NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
39 reportsClear category filterMileage unknown · Mar 24, 2026
Air BagsElectrical SystemStructure
My 2018 Volkswagen Tiguan experienced a failure of the airbag control module caused by water intrusion through the HVAC access area and failed seam seal tape at the cowl support. The dealership confirmed that water leaked through a factory seam, accumulated at the airbag module, and caused the module to fail. The airbag warning …
Read full complaint
My 2018 Volkswagen Tiguan experienced a failure of the airbag control module caused by water intrusion through the HVAC access area and failed seam seal tape at the cowl support. The dealership confirmed that water leaked through a factory seam, accumulated at the airbag module, and caused the module to fail. The airbag warning light is illuminated, and the system is inoperable. This failure matches the same defect pattern covered under Volkswagen’s recall campaigns for the Atlas and Atlas Cross Sport (water intrusion leading to airbag control module failure), but my VIN is not included. The root cause and safety implications are identical: water entering through a body seam/HVAC area and compromising the airbag system. This is a safety‑critical issue that disables the airbags and creates a risk of injury in a crash. I am requesting NHTSA review this defect for potential recall expansion. Dealership Findings: • Water present at airbag control module • Water leaking through HVAC access hole • Failed seam seal tape at cowl support • Water accumulation damaging the airbag module • Cowl trim cracked and repaired • Recommended replacement of airbag control module and seam sealing tape • Estimated repair cost: $1,377 + tax Safety Concern: Airbag system is disabled due to water intrusion from a factory seam. This creates a risk of injury or death in the event of a collision.
NHTSA ODI #11726578
Mileage unknown · Dec 15, 2025
Fuel/propulsion SystemStructure
1)My sunroof/window is leaking. This has caused internal damage. My car had 2-2.5 inches of water that has damaged by carpeting and pads the 60E5 was performed. ~72,500 miles 2018 Tiguan. 2) dealer service has advised of service:REPLACE SET OF (4) FUEL INJECTOR O-RINGS DUE TO FUEL LEAK AT FUEL RAIL-INCLUDE INTAKE MANIFOLD GAKET …
Read full complaint
1)My sunroof/window is leaking. This has caused internal damage. My car had 2-2.5 inches of water that has damaged by carpeting and pads the 60E5 was performed. ~72,500 miles 2018 Tiguan. 2) dealer service has advised of service:REPLACE SET OF (4) FUEL INJECTOR O-RINGS DUE TO FUEL LEAK AT FUEL RAIL-INCLUDE INTAKE MANIFOLD GAKET AND THROTTLE BODY GASKET.
NHTSA ODI #11705198
Mileage unknown · Aug 17, 2023
Structure
There is an excessive amount of water leaking into the passenger compartment and also the cargo area The result is that considerable mold growing on the carpeting of the entire car The dealer has ordered repair parts but the parts are on back order leaving me to drive the vehicle while it has mold I have been advised if I remove…
Read full complaint
There is an excessive amount of water leaking into the passenger compartment and also the cargo area The result is that considerable mold growing on the carpeting of the entire car The dealer has ordered repair parts but the parts are on back order leaving me to drive the vehicle while it has mold I have been advised if I remove the molded carpeting I will invalidate the warranty Very dangerous as occupying this vehicle results in inhaling mold
NHTSA ODI #11539153
Mileage unknown · Oct 20, 2022
Electrical SystemStructure
The front passenger door locking system does not function properly. The door intermittently is unable to be unlocked or opened from the outside and must manually be opened from the inside. The door also intermittently doesn't lock. This is a safety concern for thieves. If in immediate danger, ie. accident, no one is able to open…
Read full complaint
The front passenger door locking system does not function properly. The door intermittently is unable to be unlocked or opened from the outside and must manually be opened from the inside. The door also intermittently doesn't lock. This is a safety concern for thieves. If in immediate danger, ie. accident, no one is able to open the passenger door to access the person. No indication lights appear on the vehicle.
NHTSA ODI #11490146
Mileage unknown · Aug 2, 2021
Structure
Driving down the Highway with my kids in the car and the sunroof shattered. No was around driving near me, nothing was hit, no other damage on my vehicle. the sunroof just exploded with my 4 children in the car. Now Im 1,000 miles away from home.
NHTSA ODI #11427528
75,390 miles · Mar 2, 2020
Seat BeltsStructure
LEAKING FROM PANORAMIC MOONROOF,WATER COMING FROM PIPE DRAINE TUBES AND DRIPPING INTO BACK INTO SEATBELTS COMPARTMENT THAT FREEZE SEATBELTS DURING COLD WEATHER AND I CAN NOT PULL SEATBELTS OUT TO BUCKLE UP. ALSO AT THE SAME TIME WATER COMING INTO TRUNK MAKING AREA WHERE WIRING SISTEM GOING THROUGH ALL WET .VW DEALER FIXED IT ONC…
Read full complaint
LEAKING FROM PANORAMIC MOONROOF,WATER COMING FROM PIPE DRAINE TUBES AND DRIPPING INTO BACK INTO SEATBELTS COMPARTMENT THAT FREEZE SEATBELTS DURING COLD WEATHER AND I CAN NOT PULL SEATBELTS OUT TO BUCKLE UP. ALSO AT THE SAME TIME WATER COMING INTO TRUNK MAKING AREA WHERE WIRING SISTEM GOING THROUGH ALL WET .VW DEALER FIXED IT ONCE BY AND IT HAPPEND SECOND TIME AGAIN.MY CAR IS IN THE SHOP NOW AND THIS PROBLEM WILL JUST KEEP GOING ON IN MY OPINION FOREVER UNTIL CAR EVENTUALLY DIE BECAUSE OF WATER GOING ONTO WIRING .
