IllustrationWHEN ACCELERATING. IT FEELS LIKE THE MOTOR IS VIBRATING TOO MUCH LIKE IT'S GOING TO RIP ITSELF OUT. THE CAR HAS ONLY 3K MILES. IT'S BEEN ADDRESSED TO VOLKSWAGEN! MOTOR MOUNTS ARE OK AND TRANSMISSION MOUNT IS GOOD AS TOLD BY DEALER. THIS OCCURS EVERY TIME THE CAR IS ACCELERATING FROM A STANDSTILL
2018 Volkswagen Tiguan
Owner reports · Recalls · Investigations
More warning signs than most Tiguan years
Owner complaints for the 2018 Volkswagen Tiguan are substantially higher than the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tiguan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1300–25K
1825–50K
250–75K
375–100K
1100–150K
0150K+
154 reports with mileage · 128 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports6 injury reports
Engine complaints
80 reportsVEHICLE HAS A SIGNIFICANT HESITATION WHEN STARTING FROM A STOPPED POSITION. WHEN PULLING INTO TRAFFIC YOU STEP ON THE GAS AND INITIALLY THE VEHICLE DOES NOT MOVE WHICH CAUSES YOU TO PRESS FURTHER ON THE ACCELERATOR PEDAL. EVENTUALLY VEHICLE SUDDENLY JERKS VIOLENTLY FORWARD. DEALERSHIP ADVISES THAT SINCE THERE ARE NO TROUBLE CODE…
Read full complaint
VEHICLE HAS A SIGNIFICANT HESITATION WHEN STARTING FROM A STOPPED POSITION. WHEN PULLING INTO TRAFFIC YOU STEP ON THE GAS AND INITIALLY THE VEHICLE DOES NOT MOVE WHICH CAUSES YOU TO PRESS FURTHER ON THE ACCELERATOR PEDAL. EVENTUALLY VEHICLE SUDDENLY JERKS VIOLENTLY FORWARD. DEALERSHIP ADVISES THAT SINCE THERE ARE NO TROUBLE CODES THERE IS NOTHING WRONG. HAS BEEN AN ISSUE SINCE NEW.
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. WHILE DRIVING 45 MPH, THE VEHICLE STALLED WITHOUT WARNING, THE VEHICLE WAS ABLE TO COAST OVER TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. WHEN THE VEHICLE WAS RESTARTED, THE ENGINE STARTED TO VIBRATE. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED M…
Read full complaint
TL* THE CONTACT OWNS A 2018 VOLKSWAGEN TIGUAN. WHILE DRIVING 45 MPH, THE VEHICLE STALLED WITHOUT WARNING, THE VEHICLE WAS ABLE TO COAST OVER TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. WHEN THE VEHICLE WAS RESTARTED, THE ENGINE STARTED TO VIBRATE. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED MOMENTUM VOLKSWAGEN OF CLEAR LAKE AT (844) 894-5461 (LOCATED AT 15100 GULF FWY, HOUSTON, TX 77034) AND WAS INFORMED TO SCHEDULE AN APPOINTMENT. THE DEALER DIAGNOSED THAT THERE WAS MOISTURE IN THE IGNITION LINE AND THERE WAS A SIGNAL FAILURE. THE VEHICLE WAS NOT REPAIRED. WHILE DRIVING HOME FROM THE DEALER, A LOUD ABNORMAL NOISE OCCURRED FROM THE ENGINE AND THE CHECK ENGINE AND OIL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 4,100.
