IllustrationTHERE IS A RATTLE COMING FROM LOWER B PILLAR RATTLE COMING FROM DRIVER SEAT BELT RETRACTOR, OVERHEAD CONSOLE, WOOD TRIM ON BOTH FRONT DOORS, BOTH TWEETER SPEAKER GRILLS, BOTH REAR CUP HOLDERS, ALSO FOUND REAR DECK LID CLIPS NOT CLIPPED IN ALL THE WAY DRIVER REAR ACCESS PANEL RATTING ALONG WITH BOTH REAR STOP LIGHT ACCESS PANELS
2018 Volkswagen Tiguan
Owner reports · Recalls · Investigations
More warning signs than most Tiguan years
Owner complaints for the 2018 Volkswagen Tiguan are substantially higher than the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tiguan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1300–25K
1825–50K
250–75K
375–100K
1100–150K
0150K+
154 reports with mileage · 128 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports6 injury reports
What owners actually said
282 reportsTL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. WHILE DRIVING UNKNOWN SPEEDS ON ROUGH TERRAIN, THERE WAS AN ABNORMAL TICKING, RATTLING, AND KNOCKING NOISE EMERGING FROM THE FRAME. THE VEHICLE WAS TAKEN TO HAMILTON VOLKSWAGEN (2200 NJ-33 HAMILTON, NJ 08690, 844-858-4565) WHERE IT WAS DIAGNOSED THAT THE B PILLAR NEEDED TO BE REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. WHILE DRIVING UNKNOWN SPEEDS ON ROUGH TERRAIN, THERE WAS AN ABNORMAL TICKING, RATTLING, AND KNOCKING NOISE EMERGING FROM THE FRAME. THE VEHICLE WAS TAKEN TO HAMILTON VOLKSWAGEN (2200 NJ-33 HAMILTON, NJ 08690, 844-858-4565) WHERE IT WAS DIAGNOSED THAT THE B PILLAR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 181087619. THE FAILURE MILEAGE WAS 3,000. THE VIN WAS NOT AVAILABLE.
GUESS I'M HAVING THE SAME ISSUE A LOT OF OTHERS ARE HAVING. SITTING AT A RED LIGHT AND HIT THE GAS AND NOTHING HAPPENS. SMELLS LIKE GAS INSIDE THE CABIN. IT'S BEEN IN SERVICE AT THE DEALERSHIP FOR 15 DAYS AND THEY HAVE NO IDEA WHAT THE PROBLEM IS AND NO ETA ON THE FIX. I PURCHASED THE CAR IN DECEMBER 2017.
ENGINE ON THIS VEHICLE IS VERY SLOW TO RESPOND. WHEN I GIVE GAS, IT STRUGGLES TO START MOVING, FEELS LIKE IT IS CARRYING 10K LBS OF LOAD BEHIND. I PUSH GAS PEDDLE TO THE FLOOR AT A SIGNAL LIGHT TO GET AWAY FROM TRAFFIC. CAR WON'T RESPOND FOR ABOUT 1 OR 2 SECONDS, THEN STARTS TO MOVE, BUT VERY SLOW, CRAWLING, THEN STARTS TO S…
Read full complaint
ENGINE ON THIS VEHICLE IS VERY SLOW TO RESPOND. WHEN I GIVE GAS, IT STRUGGLES TO START MOVING, FEELS LIKE IT IS CARRYING 10K LBS OF LOAD BEHIND. I PUSH GAS PEDDLE TO THE FLOOR AT A SIGNAL LIGHT TO GET AWAY FROM TRAFFIC. CAR WON'T RESPOND FOR ABOUT 1 OR 2 SECONDS, THEN STARTS TO MOVE, BUT VERY SLOW, CRAWLING, THEN STARTS TO SPEED UP. TURBO LAG IS VERY BAD. I DON'T FEEL SAFE. THIS APPEARS TO BE A RECURRING ISSUE THAT IS BEING REPORTED FROM CUSTOMERS. TO BE FRANK, THE SIZE OF THE VEHICLE (LARGER THAN OTHER MODELS) DOES NOT SEEM TO MATCH THE ENGINE SIZE. NHTSA NEEDS TO INVESTIGATE FOR THE SAFETY OF OTHER DRIVERS, PARTICULARLY THOSE WHO SHARE THE SAME FEARS.