NHTSA ODI #11315731
30,000 miles · Jan 29, 2020
Structure
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH IN INCLEMENT WEATHER, THE FRONTAL COLLISION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO (VOLKSWAGEN OF DOWNTOWN CHICAGO, LOCATED AT 1111 N. CLARK ST, CHICAGO, IL 60610), TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH IN INCLEMENT WEATHER, THE FRONTAL COLLISION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO (VOLKSWAGEN OF DOWNTOWN CHICAGO, LOCATED AT 1111 N. CLARK ST, CHICAGO, IL 60610), TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #11302747
Mileage unknown · Aug 20, 2019
Structure
THE NEWEST GENERATION VW TIGUAN HAS A B PILLAR ISSUE WHERE THE RIVETS WHERE THE B PILLAR IS WELDED RATTLES. I AM CONCERNED OF THE OVER ALL STRUCTURE OF THE VEHICLE AND HOW IT WOULD WITHSTAND A CAR ACCIDENT.
NHTSA ODI #11245160
Mileage unknown · May 3, 2019
Structure
BOUGHT THE VEHICLE NEW IN EARLY APRIL 2019, AFTER A COUPLE HUNDRED MILES I NOTICED A SCREECHING/RATTLING NOISE COMING FROM BOTH THE DRIVER'S AND PASSENGER'S SIDE B PILLARS. I TOOK IT BACK THE DEALER FOR A RESOLUTION TO THE ISSUE. THEY HEARD THE NOISE AND SAID THERE IS FIX FOR THE PROBLEM THAT INVOLVES GUTTING THE ENTIRE INTERIOR…
Read full complaint
BOUGHT THE VEHICLE NEW IN EARLY APRIL 2019, AFTER A COUPLE HUNDRED MILES I NOTICED A SCREECHING/RATTLING NOISE COMING FROM BOTH THE DRIVER'S AND PASSENGER'S SIDE B PILLARS. I TOOK IT BACK THE DEALER FOR A RESOLUTION TO THE ISSUE. THEY HEARD THE NOISE AND SAID THERE IS FIX FOR THE PROBLEM THAT INVOLVES GUTTING THE ENTIRE INTERIOR AND WELDING BAD OR MISSING WELDS ON THE STRUCTURE UP NEAR THE ROOF. I HAVE TWO PROBLEMS WITH THEIR SOLUTION. FIRST, THIS IS A SAFETY ISSUE. WHO KNOWS IF THE ROOF WOULD HOLD UP DURING A ROLLOVER ACCIDENT CONSIDERING THE DEALERSHIP MECHANICS ARE NOT QUALIFIED WELDERS FOR SUCH A CRITICAL APPLICATION. SECOND, THE NOISE IS VERY DISTRACTING WHILE DRIVING. SO I HAVE DECIDE WHETHER OR NOT TO LET THEM TEAR THE ENTIRE INTERIOR OUT OF MY VEHICLE AND LET THEM MAKE SHODDY REPAIR ON MY BRAND NEW VEHICLE OR TAKE A CHANCE ON MY AND MY PASSENGER'S SAFETY. SHAME ON VOLKSWAGEN. THESE VEHICLES SHOULD BE BOUGHT OR REPLACED WITH A 2019 WHICH DOESN'T SEEM TO HAVE THE PROBLEM.
NHTSA ODI #11205427
10 miles · Dec 7, 2018
Fuel/propulsion SystemStructure
I PURCHASED MY TIGUAN SE 4MOTION IN JULY 2018 AND SINCE I HAVE OWNED THE VEHICLE I HAVE HAD ISSUES WITH THE ACCELERATION AND NOISE COMING FROM THE PASSENGER SIDE B PILLAR. THE ACCELERATION FEELS LIKE A TURBO LAG FROM THE START WHERE THE GAS PEDAL IS PRESSED BUT THE VEHICLE HESITATES TO RESPOND CAUSING A SMALL "STALL". THIS HAPPE…
Read full complaint
I PURCHASED MY TIGUAN SE 4MOTION IN JULY 2018 AND SINCE I HAVE OWNED THE VEHICLE I HAVE HAD ISSUES WITH THE ACCELERATION AND NOISE COMING FROM THE PASSENGER SIDE B PILLAR. THE ACCELERATION FEELS LIKE A TURBO LAG FROM THE START WHERE THE GAS PEDAL IS PRESSED BUT THE VEHICLE HESITATES TO RESPOND CAUSING A SMALL "STALL". THIS HAPPENS IN BOTH DRIVE AND SPORT MODES. WHEN ACCELERATING UP-HILL THE VEHICLE HAS ISSUES WITH FINDING THE PROPER GEAR AND CONSTANTLY SEARCHES FOR A GEAR TO SETTLE ON. THE B PILLAR NOISE SOUNDS LIKE LOUD CLICKING WHEN GOING OVER BUMPS AND RUTS IN THE ROAD AND EVEN MAKES A NOISE WHEN OPENING THE DOOR TO ITS FULLEST.
NHTSA ODI #11156726
Official recalls
14Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Apr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Consequence & remedy
Consequence: An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Sep 23, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Consequence & remedy
Consequence: The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy: Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
Nov 20, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Consequence & remedy
Consequence: A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Jul 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Consequence & remedy
Consequence: A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
Apr 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Consequence & remedy
Consequence: If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
Mar 8, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Consequence & remedy
Consequence: If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
Feb 9, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
Oct 18, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18005 · Seat Belt Webbing Failure
Opened Jul 3, 2018 · Closed Feb 27, 2023
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Additional source detail variants (3)
Seat Belts:front
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
PE18001 · Seat Belt Webbing Failure
Opened Jan 10, 2018 · Closed Jul 3, 2018
Status: closed (inferred from source dates) · Seat Belts:front:webbing
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.
Illustration