THIS CAR IS DANGEROUS! I HAD VEHICLE FOR 4 MONTHS AND HAVE ONLY DRIVEN 411 MILES CAR HAS STARTED TO HESITATE WHEN PULLING OUT INTO TRAFFIC, IT ALMOST FEELS LIKE IT SHUTS OFF FOR A SOLID 4 SECONDS BEFORE IT DECIDES TO ACCELERATE. GAS MILEAGE READS 100MPG, WE ALL KNOW THAT'S NOT POSSIBLE... LOUD WIND NOISES AT 50 MPH AND A POP NOI…
Read full complaint
THIS CAR IS DANGEROUS! I HAD VEHICLE FOR 4 MONTHS AND HAVE ONLY DRIVEN 411 MILES CAR HAS STARTED TO HESITATE WHEN PULLING OUT INTO TRAFFIC, IT ALMOST FEELS LIKE IT SHUTS OFF FOR A SOLID 4 SECONDS BEFORE IT DECIDES TO ACCELERATE. GAS MILEAGE READS 100MPG, WE ALL KNOW THAT'S NOT POSSIBLE... LOUD WIND NOISES AT 50 MPH AND A POP NOISE COMING FROM DRIVERS SIDE DOOR EVERY BUMP IN THE ROAD AT 50 MPH . THE START STOP OPTION TURNS ON AND OFF WHEN THE ROAD IS ROUGH OR SLIGHTLY BUMPY!
CAR MAKES NOISE THAT IS AUDIBLE WITHIN THE CAR AND IS PARTICULARLY LOUD BY THE REAR PASSENGER SIDE TIRE.
PURCHASED A 2018 VW TIGUAN SEL IN FEBUARY 2018. BROUGHT TO DEALER TWICE (SO FAR) AND BRINGING IT BACKI TOMORROW. HAS STAYED IN SHOP FOR 5 WEEKS SINCE PURCHASE. SERIOUS HESITATION WHEN ACCERLATING. MY WIFE REFUSES TO DRIVE THE VEHICLE IN FEAR OF HER LIFE !! (AND SO AM I) THESE CARS MUST BE STOPPED BEING SOLD...WILL NOT BE L…
Read full complaint
PURCHASED A 2018 VW TIGUAN SEL IN FEBUARY 2018. BROUGHT TO DEALER TWICE (SO FAR) AND BRINGING IT BACKI TOMORROW. HAS STAYED IN SHOP FOR 5 WEEKS SINCE PURCHASE. SERIOUS HESITATION WHEN ACCERLATING. MY WIFE REFUSES TO DRIVE THE VEHICLE IN FEAR OF HER LIFE !! (AND SO AM I) THESE CARS MUST BE STOPPED BEING SOLD...WILL NOT BE LONG BEFORE SOMEONE IS KILLED....
EVERYTIME I DRIVE WHEN ENGINE IS COLD, IT FEELS LIKE ENGINE IS GOING TO DIE. I CAN FEEL SMALL JERKING, LIKE CAR IS RUNNING OUT OF FUEL. FUEL TANK IS FULL. I READ MANY COMPLAINS AND FORMS, VW DOESN'T CARE. I CONTACTED THEM VIA TWITTER, NO RESPONSE YET.
THE VEHICLE HESITATES WHEN ACCELERATING FROM A STOP OR OCCASINGLY SURGES UNDER HEAVIER THROTTLE PRESSURE. THIS IS VERY DANGEROUS AND THE DEALERS ARE TELLING US THIS IS 'NORMAL' BEHAVIOR. I SEE THAT MANY DRIVERS HAVE REPORTED THIS ISSUE. DOES SOMEONE HAVE TO GET INJURED BEFORE WE GET TAKEN SERIOUSLY? VOLKSWAGEN NEEDS TO FIX THE P…
Read full complaint
THE VEHICLE HESITATES WHEN ACCELERATING FROM A STOP OR OCCASINGLY SURGES UNDER HEAVIER THROTTLE PRESSURE. THIS IS VERY DANGEROUS AND THE DEALERS ARE TELLING US THIS IS 'NORMAL' BEHAVIOR. I SEE THAT MANY DRIVERS HAVE REPORTED THIS ISSUE. DOES SOMEONE HAVE TO GET INJURED BEFORE WE GET TAKEN SERIOUSLY? VOLKSWAGEN NEEDS TO FIX THE PROBLEM WITH THE ENGINE NOW.