THERE WAS A LOUD, CONTINUOUS "CLICKING" NOISE COMING FROM THE DRIVER'S SIDE ALL ALONG WHERE THE ROOFLINE MEETS THE SIDE PANELS. THIS IS FROM A STRUCTURAL DEFECT DUE TO A LACK OF WELDING IN THOSE AREAS. WHILE IN FOR INSPECTION, I WAS LOANED THREE ADDITIONAL TIGUANS AND THEY ALL MADE THE CLICKING SOUND. IT'S A HEAT-SENSITIVE IS…
Read full complaint
THERE WAS A LOUD, CONTINUOUS "CLICKING" NOISE COMING FROM THE DRIVER'S SIDE ALL ALONG WHERE THE ROOFLINE MEETS THE SIDE PANELS. THIS IS FROM A STRUCTURAL DEFECT DUE TO A LACK OF WELDING IN THOSE AREAS. WHILE IN FOR INSPECTION, I WAS LOANED THREE ADDITIONAL TIGUANS AND THEY ALL MADE THE CLICKING SOUND. IT'S A HEAT-SENSITIVE ISSUE, OCCURRING WHEN THE TEMPERATURE REACHES AT LEAST 45 DEGREES AND THE METAL EXPANDS. AFTER FOUR ATTEMPTS TO REPAIR THE VEHICLE BY INSTALLING CLIPS, WEDGES, AND FELT PADDING, VOLKSWAGEN AGREED TO RE-PURCHASE THE VEHICLE FROM ME. THERE ARE NUMEROUS COMPLAINTS ONLINE ABOUT THIS ISSUE, WITH VW REPURCHASING SEVERAL VEHICLES. THE CLICKING IS A CONTINUOUS ISSUE WHENEVER THE VEHICLE IS IN MOTION.
THERE IS A RECALL FOR SUNROOF LIGHTING: FROM VW WEBSITE: HIGH HUMIDITY IN THE PANORAMIC SUNROOF AMBIENT LIGHTING BAR LED MODULE (CAUSED BY ENVIRONMENT OR BY LEAVING THE SUNROOF OPEN) COULD LEAD TO A LOCAL SHORT CIRCUIT. IF THIS HAPPENS, THERE IS A RISK OF A FIRE. SO, I BOUGHT HIGHER MODEL BECAUSE I WANTED THIS FEATURE, BUT N…
Read full complaint
THERE IS A RECALL FOR SUNROOF LIGHTING: FROM VW WEBSITE: HIGH HUMIDITY IN THE PANORAMIC SUNROOF AMBIENT LIGHTING BAR LED MODULE (CAUSED BY ENVIRONMENT OR BY LEAVING THE SUNROOF OPEN) COULD LEAD TO A LOCAL SHORT CIRCUIT. IF THIS HAPPENS, THERE IS A RISK OF A FIRE. SO, I BOUGHT HIGHER MODEL BECAUSE I WANTED THIS FEATURE, BUT NOW I CANNOT USE IT BECAUSE VW IS GOING TO DISCONNECT IT? AT THE END, PAY FOR FEATURE, BUT YOU CANNOT USE IT BECAUSE VW CAN'T FIGURE OUT WHICH FIRE TO PUT OUT.
