEY HAD A $2500 SOLUTION TO THE PROBLEM AND THEY WERE MORE THAN HAPPY TO ASSIST IN REPLACEMENT OF THE ACCESS MODULAR WITH THERE HEARTY COST. THE BRAIN THE VOLKSWAGON ACCESS MODULAR STOPS FUNCTIONING AND VOLKSWAGEN AT NO FAULT OF MINE AND I'M CHARGED $2500 PLUS. MECHANICAL MAINTENANCE I UNDERSTAND BUT REPLACEMENT OF THE VEHICLES ACCESS MODULAR IS A REPAIR THAT I FEEL VOLKSWGON SHOULD COVER.
NHTSA ODI #10853446
115,000 miles · Jan 26, 2015
Electrical SystemElectronic Stability Control (esc)Steering
I RECENTLY PURCHASED A 2004 VW TUAREG IN JULY 1ST OF 2014. IMMEDIATELY UPON PURCHASING THE VEHICLE I BEGAN RECEIVING A PARKING BRAKE ALARM WHEN I TURNED ON THE VEHICLE. THE ALARM WOULD PERSIST UNTIL I PUSHED DOWN ON THE PARKING BRAKE. I WOULD ALSO RECEIVE AN OCCASIONAL ALARM FOR THE TIRE PRESSURE MONITORING SYSTEM. THEN, ON DECE…
Read full complaint
I RECENTLY PURCHASED A 2004 VW TUAREG IN JULY 1ST OF 2014. IMMEDIATELY UPON PURCHASING THE VEHICLE I BEGAN RECEIVING A PARKING BRAKE ALARM WHEN I TURNED ON THE VEHICLE. THE ALARM WOULD PERSIST UNTIL I PUSHED DOWN ON THE PARKING BRAKE. I WOULD ALSO RECEIVE AN OCCASIONAL ALARM FOR THE TIRE PRESSURE MONITORING SYSTEM. THEN, ON DECEMBER 15, 2014 THE VEHICLE REFUSED TO TURN ON AT ALL. THE DASHBOARD DISPLAY HAD A FLASHING STEERING WHEEL. I HAD THE VEHICLE TOWED TO A VOLKSWAGEN DEALERSHIP WHERE THE TECHNICIANS LOOKED IT OVER AND TOLD ME THAT THE CAUSE OF THE PROBLEM IS THAT TWO CABLES TOUCHED AND SHORTED OUT THE SYSTEM. AFTER 3 WEEKS OF HOLDING THE VEHICLE, THE COST OF REPAIR WAS QUOTED AT AROUND $3,500 TO REPLACE SOME MODULES. I WAS ALSO INFORMED THAT THIS MIGHT BE A RECALL ISSUE AS MANY OTHER 2004 VW TUAREGS HAVE HAD SIMILAR PROBLEMS. *TR
NHTSA ODI #10679060
112 miles · Jul 30, 2014
Electronic Stability Control (esc)Steering
WOULDN'T START SO HAD IT TOWED TO NORTHLAND VOLKSWAGEN. THERE THEY TESTED AND SAID I NEEDED STEERING COLUMN REPLACED AND WIRING DONE . NOT SURE BUT HAVE NEVER HAD PROBLEMS WITH COLUMN NOT PERFORMING CORRECTLY BUT I DON'T HAVE A CLUE ABOUT WIRING INSIDE ONE. THE REPAIRS ARE 2538.08 AND 1567.77 IS FOR THE COLUMN. *TR
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
Remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE06022 · Srs Warning Light Illumination
Opened Jun 19, 2006 · Closed Oct 30, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:side/window
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05042 · Exterior Door Handle Malfunction
Opened Aug 11, 2005 · Closed Dec 21, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) DATED JUNE 10, 2005, DESCRIBING A CONDITION OF EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER THE DOOR IS OPENED.VW DESCRIBED THE CAUSE OF THE PROBLEM TO BE A POTENTIAL FOR INCREASED FRICTION BETWEEN THE DOOR HANDLE AND THE LOCK CYLINDER HOUSING . . . BECAUSE SOME GUIDE NUBS THAT WERE MOLDED INTO THE PLASTIC DOOR HANDLE . . . WERE SLIGHTLY HIGHER THAN SPECIFIED.IN ADDITION TO THE TSB, VW HAS INTRODUCED PRODUCTION CHANGES (LUBRICATION, DELETION OF THE GUIDE NUBS, INTRODUCTION OF A LOW FRICTION GUIDE SURFACE ON THE LOCK CYLINDER HOUSING) TO ADDRESS THE PROBLEM.VW REPORTS THAT THE FAILURE OCCURS PREDOMINANTLY IN THE VERY EARLY LIFE STAGE OF THE VEHICLE.ODI EXAMINATION OF VW'S WARRANTY DATA SHOWS FEWER CLAIMS AS THE VEHICLE AGES.THE ONE INJURY RESULTED WHEN THE UNLATCHED DOOR HIT THE OCCUPANT'S HAND.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR COMPLAINTS ANDRESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2004 Volkswagen Touareg Problems, Complaints & Recalls | Skip That Year
Illustration