08/24/2018- EPC LIGHT CAME ON SHORTLY AFTER I BEGAN MY MORNING COMMUTE WHILE DRIVING APPROX 45MPH ON CITY STREET. MY CAR SLOWED AND WOULD NOT ALLOW ACCELERATION, AS A SECOND WARNING LIGHT CAME ON STATING 'ENGINE SPEED MAX 3000RPM'. I WAS ABLE TO DRIVE BACK A SHORT DISTANCE AT A REDUCED SPEED WITH LIMITED ACCELERATION. HAD CAR TO…
Read full complaint
08/24/2018- EPC LIGHT CAME ON SHORTLY AFTER I BEGAN MY MORNING COMMUTE WHILE DRIVING APPROX 45MPH ON CITY STREET. MY CAR SLOWED AND WOULD NOT ALLOW ACCELERATION, AS A SECOND WARNING LIGHT CAME ON STATING 'ENGINE SPEED MAX 3000RPM'. I WAS ABLE TO DRIVE BACK A SHORT DISTANCE AT A REDUCED SPEED WITH LIMITED ACCELERATION. HAD CAR TOWED FOR THE EARLIEST AVAILABLE APPOINTMENT ON 08/27/2018 AT A LOCAL VW SERVICE CENTER. TOLD TIMING CHAIN NEEDED TO BE REPLACED FOLLOWING A THOROUGH DIAGNOSTIC AND TSB. 09/21/2018- TOLD VW ENGINEER INSPECTED THE VEHICLE AFTER THE TIMING CHAIN FIX AND THE ECP LIGHT CAME BACK ON, SO IT WAS DETERMINED A FULL ENGINE REPLACEMENT WAS NEEDED. ALSO SAME DAY, VW CUSTOMER CARE REPRESENTATIVE INFORMED ME THAT MY PRIOR REQUEST FOR A VEHICLE REPLACEMENT/ REPURCHASE WAS DENIED, BUT WOULD BE RE-SUBMITTED WITH THE NEW INFORMATION TEGARDING THE ENGINE. 09/25/2018- VW CUSTOMER CARE REP NOTIFIED ME THAT A NEW ENGINE WAS ORDERED AND WAS ESTIMATED TO ARRIVE AT VW SERVICE WITHIN 10-12 BUSINESS DAYS. 09/26/2018- I NOTIFIED VW CUSTOMER CARE REP THAT I WANT TO BE CONTACTED AS SOON AS A DECISION FOR THE RE-SUBMITTED REPLACEMENT/REPURCHASE REQUEST IS MADE, AS I AM NOT COMFORTABLE DRIVING THIS VEHICLE DUE TO SAFETY CONCERNS (FAILURE TO ACCELERATE) AND RELIABILITY CONCERNS AFTER ENGINE FAILURE AT 5 MO./ 4575 MILES.
THE TIGUAN HAS BEEN HAVING ISSUES WITH HESITATION WHILE SHIFTING BETWEEN 1ST AND 2ND GEAR. YOU CAN FEEL AN IMMEDIATE LOSS OF POWER, LOSS OF BOOST AND A BUCKING FEELING WHILE IT SHIFTING. I'VE ALSO DRIVEN ANOTHER TIGUAN OF THE SAME YEAR AND THE ISSUE WAS PRESENT ON THAT SPECIFIC MODEL TOO. THIS ISSUE IS NOT ONLY AN ANNOYAN…
Read full complaint
THE TIGUAN HAS BEEN HAVING ISSUES WITH HESITATION WHILE SHIFTING BETWEEN 1ST AND 2ND GEAR. YOU CAN FEEL AN IMMEDIATE LOSS OF POWER, LOSS OF BOOST AND A BUCKING FEELING WHILE IT SHIFTING. I'VE ALSO DRIVEN ANOTHER TIGUAN OF THE SAME YEAR AND THE ISSUE WAS PRESENT ON THAT SPECIFIC MODEL TOO. THIS ISSUE IS NOT ONLY AN ANNOYANCE BUT ALSO A SAFETY ISSUE WHILE MERGING OR TRYING TO ACCELERATE FROM A STOP.
Official recalls
1426V590000 · Steering
Sep 11, 2026
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan, 2018-2019 Atlas, and 2019-2021 Audi Q3 vehicles. One of the bolts that attaches the steering rack to the subframe may corrode and break. If this happens, the steering rack housing can break.