THERE IS WEIRD TURBO/ENGINE SOUND COMING FROM ENGINE COMPARTMENT. WHEN ENGINE IS COLD, COLD START, YOU HEAR GRINDING TYPE OF NOISE. IT IS VERY LOUD. ONCE ENGINE IS DRIVEN FOR ABOUT 20 MINUTES, NOISE IS REDUCED, BUT STILL THERE. THE TRANSMISSION SHIFT HAS CLICKING NOISE. YOU DO NOT HEAR IT WHEN SEATING INSIDE THE VEHICLE…
Read full complaint
THERE IS WEIRD TURBO/ENGINE SOUND COMING FROM ENGINE COMPARTMENT. WHEN ENGINE IS COLD, COLD START, YOU HEAR GRINDING TYPE OF NOISE. IT IS VERY LOUD. ONCE ENGINE IS DRIVEN FOR ABOUT 20 MINUTES, NOISE IS REDUCED, BUT STILL THERE. THE TRANSMISSION SHIFT HAS CLICKING NOISE. YOU DO NOT HEAR IT WHEN SEATING INSIDE THE VEHICLE, BUT YOU CAN HEAR IT WHEN OUTSIDE AND SOMEONE ELSE IS SHIFTING. THE NOISE IS WHEN CAR GOES FROM EITHER DRIVE TO NEUTRAL, OR REVERSE TO NEUTRAL. IT'S A CLICKING NOISE, LIKE CHIME AND METAL BANGING MIXED TOGETHER.
ENGINE ON THIS VEHICLE IS VERY SLOW TO RESPOND. WHEN I GIVE GAS, IT STRUGGLES TO START MOVING, FEELS LIKE IT IS CARRYING 10K LBS OF LOAD BEHIND. THERE ARE ONLY TWO PASSENGERS, NOT PULLING ANYTHING. PUSH GAS PEDDLE TO THE FLOOR AT A SIGNAL LIGHT TO GET AWAY FROM TRAFFIC. CAR WON'T RESPONSE FOR ABOUT 1 SECOND, THEN STARTS TO…
Read full complaint
ENGINE ON THIS VEHICLE IS VERY SLOW TO RESPOND. WHEN I GIVE GAS, IT STRUGGLES TO START MOVING, FEELS LIKE IT IS CARRYING 10K LBS OF LOAD BEHIND. THERE ARE ONLY TWO PASSENGERS, NOT PULLING ANYTHING. PUSH GAS PEDDLE TO THE FLOOR AT A SIGNAL LIGHT TO GET AWAY FROM TRAFFIC. CAR WON'T RESPONSE FOR ABOUT 1 SECOND, THEN STARTS TO MOVE, BUT VERY SLOW, CRAWLING, THEN STARTS TO SPEED UP. TURBO LAG IS VERY BAD. NEED TO UPDATE SOFTWARE TO HELP ELIMINATE THIS. AUDI USES THE SAME ENGINE, BUT RESPONSE IS SO MUCH BETTER.
MY VEHICLE HAS 2 SERIOUS ISSUES. THE 1ST IS THE GAS/EXHAUST SMELL THAT IS INSIDE THE CABIN. THIS HAPPENS WHEN I AM DRIVING FOR MORE THAN A FEW HOURS CONSISTENTLY. THIS TENDS TO HAPPEN MORE WHEN THE OUTSIDE TEMPERATURES ARE OVER 108 DEGREES. THE 2ND ISSUE IS THE VEHICLE DOES NOT ALWAYS ACCELERATE FROM A COMPLETE STOP WHEN THE GAS…
Read full complaint
MY VEHICLE HAS 2 SERIOUS ISSUES. THE 1ST IS THE GAS/EXHAUST SMELL THAT IS INSIDE THE CABIN. THIS HAPPENS WHEN I AM DRIVING FOR MORE THAN A FEW HOURS CONSISTENTLY. THIS TENDS TO HAPPEN MORE WHEN THE OUTSIDE TEMPERATURES ARE OVER 108 DEGREES. THE 2ND ISSUE IS THE VEHICLE DOES NOT ALWAYS ACCELERATE FROM A COMPLETE STOP WHEN THE GAS PEDAL IS STEPPED ON. THE VEHICLE WILL ROLL INTO TRAFFIC A LITTLE BIT AND THEN 2-4 SECONDS PASS AND THEN IT WILL GO. IT IS VERY TOUCH AND GO AFTER IT DOES THIS AND IT TAKES ABOUT 10 MINUTES FOR IT TO FULLY BE "NORMAL" I HAVE HAD IT AT THE DEALERSHIP 2 TIMES FOR THESE ISSUES. THEY KEEP TELLING ME NOTHING IS WRONG WITH THE VEHICLE. I DO NOT FEEL SAFE IN THIS VEHICLE. BOTH ISSUES HAPPEN WITHOUT REASON. IT HAPPENS ON CITY STREETS AND HIGHWAYS. IT HAPPENS WITH OR WITHOUT THE "START/STOP" SYSTEM ACTIVATED. IT HAPPENS IN HOT AND COLD. I USE PREMIUM GAS LIKE THEY TOLD ME I HAD TO DO. I DO NOT TOP OFF WHEN I GET GAS. IT STILL CONTINUES TO HAPPEN.
