NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
21 reportsClear category filterMileage unknown · Jan 15, 2024
EnginePower TrainVehicle Speed Control
On multiple occasions, while driving on the highway, subject vehicle displayed check engine light and EPC light at random intervals and an alarm saying exceeded 4000 came on. RPM's were not over 4000. Speed and acceleration severely limited making it dangerous to pull over on the highway in traffic. Had to pull car over and rest…
Read full complaint
On multiple occasions, while driving on the highway, subject vehicle displayed check engine light and EPC light at random intervals and an alarm saying exceeded 4000 came on. RPM's were not over 4000. Speed and acceleration severely limited making it dangerous to pull over on the highway in traffic. Had to pull car over and restart engine. This has happened numerous times. Also experienced shaking and skipping or missing of transmission. The car has also had the engine stall or stop when at red light or stopped forcing restart of engine.
NHTSA ODI #11565620
Mileage unknown · Jul 5, 2022
EnginePower TrainVehicle Speed Control
The first time this problem occurred was in April right after a routine maintenance check. The car was idling in a parking lot when the engine started to vibrate and a warning was displayed that said "Max Engine Speed 4000 RPM". The car was turned off and then back on. The warning did show up on the display, but the "check engin…
Read full complaint
The first time this problem occurred was in April right after a routine maintenance check. The car was idling in a parking lot when the engine started to vibrate and a warning was displayed that said "Max Engine Speed 4000 RPM". The car was turned off and then back on. The warning did show up on the display, but the "check engine" light was lit. The car was driven back home, and after that drive the check engine light was not lit anymore. To be safe the car was taken to the dealer. The dealer was not able to replicate the issue. Later, in July, the max engine speed and EPC warnings were displayed on the screen in the middle of a trip. At this time there was also a loss of acceleration power. The driver pulled over, stopped the car, and then restarted it. When the car restarted the warning lights were no longer on so the driver completed the trip. In the manual it says that the car can still be operated if the EPC warning light is on, but that it should be taken to a dealer. This led the driver to believe that it was safe to complete the trip and take the car to their home dealership after the holiday. The following day, the EPC warning light and the max engine speed warning both appeared in the middle of a drive. The driver was driving up a hill on a backroad with no possible pull off. The driver had to stop the car in the middle of a road directly after a blind turn. The driver restarted the car and was able to drive about 10 yards before the warning came on again and the engine cut out. The driver repeated turning the car off and then back on multiple times to be able to safely get the car up the hill and to an area where a pull-off was available. Luckily, no other cars were coming at the time the car was stalled. It was a very unsafe location! The car is currently in the process of being towed to the dealer to be worked on. This seems like a very serious safety concern that is affecting other Tiguan owners too.
NHTSA ODI #11472324
Mileage unknown · May 28, 2022
EnginePower TrainVehicle Speed Control
Car has multiple malfunctions. Has had noisy valvetrain, lack of power upon acceleration, has sputtered with a load on engine especially uphill. Car shut off completely while at 60 mph and nearly caused a catastrophic collision with my whole family in the car. Car presents substantial safety risk. Multiple codes/warnings have fl…
Read full complaint
Car has multiple malfunctions. Has had noisy valvetrain, lack of power upon acceleration, has sputtered with a load on engine especially uphill. Car shut off completely while at 60 mph and nearly caused a catastrophic collision with my whole family in the car. Car presents substantial safety risk. Multiple codes/warnings have flashed up on the display screen(Evap,Trans,fuel inj,etc). Transmission went into "emergency mode" after being started up today, then went away after restarted. Car has been to dealership but issues were not properly addressed/ignored. VW of America is well aware of issues with these cars but ignores the consumers needs and puts consumers at great safety risk by doing so. This vehicle has both engine and transmission issues as well as odd electrical anomalies.
NHTSA ODI #11466553
Mileage unknown · Mar 22, 2022
Electrical SystemFuel/propulsion SystemVehicle Speed Control
At 48k miles, fuel efficiency began to significantly drop. At next start up, engine would not turn over and EPC light came on. I waited 30 minutes, unlocked the steering wheel and was able to start the vehicle and EPC light turned off. I took it into Volkswagen dealership to have it looked over and they could not duplicate the i…
Read full complaint
At 48k miles, fuel efficiency began to significantly drop. At next start up, engine would not turn over and EPC light came on. I waited 30 minutes, unlocked the steering wheel and was able to start the vehicle and EPC light turned off. I took it into Volkswagen dealership to have it looked over and they could not duplicate the issue nor find cause for lower fuel efficiency. The issue with fuel persisted intermittently. Then at 57k, while driving long distance, I noticed what seemed like misfiring when accelerating above 65 mph. There were no noises, no warning lights, and fuel efficiency seemed about the same. I continued driving and about 6 hours into my drive, EPC light came on, RPM's shot up to 4,000 and car began violently shaking while losing significant power and dropped down to 30 mph. I was in the left lane when it occurred and had to quickly move over to the right lane. The car then could not exceed 40 mph with the pedal held to the floor. I turned on my hazards while I continued driving an additional 30 miles to the nearest Volkswagen dealership. Because of how heavy the traffic was and the high speeds of the travelers, it put myself and my passengers at risk from not being able to accelerate, along with the other drivers having to either brake hard or quickly change lanes to avoid my car. At the Volkswagen dealership, diagnosis found code p0204 cylinder 4 injector. They confirmed 4th cylinder misfiring and replaced the fuel injector harness. Since that repair, my car has been shaking at idol, when initially taking off, and if I turn of the start/stop function.
