NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
50 reportsClear category filterMileage unknown · Jun 6, 2026
Back Over PreventionLane DepartureUnknown Or Other
A few weeks ago i noticed that a car passed me and the little blind spot alert light didn't light up. when i arrived at my destination I did some scanning through the menus and i discovered that the blind spot (side assist) was not on, but when i attempted to turn it on, the car said "function not available". After some invest…
Read full complaint
A few weeks ago i noticed that a car passed me and the little blind spot alert light didn't light up. when i arrived at my destination I did some scanning through the menus and i discovered that the blind spot (side assist) was not on, but when i attempted to turn it on, the car said "function not available". After some investigation (using a odbeleven scanner) i discovered that the blind spot assist functionality has a fault with "no communication". This system, upon failure, give NO indication anywhere, plus this also means my rear back up alert ( a kid running behind my car, for example, which would normally cause a huge alert, nothing happens). I also learned that there is a technical bulletin : [XXX] related to this. This should be a recall, its dangerous to have no indication that a safety feature system like this is completely nonfunctional (without an ODBeleven read). a light on the dash should alert me, or a message on the screen. this is just plain dangerous! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11742512
Mileage unknown · Feb 26, 2026
Unknown Or Other
I just bought this 2018 Volkswagen Tiguan Ford, cylinder All wheel Drive in the Angel light came on and it says recalls will never fixed. I would like to know if you can help me and fix this problems. My name is [XXX] , Lodi New Jersey. My phone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F…
Read full complaint
I just bought this 2018 Volkswagen Tiguan Ford, cylinder All wheel Drive in the Angel light came on and it says recalls will never fixed. I would like to know if you can help me and fix this problems. My name is [XXX] , Lodi New Jersey. My phone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11720678
Mileage unknown · Jan 12, 2026
Unknown Or Other
On [XXX] I discovered water in my car. ~2.5 inch front passenger and back driver and passenger side. Condensation on the sunroof. My sunroof was not opened/completely shut. I called VW service was advised my car was not covered under the class action or warranty and advised to report to my insurance. I did not want to report and…
Read full complaint
On [XXX] I discovered water in my car. ~2.5 inch front passenger and back driver and passenger side. Condensation on the sunroof. My sunroof was not opened/completely shut. I called VW service was advised my car was not covered under the class action or warranty and advised to report to my insurance. I did not want to report and risk my insurance rate increasing. I have never filed a claim in the 20+ years of having the car. After researching and taking my call for repairs I discovered that my vehicle should be covered on the extended warranty IF the recall 60E5/60E2 was repaired. I am in Ohio where the damage was discovered my regular service dealer is in Illinois. 1)The service dealer in Illinois did complete the 60E5/60E2 recall. 2) the extend warranty % coverage should cover my car however I was told my VIN was not apart of the class action although the recall was performed an no record in the system with VW and if it were I would not be covered because I am 5 months out of the in service date. 3) the damage is ~ 3000.00 and increasing because now the sunroof switch doesn’t work and the screen is damaged from water. There is mold in my car which is a health hazard. I have exhausted trying to navigate through this issue! If my car was not apart of the class action it should have been. The insurance minus my deductible does not cover the cost of repairs. I have been without a call since this incident. This is a health hazard consumer driving hazard and should be investigated ASAP. I have attached the initial estimate which will be supplementally adjusted, the service 60E5 document . Please advise if this should be reported to the attorney general office and or what my next course of action should be. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11710452
Mileage unknown · Jun 26, 2025
Fuel/propulsion SystemUnknown Or Other
coolant burst and started leaking. Unable to drive car. radiator problem May be related to bad water pump. I see there was a recall.
NHTSA ODI #11669508
Mileage unknown · Jun 10, 2025
SuspensionUnknown Or OtherWheels
I originally started out at World Kia in Matteson, where I was approved for a newer vehicle. But then they suddenly changed their minds and tried to put me in an older car instead. That rubbed me the wrong way, so I went to their Joliet location hoping for better service. Boy, was I wrong. Even though they had already run my c…
Read full complaint
I originally started out at World Kia in Matteson, where I was approved for a newer vehicle. But then they suddenly changed their minds and tried to put me in an older car instead. That rubbed me the wrong way, so I went to their Joliet location hoping for better service. Boy, was I wrong. Even though they had already run my credit in Matteson, they reran it again in Joliet, which made no sense and damaged my credit even more. I really needed a car at the time, so I felt pressured and couldn’t walk away. After I bought the car, it broke down shortly after, and I was never given any paperwork about its condition or inspection. They sold it to me “as-is,” but I later found out that under Illinois law, used cars must be safe and reliable for at least 15 days or 500 miles, even when sold “as-is.” My car didn’t meet that standard at all. The car has suspension issues which is very dangerous. The mechanic stated to not drive the car at all it's a safety hazard and I could cause a major accident. There is no recall on my vin#, but several other owners have had the same issues based of the information on the website. I just want some kind of resolution. I'm still responsible for the car, which is so unfair. This has caused so much stress that I have no clue what to do. please help. Best, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11666160
Mileage unknown · Apr 28, 2025
Unknown Or Other
Our car frequently (several times per month) suddenly stops when it is coming to a STOP when the Stop/Start feature is trying to engage. We took it to the dealer, and VW replaced the starter. That DID NOT fix the problem. When the car stops, frequently at or when approaching intersections, the display says we need to stop the ca…
Read full complaint
Our car frequently (several times per month) suddenly stops when it is coming to a STOP when the Stop/Start feature is trying to engage. We took it to the dealer, and VW replaced the starter. That DID NOT fix the problem. When the car stops, frequently at or when approaching intersections, the display says we need to stop the car immediately, and the car is stopped, making a high-pitched sound, like a dentist’s drill. This problem started well before our warranty was finished, but after going to the dealer many times (and even leaving the car with them for a considerable amount of time). We were told many times that they could not replicate the problem, and that their diagnostic tools could not find a problem. I requested help from the automaker, VW, and I was told that they only follow the dealer, even though we have had this problem many, many times, and that there was nothing they could do for us. This is a safety problem, and I have seen many similar complaints online. You need to look into this. This problem happens when driving. We cannot get it fixed, and it seems to pose a danger. When I put the date of the incident, I will put the most recent day this happened. Please note that this has happened more than 100 times, and seems to be getting worse. Please investigate with VW. This is a large problem, and it deserves an auto recall.