THIS VEHICLE HAS A DRIVE ABILITY PROBLEM. THE CAR HAS A MAJOR HESITATION AND IS VERY DANGEROUS WHEN PULLING ONTO THE HIGHWAY. THE CAR ALMOST CUTS OUT BUT DOESN'T STALL AND FIND IT VERY DANGEROUS. THE DEALER TOLD ME THAT NOTHING IS WRONG WITH IT. ALSO, THERE WAS A RECALL ON MY AMBIENT LIGHTING ON MY SUNROOF. THERE COULD BE A LEAK…
Read full complaint
THIS VEHICLE HAS A DRIVE ABILITY PROBLEM. THE CAR HAS A MAJOR HESITATION AND IS VERY DANGEROUS WHEN PULLING ONTO THE HIGHWAY. THE CAR ALMOST CUTS OUT BUT DOESN'T STALL AND FIND IT VERY DANGEROUS. THE DEALER TOLD ME THAT NOTHING IS WRONG WITH IT. ALSO, THERE WAS A RECALL ON MY AMBIENT LIGHTING ON MY SUNROOF. THERE COULD BE A LEAK OR HUMIDITY COULD AFFECT THE WIRING AND COULD CAUSE A FIRE. THERE FIX IS TO DISCONNECT IT. I HAVE NO SUNROOF LIGHTING. I SHOULD GET A REFUND FOR SOMETHING THEY TOOK AWAY.
Official recalls
1426V590000 · Steering
Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
22V226000 · Structure:body
Apr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Consequence & remedy
Consequence: An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
21V732000 · Structure:body:roof And Pillars
Sep 23, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Consequence & remedy
Consequence: The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy: Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
20V724000 · Seat Belts:front:webbing
Nov 20, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Consequence & remedy
Consequence: A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
19V679000 · Unknown Or Other
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
19V188000 · Suspension:rear:springs:coil Springs
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
18V824000 · Electrical System: Instrument Cluster/panel
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
18V467000 · Visibility:sun/moon Roof Assembly
Jul 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
18V375000 · Air Bags:frontal:passenger Side:inflator Module
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
18V324000 · Suspension:front:control Arm:lower Ball Joint
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Consequence & remedy
Consequence: A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
18V262000 · Suspension:rear:shock Absorber
Apr 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Consequence & remedy
Consequence: If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
18V159000 · Engine
Mar 8, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Consequence & remedy
Consequence: If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
18V102000 · Air Bags:frontal
Feb 9, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
17V662000 · Exterior Lighting:tail Lights
Oct 18, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18005 · Seat Belt Webbing Failure
Opened Jul 3, 2018 · Closed Feb 27, 2023
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Additional source detail variants (3)
Seat Belts:front
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
PE18001 · Seat Belt Webbing Failure
Opened Jan 10, 2018 · Closed Jul 3, 2018
Status: closed (inferred from source dates) · Seat Belts:front:webbing
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.