2015 Volkswagen Passat

While driving the EPC light came on and the car stopped driving. Vehicle was towed to local VW dealership, a FULL engine rebuild took place and a faulty intake valve spring was found, after replacing the injectors and seal kits. Then to replace the faulty electronic ignition switch. Over $3k in repairs for faulty parts. It was a safety risk because the vehicle stopped working in the middle of driving, in traffic with no other indication that something was wrong prior on a major road in the city. Since then, the vehicle has had constant issues with oil being low even after an oil change, no leaks were detected or reported. Also, the airbags and clockspring was supposed to be replaced. My airbag light came on in 3/2023 and it sounds like the clock spring is broken. Horn and electronics do not work from the steering column.

I take my car to the dealership for maintenance when it is scheduled. The ignition would not allow me to put the key inside. I did a little internet research and it seems to be a common problem with this car. I could not put the key in the ignition. I then used some wd40 and got it to go in eventually but thought I should report it as this could pose a safety hazard.

Severe crack in sidewall of one tire. (4) 235/45R18 GOODYEAR ASSURANCE MAXLIFE I stopped by the installer today 9/12/2023. At risk for Blow-out. No signs of running underinflated. To my surprise - they Identified that the three other tires are show similar sidewall cracking emerging. Pictures available. Pictures of the other three tires are available upon request. I purchased four tires from Tire rack January 5, 2020. RHP Reference Number(s): XXXXXXXXXXXXXXXXXX NOTE: Is this similar to complaint # NHTSA ID NUMBER: 11510140 ( March 4, 2023 ) Similarities: Both cars had: Same "brand" Tire. Similare make. Passat. 2017 vs my 2015 (TDI = extra weight) Hot climate Texas vs Arizona INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Failed part: Clock spring. Yes, the work was appropriately installed. This is my fourth replacement within less than 100k miles. No additional inspections as of yet. No warning lights, just a faint click coming from the steering wheels while making turns two days prior to hearing a snapping noise. My air bag light illuminated and my dash notified me of an air bag error. Lost all connection to steering wheel controls and horn. This is the same thing that has happened every time prior. The car is inoperable, once again, due to clock spring failure. I cannot drive my vehicle as I am concerned about not having safety features of an air bag and a horn. This has been an ongoing issue with VW. I have been the only owner of this vehicle for almost nine years.

Rear coil spring is broken. Normal driving conditions and we noticed a significant vibration. Upon inspection of rear suspension we found a broken rear coil spring. I researched this issue and found that VW recalled several other 2015 models for rear coil springs breaking. This is a major safety issue. Currently we cannot use the car due to this safety issue.

I have no heat on the passenger side of the vehicle from any of the vents. The windshield would ice up due to this. The drivers side works fine. This car does not have Climatronic. It has manual controls. I have been told the heater core is clogging by my mechanic. This is a 2015. VW extended the warranty for 2012-14 Passat TDI's with the CKRA engine however this is a 2015 with the CVCA TDI engine. Is there any extended coverage for this generation engine? I don't want this to develop into a larger issue with deficient EGR cooling problems. The heater core in the 2015 is the same part number used in previous model years which are covered by the recall.

The contact owns a 2015 Volkswagen Passat. The contact stated that while driving approximately 15 MPH, the vehicle lost motive power and stalled. The contact was unable to immediately restart the vehicle. After several attempts, the vehicle was restarted and driven to the residence. After parking the vehicle, the vehicle would no longer start. The contact stated that prior to the failure, the EPC warning light remained illuminated. The local dealer was unable to determine the cause of the failure. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 3,500.