Consequence & remedy
Consequence: A broken steering rack housing can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the right-side steering rack mounting bolt, free of charge. Owner notification letters are expected to be mailed November 10, 2026. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 48LG and 48VT. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 16, 2026.
22V226000 · Structure:body
Apr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
Consequence & remedy
Consequence: An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
21V732000 · Structure:body:roof And Pillars
Sep 23, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan vehicles. During the repair of roof damage, an incorrect roof reinforcement assembly may have been installed.
Consequence & remedy
Consequence: The incorrect roof reinforcement may decrease the roof's structural integrity or impact deployment of the side curtain air bags, increasing the risk of injury in the event of a crash.
Remedy: Dealers will be replace the roof reinforcement, free of charge. Owner notification letters were mailed November 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 51H5.
20V724000 · Seat Belts:front:webbing
Nov 20, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan LWB vehicles. In the event of a crash, one or both of the front seat belt's webbing may tear.
Consequence & remedy
Consequence: A torn seat belt may not adequately restrain the seat occupant during a crash, increasing their risk of injury.
Remedy: Volkswagen will notify owners, and dealers will inspect the front seat belts and replace them as necessary, free of charge. The recall began April 13, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BH.
19V679000 · Unknown Or Other
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
19V188000 · Suspension:rear:springs:coil Springs
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
18V824000 · Electrical System: Instrument Cluster/panel
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
18V467000 · Visibility:sun/moon Roof Assembly
Jul 13, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan vehicles. The LED module for the panoramic sunroof ambient light bar may short circuit.
Consequence & remedy
Consequence: A short-circuit can increase the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will disconnect the power supply for the panoramic sunroof LED module, free of charge, until a future service action can safely reactivate the feature. The recall began July 24, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall 60D1.
18V375000 · Air Bags:frontal:passenger Side:inflator Module
Jun 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and Tiguan vehicles. In the event of a crash, the passenger frontal air bag may tear or not properly unfold during deployment.
Consequence & remedy
Consequence: If the air bag were to tear or unfold incorrectly during deployment, it can increase the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger frontal air bag, free of charge. The recall began July 19, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69W8, and 69W9.
18V324000 · Suspension:front:control Arm:lower Ball Joint
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan and Tiguan long wheel base (LWB) vehicles. The nut that holds the lower ball joint of the front wheel on each side of the vehicle may be loose or improperly tightened.
Consequence & remedy
Consequence: A loose or improperly tightened ball joint nut can result in the separation of the lower ball joint causing steering, traction or other stability issues, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the nut on the lower ball joint and, as necessary, clean the thread in the ball joint, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40N4. Note: owners are advised not to drive their vehicle until the recall repair has been performed.
18V262000 · Suspension:rear:shock Absorber
Apr 25, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheelbase (LWB) vehicles. A lower loop of a rear shock absorber may separate from its base due to an incorrect welding process
Consequence & remedy
Consequence: If the lower loop of the rear shock absorber detaches, there may be a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the rear shock absorbers, replacing them as necessary, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42i7.
18V159000 · Engine
Mar 8, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Tiguan long wheel base (LWB) vehicles. The engine support bolts on these vehicles may not have been properly tightened.
Consequence & remedy
Consequence: If the engine support bolts were not properly tightened, an unexpected engine breakdown or loss of engine power may occur, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace engine support bolts, free of charge. The recall began March 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 10F7.
18V102000 · Air Bags:frontal
Feb 9, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Tiguan Limited vehicles. The front driver air bag installed on these vehicles may not be intended for use in vehicles sold in the United States. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, the incorrect air bags may not protect the driver as intended, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the steering wheel and front driver air bag module, free of charge. The recall began May 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69V2.
