2021 Volkswagen Tiguan

I’ve had my Volkswagen Tiguen since 2021 fresh off the lot. I have been the only owner of the car at about 30,000 miles my head gasket blew, causing the engine to go into default after weeks in the dealer. They replaced the head gasket and stitched it up, the head gasket blew again at this point I was still under warranty so they agreed to replace the engine. It drove fine after the engine was replaced this year 2025. I started to have a whole host of problems. It began to jerk and hesitate at acceleration. My engine light came on with continuous jerking upon acceleration for weeks until I started to lose power in my engine. I couldn’t go over 50 60 mph. I would always pull the car over power it off and power it back on just to see if it would change and it didn’t do much I had a local mechanic add oil to each tire also drain the engine, which had shards of metal in it. And basically stitch the car back together until we can figure out the bigger issues. It’s only been a day since the oil was added to each tire. I had a very violent jerk of the engine, which made it feel and sound like I blew a tire I got out to look at the tire and it was just fine. It was the backfire of the engine going into the exhaust that caused such the violent jerk. Happy that no one was on the road. If somebody was behind me it would’ve easily been an accident. Most of these dealerships know exactly what’s going on and have been avoiding the big conversation of what to do next they rather just replace and Band-Aid these things into the consumer just gives up. I have two small children and this is the only means of transportation. I’m fearful that I’ll be stuck with a car note for a car. I can’t drive.

Check engine light came on with excessive oil leaking from engine. Dealer inspected and diagnosed the PCV/Oil separator had failed, multiple valve stem seals had failed, and valve stem guides were worn causing excessive crankcase pressure. Dealer recommended cylinder head replacement. Vehicle has been at the dealer a month with the cylinder head on backorder and no timeline for resolution. Dealer indicated thousands of cylinder heads in the queue, with tens of units being distributed per month.

2021 Volkswagen Tiguan, Approximately 40,000 miles
Date of failure: Oct 12th, 2025
Component(s): Engine, Powertrain, Vehicle Speed Control, Throttle body Description of the problem:
My 2021 Volkswagen Tiguan experienced a complete engine failure despite having multiple prior service visits for engine-related issues while it was still under warranty. During the warranty period, I brought the vehicle to Grand Junction Volkswagen (Grand Junction, CO) several times for problems including: * Excessive oil consumption * “Check coolant” warning light turning on * EPC (Engine Power Control) mode activating and loss of power The dealership performed an oil consumption test and told me the results were “normal,” but they did not address the coolant light or EPC issues, stating these conditions were within normal limits. The same problems continued after each visit. At approximately 40,000 miles, the engine failed completely while driving, leaving the vehicle inoperable and creating a significant safety risk. The vehicle had to be towed. Volkswagen is now denying liability, claiming the vehicle is out of warranty, even though the same engine problems were documented repeatedly while it was still under warranty. I have opened a case with Volkswagen of America Customer Care (Case #07085098), but there has been no resolution so far. Safety concern:
This issue poses a serious safety hazard. The vehicle can lose power suddenly and stall while in motion, which could lead to a crash or leave occupants stranded in unsafe conditions.

The overhead console has come disconnected inside of the vehicle. I am seeing countless comments and posts online, both on Volkswagen site as well as other automotive sites, that also report this same issue for Tiguan autos from the 2020 through 2022 years. My car is a 2021 VW Tiguan. I am calling the Perrysburg Auto Mall VW Dealership located in Perrysburg, OH to request full service and that this should be covered under the extended warranty that I have seen is a part of this automobile. I wanted to make sure I reported this incident to this governing board.

Subject: Complaint Regarding 2021 Volkswagen Tiguan – Premature Engine Failure at 46,000 Miles To Whom It May Concern, I am filing a complaint regarding my 2021 Volkswagen Tiguan (VIN: [XXX] ) which suffered a catastrophic engine failure at only 46,000 miles. •I purchased the vehicle used in August 2023 through CarMax Auto Finance. •At the time of failure, the car had fewer than 50,000 miles and had been properly maintained. •Despite the extremely low mileage, Volkswagen has refused to cover the repair under warranty because the vehicle is slightly past the 4-year time limit. I believe this is unfair and unreasonable. A major component such as the engine should not fail this early, and a vehicle sold under these conditions is not fit for its ordinary purpose. Because of this premature failure, I was left with no functional car but still obligated to pay the outstanding loan balance. This has caused severe financial hardship and forced me to dispose of the vehicle below value. Requested Action: 1.That Volkswagen cover or reimburse the cost of the engine replacement, OR 2.Provide financial relief toward the remaining auto loan balance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased about 4 months ago with about 139,000 miles on it. The vehicle now has 142,000 miles and is experiencing excessive oil consumption—approximately 0.9 quarts per 600 miles. VW seems to be pushing this off and as I try to use my extended warranty I purchased when I got the car, AUL has asked for an engine tear down. VW knows about this issue, as it is internally a known issue for this model, yet they are unwilling to help. At time of purchase, this issue was not disclosed to me, as such had it been, I would not have chosen this car.

Upon starting my 2021 Volkswagen Tiguan, the vehicle immediately went into "limp" mode and the check engine light and EPC light came on. The vehicle would not drive over 18 mph. The car was towed to a close by Volkswagen dealership and checked for codes using a multipoint inspection. The report came back with a throttle body issue (Multipoint inspection report attached). The throttle body was replaced and the vehicle was taken for a 15 mile test drive. During the drive, the same problem occurred. After the drive, 34 codes were found in VWs report. I have also attached the report to this complaint. The technicians at the VW dealership didn't understand the problem, so they opened up communication with Volkswagen in Germany. The Volkswagen engineer advised the dealership to replace the wire harness. After the wire harness was replaced, the car has no more issue (although it has only been 5 days since), which cost $2314.54 in total. There is a class action lawsuit in the state of New Jersey (Case [XXX]) against Volkswagen Group of America that states "VW is aware of concerns involving faulty wire harnesses"... affecting 2019-2022 Volkswagen Atlas, Golf, Jetta, TIGUAN, and Taos. Thank God that this happened to my vehicle with the car was at rest and not traveling at a high rate of speed that could have been fatal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving approximately 55 MPH, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The contact stated that on three separate occasions, while the vehicle was parked, the contact observed oil on the ground underneath the vehicle. The vehicle was then taken to a dealer, and oil was discovered under the vehicle. The vehicle was diagnosed, and determined that the breather failure caused the crank case pressure to enter the system, causing the upper timing gasket and seal to be compromised and leak oil. The contact was informed that the oil separator timing cover, CAM magnets, and oil pan needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.