2022 Volkswagen Tiguan

I own a 2022 Volkswagen Tiguan that has experienced ongoing excessive oil consumption. At approximately 60,000 miles, the vehicle experienced a much more serious incident. While traveling approximately 75 mph on the interstate, the vehicle began actively spraying engine oil, covering the exterior of the vehicle. A warning light then appeared instructing me to check the engine oil level. I was able to exit the interstate and pull into a gas station. Once parked, the vehicle was leaking an excessive amount of oil onto the concrete underneath it. I contacted the dealership, and they immediately understood the issue because they had seen the same problem occur in other Volkswagen Tiguans. I am concerned that the sudden and substantial loss of engine oil while traveling approximately 75 mph presents a serious safety risk. This type of failure could potentially cause catastrophic engine damage or engine failure at highway speeds, leaving the vehicle disabled in active traffic. I am also concerned about the possibility of oil contacting hot engine components and creating a fire hazard. This incident is especially concerning given the vehicle's prior history of excessive oil consumption and the dealership's statement that they had encountered the same issue in other Volkswagen Tiguans. I am concerned there may be an underlying defect involving the engine or oil system. I am submitting this complaint so NHTSA can document the incident and evaluate whether similar complaints involving 2022 Volkswagen Tiguan vehicles indicate a broader safety-related defect.

EPC light kicks on which is puts your car in limp mode, which is caused by a cylinder head issue. The EPC limits your car acceleration and speed ability, this is extremely dangerous especially on the highway. It’s been a year & Volkswagen is refusing to take responsibility and offer a recall when it’s an ongoing issue with 2021-2022 Volkswagen Tiguans. The cylinder heads have been on back order for a year. This is an issue I believe that needs a nation wide investigation & recall for customers.

My 2022 Volkswagen Tiguan has an ongoing excessive oil consumption problem that began in April 2025 when the low oil warning illuminated. I added approximately one quart of oil and contacted the Volkswagen dealership. The dealership instructed me not to add oil myself if the warning returned and to bring the vehicle in for evaluation. On May 12, 2025, I brought the vehicle to the Volkswagen dealership and an oil consumption test was performed. The problem continued. I returned the vehicle on July 25, 2025, and a second oil consumption test was performed. The dealership subsequently replaced the PCV valve in the engine in an attempt to correct the oil consumption problem. On August 25, 2026, the check oil warning illuminated again, indicating that the problem has continued despite two oil consumption tests and replacement of the PCV valve. The dealership is now requesting that I bring the vehicle back for a third oil consumption test. The vehicle has repeatedly been made available to the Volkswagen dealership for inspection and repair. Each time it is taken in for this problem, the dealership keeps the vehicle for approximately one week, and there has been little communication regarding the status of the vehicle unless I contact the dealership myself. I am concerned that the underlying cause of the excessive oil consumption remains unresolved despite repeated testing and an attempted repair. I am concerned about continued oil loss, potential engine damage or engine failure, and the safety of operating the vehicle while the cause of the oil consumption remains unresolved. The vehicle is available for further inspection.

2022 VW Tiguan SE had PCV (positive crankshaft ventilation) also known as air-oil separator failed just outside of warranty creating a pressure cooker like effect in the engine which caused several seals and hoses, (such as the upper/front timing cover gaskets, rear main seal, and valve stem seals) to fail. The oil pan gasket was also destroyed. Although I was fortunate enough to be able to drive from my house around the corner to my local mechanic, this could have become a dangerous scenario considering most of my driving is done on busy freeways -- this could have caused severe oil slicking, sudden loss of power, and/or total engine failure. All of which could have resulted in a fatal, multi-vehicle accident. This appears to be a relatively common incident involving this particular year and model according to a New Jersey federal case ([XXX] et al v. Volkswagen [XXX] et al.), and several other complaints found. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? During a multipoint inspection that was earlier than advised due to multiple dashboard lights engaging, we were told that our car has an oil leak due from the timing covers and lower pan seal. They removed the oil separator and found value stem seals to be out towards the exhaust side creating an oil leak that stemmed from blown timing covers and the lower oil pan seal being the cause of the leak. The oil separator was noted as failed. This car has been brought in for every inspection and continued to have lights on post inspection that we were told regularly that they forgot just to turn off the lights but that the oil had been changed. In fact, our next oil change wasn't due until February 2027. How was your safety or the safety of others put at risk? Our safety has been put at risk driving a car with a substantial oil leak and faulty components that only seem found after we are 8,000 over the warranty. In searching the internet, this oil valve and leak situation is common in 2022 Tiguans enough so that there are multiple threads and articles about it. Has the problem been reproduced or confirmed by a dealer or independent service center? The dealer confirmed that this is an ongoing issue with these cars and that Volkwagen may be looking into doing a rebate for repairs. That doesn't fix the issue with the safety of the vehicle. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? We will be checking in with our insurance provider as well as an independent service center after dealing with Heritage Volkswagen Group due to our warranty. That warranty obviously provided us nothing for its cost or coverage. The lights were present and always brought in to be checked at the dealer we bought the car from. Again, we were always told that the lights didn't mean anything and they were left on after service accidentally

The vehicle logged code P0491 due to a clogged cylinder head internal port at 28,000 miles (26,000 at the time vehicle was inspected.) Volkswagen's official repair protocol requires a complete engine cylinder head replacement. The vehicle's onboard computer has disabled the factory-installed remote start system as a result of this engine fault.