17V662000 · Exterior Lighting:tail Lights
Oct 18, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Tiguan long wheel base (LWB) vehicles. The back-up lights in the taillight assemblies may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the back-up lights are not bright enough, other drivers may not see the vehicle reversing, or the driver may back into an obstacle, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the affected inner taillight assemblies, free of charge. The recall began December 15, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94J9.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18005 · Seat Belt Webbing Failure
Opened Jul 3, 2018 · Closed Feb 27, 2023
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Additional source detail variants (3)
Seat Belts:front
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts:front:webbing
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
Seat Belts
In December 2017, NHTSA conducted two (2) New Car Assessment Program (NCAP) tests on the Model Year (MY) 2018 Volkswagen (VW) Tiguan. Both tests were 35mph full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front passenger position. The tests were conducted on December 8, 2017, at MGA Research Corp. (MGA) in Wisconsin and December 13, 2017, at the Transportation Research Center (TRC) of Ohio.During both crash tests, the driver seat belt webbing completely separated at the point where the webbing loops through the Crash Locking Tongue (CLT). In both NCAP tests, the dummy injury criteria requirements, as set forth in Federal Motor Vehicle Safety Standard (FMVSS) 208, were met with one exception. The chest deceleration G force requirement was exceeded in the test conducted at TRC. The FMVSS 208 injury criteria requirement for the chest deceleration is 60 Gs and it was measured at 67 Gs in the test conducted at TRC. It should be noted, FMVSS 208 does not include a requirement that the seat belt webbing remain intact during a frontal collision to comply with the standard. Compliance with the standard is based on the dummy injury criteria.Further, the Agency has conducted NCAP testing with no substantial protocol changes for over forty (40) years. This includes tests conducted prior and subsequent to the subject NCAP tests. During that time there has not been a similar failure of the seat belt webbing in any other NCAP tested vehicle manufactured by VW or another manufacturer.In November 2020, VW filed a defect notice (20V-724/69BH) that recalled seat belt systems, both driver, and front passenger, that were manufactured with webbing from the same lot as the two NCAP tested MY2018 Tiguan vehicles. VW has tested and inspected several of the returned seat belt systems and found no anomalies in either the webbing or the CLT that would substantially affect system performance in a frontal collision.The Office of Defects Investigation (ODI) estimates that between 2000 and 3500 frontal collisions involving MY2018 VW Tiguan vehicles have occurred in the field during the time these vehicles have been in service. This estimate is based on vehicle population and an estimated yearly rate of severe frontal collisions.A severe frontal collision is defined, in this instance, as being of sufficient severity to warrant a commanded deployment of the frontal air bags. These collisions would place a significant load on the seat belt system similar to loads experienced during the NCAP tests. To date, neither ODI nor VW is aware of any frontal collision in the field that resulted in separation of the seat belt webbing. ODI believes that had any field collisions involved separation of the seat belt webbing, the Agency would have been notified.In view of the recall being conducted by VW, and lack of field data demonstrating a system defect, ODI is closing this Engineering Analysis (EA). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances.
PE18001 · Seat Belt Webbing Failure
Opened Jan 10, 2018 · Closed Jul 3, 2018
Status: closed (inferred from source dates) · Seat Belts:front:webbing
In December 2017, NHTSA conducted two New Car Assessment Program (NCAP) tests on the 2018 MY Volkswagen (VW) Tiguan. Both tests were 35 mph, full frontal impacts into a rigid barrier with a 50th percentile male dummy seat-belted in the driver position and a 5th percentile female seat-belted in the right front-passenger position. The tests were conducted on December 8, 2017 at MGA Research Corp. in Wisconsin (MGA) and December 13, 2017 at the Transportation Research Center of Ohio (TRC).During both crash tests, the driver seat belt webbing completely separated in tension where it looped through the seat belt latch tongue (see attached photos). Based on its analysis of the NCAP test results, VW asserted that the test dummy umbilical cord exerted additional forces on the seat belt system causing the separation. To support this theory, VW conducted several sled tests.The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE18-001) on 01/10/2018 to evaluate the two (2) incidents of seat belt separation. ODI and NCAP reviewed the sled test data submitted by VW in support of their theory. Micro analysis, conducted by the Materials Laboratory at the National Transportation Safety Board (NTSB), verified the seat belts failed in tension and not due to cuts or abrasion.PE18-001 has been upgraded to an Engineering Analysis (EA18-005) to further examine seat belt behavior in the subject vehicles and to determine, among other things, a root cause for the seat belt separation. ODI will perform a thorough review of any vehicle and seat belt design changes for the new 2018 MY Tiguan platform and their effects on the performance of the seat belt system.