2021 Volkswagen Tiguan

Here is a quick description of the issue from our Volkswagon of Huntington service report. We have had this ongoing issue for a few months now. the check engine light will come on. We get it checked, we replace a sensor, and all is good for a day or week. Then we do it again, replacing a different sensor. Now the dealer is saying the oil separator is leaking and requires repairs starting at $8,400 and going up from there as they uncover more. We have always maintained the car properly. From research this appears to be a very known issue with this model car and should be reported and covered by VW. SCANNED VEHICLE AND FOUND FAULTS PRESENT FOR SECONDARY AIR. OBSERVED OIL SEPARATOR LEAKING CUASING UPPER TIMING COVER GASKETS TO BLOW OUT ALLOWING OIL TO ESCAPE. FOUND SECONDARY AIR PORTS IN CYLINDER HEAD CLOGGED TRIGGERING CHECK ENGINE LIGHT. ADVISED TO REPLACE OIL SEPARATOR,CAM SHAFT MAGNETS AND CYLINDER HEAD TO START. APPROX $ 8480.00 PLUS TAX

After oil changes (always maintained at dealerships) it would require a quart of oil with in 2 days. Random starts will blow smoke out the rear. random sluggish behavior. Dealership confirmed PCV valve is causing a buildup in engine pressure which caused a premature oil pan gasket leak. Without full teardown cannot know full extent of damages caused. (which spills out of the bottom and towards tires.....) dealership and fellow Tiguan owners have all reported the same issue! with a repair cost of $1,000-8,000+. same with alot of other years as well.. The date below that i will list is for when the problem was fully confirmed (89k miles) but has always been an issue told its fine ... really noticed it after (68k miles) when i purchased the vehicle. With how many people are dealing with this it is hard to understand how we dont see an open recall for them..... also dealer said pvc valves are on back order and have been. why should one replace with oem if they won't acknowledge its a faulty part?

Check Engine Light came on and got estimate from Pete Moore VW Dealer in Pensacola, Florida and was told the car needed extensive engine repair which included a new cylinder head part. So we waited to come get the car repaired on 3/5/2026 once we had saved up the money for it. We found out the cylinder head is on a Nationwide back order with NO estimated time to get it fixed properly. The technician who gave us the estimate back in September 2025 failed to mention that the cylinder head has been on a Nationwide back order during that time. I am not the only person dealing with this issue in the USA but feel VW has not provided a fix or estimate time to repair these cars properly causing a safety hazard. This time to wait for a part is unacceptable and feel our cars fall under the Lemon Law.

The contact owns a 2021 Volkswagen Tiguan. The contact stated that while his wife was driving slowly in traffic, several unknown warning lights illuminated orange, and the speedometer and RPM went to zero. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that minutes later, the vehicle returned to function as intended. The contact's wife stated that after several minutes, the lights and indicators returned to normal function. A short while later, the failure reoccurred, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle then returned to function as intended. The contact stated that on a separate occasion, the driver’s side door failed to open. While using the key fob, the doors failed to open. The contact's wife tested the door, and the only door that opened was the rear passenger’s side door. The contact's wife opened the driver’s side door manually. The vehicle then failed to start. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. Three hours later, when the contact arrived at the residence, the contact was able to start the vehicle, the doors opened as intended, and the contact was able to drive around the neighborhood. The manufacturer was not notified of the failure. The failure mileage was approximately 29,180.

My fuel system level indicator does not work properly when the tank is below 1/2 full, and the check engine light comes on. It does not correctly deplete, instead leaving me with no gas when it shows it still has gas available. This has left me stranded in various locations as my car runs out of gas, but doesn't show me that until it is completely empty. Most recently, it was on a very busy road in the middle of traffic. The gas gauge went from 1/2 full to empty while I was driving. Upon taking it to the dealer, they said to replace the 1 sensor, which is a very small, simple piece, they have to replace the entire fuel system, which is over $5000 in repairs. My car is only 4 years old and only out of warranty by 6 months. Further research shows this is a common issue with the make and model of my car. Many seem to happen under warranty, but with the age my car is now, many of these warranties will expire, leaving owners to have to pay to fix this outrageous, costly repair.

I am experiencing severe oil consumption and leakage with my 2021 Volkswagen Tiguan. The low oil level light began coming on weekly, and I have had to add oil nearly every week to keep the engine from running dry. Recently, I noticed oil leaking underneath the vehicle and immediately parked it. After parking, the vehicle began leaking oil excessively. The problem appears related to PCV system failure, which has caused multiple oil seals to rupture. After researching online, I found many other Tiguan owners reporting the same issues — including PCV valve failure, cracked oil pans, damaged valve seals, and crankshaft seal failures. My vehicle is no longer under the manufacturer’s warranty, and the dealership has not provided a fix. This defect presents a major safety concern because the engine can suddenly lose oil pressure or seize while driving, leading to sudden loss of power or control, which could cause an accident and potential injury. It appears Volkswagen has been aware of similar issues in other model years, but has not issued a recall or permanent repair for this problem. There is currently a class action lawsuit for the exact same issue for 2022 - 2023 Volkswagen Tiguan but doesn't currently include the 2021 Tiguan that I have. I am requesting that NHTSA investigate these widespread PCV and oil consumption failures in 2021 Volkswagen Tiguan vehicles.

The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the contact's dad who was following behind the vehicle noticed oil splashing onto the front windshield of his vehicle. The contact's dad then noticed while the contact was driving uphill, oil was splashing out of the oil pan. In addition, the contact's dad noticed smoke coming out of the exhaust. The check engine and PCV warning lights were illuminated. The vehicle was driven to the shoulder of the road. The vehicle was inspected, and the contact's dad noticed that the oil pan was completely empty. The vehicle was towed to an independent mechanic, where it was diagnosed with a cracked oil pan. The contact was informed that the oil pan, gasket, and filter needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving at an undisclosed speed, the contact's dad noticed the oil splashing underneath the vehicle again. The vehicle was driven to the shoulder of the road. The vehicle was inspected, and the contact noticed that oil was spilling out onto the road. The oil pan was empty. The vehicle was towed back to the independent mechanic. The independent mechanic contacted the dealer. The independent mechanic was informed that this was a known failure with the vehicle. The independent mechanic was informed that the failure was that the PCV valve had either failed or was clogged. The independent mechanic was informed that the failure normally occurred between 60,000-100,000 miles. The contact was informed that the failure might recur after the repair, however there was no recall for the failure. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.

The 2021 Tiguan, R-Line that I own now requires a new engine after roughly 70,000. The engine is no longer under warranty, According to the VW Dealership, this is what is wrong with the engine - Based on our observations and diagnostic review, we have determined that damage to the rotating assembly was caused by the presence of one or more metal objects entering the engine. This type of foreign-object intrusion can lead to significant internal impact, which is consistent with the damage we found during our assessment. Also, if you do a search on Reddit and other public forums, there are a lot of 2021 VW Tiguan's with similar issues.