NHTSA ODI #11457881
Mileage unknown · Oct 12, 2021
EngineFuel/propulsion SystemVehicle Speed Control
Like many other people who have complained, the same EPC engine light turning on after the engine stalls while driving. This has happened multiple times while driving on the highway while going 65mph+. The max speed 4000 rpm message comes on the dashboard. The car does not accelerate and pulling over is necessary in order to shu…
Read full complaint
Like many other people who have complained, the same EPC engine light turning on after the engine stalls while driving. This has happened multiple times while driving on the highway while going 65mph+. The max speed 4000 rpm message comes on the dashboard. The car does not accelerate and pulling over is necessary in order to shut off the car and restart the engine. This is incredibly dangerous and the car’s speed cannot be controlled.
NHTSA ODI #11436515
41,000 miles · Oct 29, 2020
Vehicle Speed Control
THE CAR DOES NOT ACCELERATE FROM A STOP ESPECIALLY ON HOT DAYS AFTER BEING IN STOP AND GO TRAFFIC. I STEP ON THE GAS AND LITERALLY NOTHING HAPPENS. THE ENGINE DOESN'T REV AND THE CAR DOES NOT ADVANCE. I CAN PUSH THE GAS PEDAL MULTIPLE TIMES BEFORE IT FINALLY ACCELERATES AND THEN IT DOES IT IN AN OUT OF CONTROL MANNER. I HAVE…
Read full complaint
THE CAR DOES NOT ACCELERATE FROM A STOP ESPECIALLY ON HOT DAYS AFTER BEING IN STOP AND GO TRAFFIC. I STEP ON THE GAS AND LITERALLY NOTHING HAPPENS. THE ENGINE DOESN'T REV AND THE CAR DOES NOT ADVANCE. I CAN PUSH THE GAS PEDAL MULTIPLE TIMES BEFORE IT FINALLY ACCELERATES AND THEN IT DOES IT IN AN OUT OF CONTROL MANNER. I HAVE HAD TO SIT THROUGH A FULL CYCLE OF A LIGHT BEFORE IT HAS STARTED. I HAVE BROUGHT IT TO A DEALERSHIP MULTIPLE TIMES WITH THIS COMPLAINT, BUT EVERY TIME THEY ARE UNABLE TO GET IT TO FAIL. I BROUGHT IT IN FOR A RECALL AND THE PROBLEM WAS MADE WORSE AND NOT BETTER. THE CAR IS NOT SAFE. THE ISSUE BEGAN WITHIN 6 MONTHS OF PURCHASE AND WHILE IT ISN'T CONSTANT, IT HAS BEEN A REPEATED PROBLEM FOR THE PAST 2 YEARS.
NHTSA ODI #11366975
Mileage unknown · Mar 19, 2020
EnginePower TrainVehicle Speed Control
MY CAR HESITATES WHEN ACCELERATING AT A COMPLETE STOP. I PRESS THE ACCELERATOR TO PULL INTO TRAFFIC AND IT SEEMS THE CAR JUST DOESN'T WANT TO GO! THIS MAKES IT VERY DANGEROUS TO DRIVE PERIOD. IT TAKES A FEW SECONDS FOR THE CAR TO 'WAKE UP' AND FINALLY ACCELERATE.
NHTSA ODI #11318746
Mileage unknown · Nov 27, 2019
EngineVehicle Speed Control
IT TAKES A SCARY AMOUNT OF TIME FOR THE CAR TO SPEED UP WHEN ACCELERATING. THE RPM MODULE SHOWS THE ACCELERATION BUT THE VEHICLE DOESN'T ACTUALLY SPEED UP TO MATCH IT. THIS IS A SAFETY ISSUE ESPECIALLY WHEN MERGING ON TO THE FREEWAY. AN ACCIDENT IS BOUND TO HAPPEN AS I AM NOT ABLE TO CONTROL THE SPEED OF THE ON COMING CARS AND A…
Read full complaint
IT TAKES A SCARY AMOUNT OF TIME FOR THE CAR TO SPEED UP WHEN ACCELERATING. THE RPM MODULE SHOWS THE ACCELERATION BUT THE VEHICLE DOESN'T ACTUALLY SPEED UP TO MATCH IT. THIS IS A SAFETY ISSUE ESPECIALLY WHEN MERGING ON TO THE FREEWAY. AN ACCIDENT IS BOUND TO HAPPEN AS I AM NOT ABLE TO CONTROL THE SPEED OF THE ON COMING CARS AND AM UNABLE TO GET MY CAR UP TO SPEED TO MATCH THE OTHERS. ALSO, THE CAR RANDOMLY SHUTS DOWN WHEN STOPPED, A MESSAGE SAYING PLEASE START ENGINE MANUALLY POPS UP. THIS IS ALSO A SAFETY CONCERN AND IS BOUND TO CAUSE AN ACCIDENT AS IT HAPPENS A FEW TIMES A MONTH. A FEW MONTHS AGO MY CAR TURNED OFF WHEN I STOPPED AT THE RED LIGHT, A CAR WAS EXITING THE FREEWAY AS THE LIGHT HAD TURNED GREEN SO THEY KEPT THEIR HIGH SPEED, I QUICKLY TURNED MY HAZARD LIGHTS ON AND THE CAR HAD TO SWERVE TO THE RIGHT LANE TO AVOID REAR ENDING ME.