NHTSA ODI #11657302
Mileage unknown · Mar 19, 2025
Unknown Or Other
Panoramic Sunroof randomly exploded while my car was parked at my workplace. I parked the vehicle after 8am. My sunroof spontaneously exploded at roughly 2:30pm. A coworker had arrived seconds before the explosion, he parked his vehicle behind & across the lot. While standing by his car, the full outer glass panel forcefully eje…
Read full complaint
Panoramic Sunroof randomly exploded while my car was parked at my workplace. I parked the vehicle after 8am. My sunroof spontaneously exploded at roughly 2:30pm. A coworker had arrived seconds before the explosion, he parked his vehicle behind & across the lot. While standing by his car, the full outer glass panel forcefully ejected off of my Tiguan sunroof & flew across the parking lot before shattering into pieces. My coworker described the explosion like a gunshot. He called me out to assess the damage, glass was all over the parking lot, most of the sunroof’s lower glass panel broke off & shattered on the rear-right passenger & middle seats of my vehicle. Piles of shattered glass landed where my daughter “would have sat” if she were in the vehicle. This experience has been distressing.The thought that this could’ve happened while driving on the road or with my family is absolutely terrifying. What is tragic, is there are several documented cases & reports of a class action settlement yet no recalls or warnings of the possible dangers with Tiguan’s LED Panoramic Sunroof. I contacted the VW St. Aug. FL dealership which is where I purchased the vehicle, reported the incident, the vehicle was dropped off to be inspected the next day, (today) (their sales team confirmed no active recalls were on the vehicle). Instead of receiving assistance & escalating the hazardous report to their VW Corp.Level, I received a call from a repair tech who was rude, showed no empathy & stated that I need to come pick up my car. He stated that it would not be covered under warranty, I need to contact my insurance company to file a claim. He told me to return the loaner that I received yesterday, or he would start charging me $100/a day. I questioned his poor handling of the matter, asked if he tried to escalate the matter to a manager, or VW, he declined to & hung up on me, twice. I never received an estimate for repairs. Their GM never called back. Security cameras recorded incident.
NHTSA ODI #11649156
Mileage unknown · Aug 23, 2024
Electrical SystemUnknown Or Other
Vehicle sending transmission alarms and also exit vehicle in P mode only alarm. First had issue around 25,000 miles and gear shift assembly was replaced under warranty for what I was told was a faulty sensor. Same issue returned at 100,000 miles and Volkswagon is replacing the gear shift assembly again at customers expense. I wa…
Read full complaint
Vehicle sending transmission alarms and also exit vehicle in P mode only alarm. First had issue around 25,000 miles and gear shift assembly was replaced under warranty for what I was told was a faulty sensor. Same issue returned at 100,000 miles and Volkswagon is replacing the gear shift assembly again at customers expense. I was told by Volkswagon that the car is safe to drive.
NHTSA ODI #11610452
Mileage unknown · Jun 2, 2024
Unknown Or Other
2018 Tiguan intermittently fails to accelerate. Car has stopped on highway even after pressing on acceleration peddle. Car behind me had to slam on brakes to avoid hitting rear of my car. Carfax indicates several replacement parts. Beaumont, Texas dealership revealed that previous owner insisted on having parts changed in 2022. …
Read full complaint
2018 Tiguan intermittently fails to accelerate. Car has stopped on highway even after pressing on acceleration peddle. Car behind me had to slam on brakes to avoid hitting rear of my car. Carfax indicates several replacement parts. Beaumont, Texas dealership revealed that previous owner insisted on having parts changed in 2022. Not inspected by manufacturer, police, insurance representatives. Inspected by dealership. There are no warning signals prior to deacceleration. Car died, dash goes black, for close to half minute and then accelerates again. This has happened 3 times since purchase date of 10/23/23. Car was not driven from January 14,2024 to May 2,2024.
NHTSA ODI #11591970
Mileage unknown · May 12, 2024
Fuel/propulsion SystemUnknown Or Other
Same issue as reported with NHTSA CAMPAIGN NUMBER 24V110000 Fuel has flowed into evaporative emissions and has leaked out of the charcoal canister. The dealership is replacing the following parts- Fuel tank Evap canister Leak detection pump Purge Value
NHTSA ODI #11588355
Official recalls
14Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
Apr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Consequence & remedy
Consequence: An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Sep 23, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Consequence & remedy
Consequence: The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy: Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
Nov 20, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Consequence & remedy
Consequence: A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Jul 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Consequence & remedy
Consequence: A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
Apr 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Consequence & remedy
Consequence: If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
Mar 8, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Consequence & remedy
Consequence: If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
Feb 9, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
Oct 18, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18005 · Seat Belt Webbing Failure
Opened Jul 3, 2018 · Closed Feb 27, 2023
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Additional source detail variants (3)
Seat Belts:front
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
PE18001 · Seat Belt Webbing Failure
Opened Jan 10, 2018 · Closed Jul 3, 2018
Status: closed (inferred from source dates) · Seat Belts:front:webbing
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.
Illustration