NHTSA ODI #11282651
17,608 miles · Nov 4, 2019
EngineFuel/propulsion SystemVehicle Speed Control
THE CAR GETS FILLED WITH STRONG ODOR OF GASOLINE INSIDE THE CABIN AND I WAS LOOSING GAS AT A RAPID RATE IN ADDITION THE CAR WAS LOOSING SPEED. THERE IS ALSO THE PROBLEM WITH THE STO-START SYSTEM, ONCE THE CAR WAS AT A STOP, THE CAR WOULD NOT TURN OVER AND START AGAIN. IT WOULD GET STUCKTRYING TO TURN ON AND AT THE SAME TIME I WA…
Read full complaint
THE CAR GETS FILLED WITH STRONG ODOR OF GASOLINE INSIDE THE CABIN AND I WAS LOOSING GAS AT A RAPID RATE IN ADDITION THE CAR WAS LOOSING SPEED. THERE IS ALSO THE PROBLEM WITH THE STO-START SYSTEM, ONCE THE CAR WAS AT A STOP, THE CAR WOULD NOT TURN OVER AND START AGAIN. IT WOULD GET STUCKTRYING TO TURN ON AND AT THE SAME TIME I WAS LOOSING GASOLINE. I HAD TO REMOVE ALL PASSENGERS FROM THE VEHICLE INCLUDING MY ONE MONTH GRAND SON DUE TO THE STRONG ODOR OF GASOLINE. THIS INCIDENTS OCCURED SEVERAL TIMES DURING THE WEEKEND OF NOVEMBER 1 THROUGH NOVEMBER 4TH WHEN I DROPPED OFF THE VEHICLE AT THE DEALERSHIP.
NHTSA ODI #11278000
Mileage unknown · Oct 3, 2019
EnginePower TrainVehicle Speed Control
CARS RESPONSE TO DRIVER ACCELERATOR INPUTS IS HESITANT AND ERRATIC. CAR MOTION IS UNPREDICTABLY WHEN ACCELERATING FROM STAND STILL. THE PERFORMANCE IS NOT PREDICTABLE AND VERY WITHOUT APPARENT EXTERNAL ENVIRONMENTAL FACTORS. UNPREDICTABLE PERFORMANCE ENDANGERS CAR OCCUPANTS WHILE ENTERING TRAFFIC. THE BEHAVIOR HAS BEEN DETERMI…
Read full complaint
CARS RESPONSE TO DRIVER ACCELERATOR INPUTS IS HESITANT AND ERRATIC. CAR MOTION IS UNPREDICTABLY WHEN ACCELERATING FROM STAND STILL. THE PERFORMANCE IS NOT PREDICTABLE AND VERY WITHOUT APPARENT EXTERNAL ENVIRONMENTAL FACTORS. UNPREDICTABLE PERFORMANCE ENDANGERS CAR OCCUPANTS WHILE ENTERING TRAFFIC. THE BEHAVIOR HAS BEEN DETERMINED BY DEALER AS NORMAL AGAINST OTHER 2018 MODELS BUT IS DIFFERENT AGAINST 2019. VW US HAS NOT RETURNED INQUIRY REQUESTS.
NHTSA ODI #11265828
Official recalls
14Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Apr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Consequence & remedy
Consequence: An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Sep 23, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Consequence & remedy
Consequence: The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy: Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
Nov 20, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Consequence & remedy
Consequence: A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Jul 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Consequence & remedy
Consequence: A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
Apr 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Consequence & remedy
Consequence: If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
Mar 8, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Consequence & remedy
Consequence: If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
Feb 9, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
Oct 18, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18005 · Seat Belt Webbing Failure
Opened Jul 3, 2018 · Closed Feb 27, 2023
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Additional source detail variants (3)
Seat Belts:front
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
PE18001 · Seat Belt Webbing Failure
Opened Jan 10, 2018 · Closed Jul 3, 2018
Status: closed (inferred from source dates) · Seat Belts:front:webbing
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.
Illustration