NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
55 reportsClear category filter90,000 miles · Feb 5, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY) AND IMMEDIATELY CALLED THE DEALER. THE CONTACT WAS INFORMED THAT THEY WOULD REPAIR THE VEHICLE ACCORDING TO THE REMEDY; HOWEVER, IF THE HEAT SHIELDS AND ANOTHER COMPONENT BE…
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY) AND IMMEDIATELY CALLED THE DEALER. THE CONTACT WAS INFORMED THAT THEY WOULD REPAIR THE VEHICLE ACCORDING TO THE REMEDY; HOWEVER, IF THE HEAT SHIELDS AND ANOTHER COMPONENT BECAME DAMAGED DURING THE INSTALLATION, HE WOULD HAVE TO PAY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 90,000.
NHTSA ODI #10257535
91,000 miles · Jan 19, 2009
Fuel System, Gasoline
SUDDENLY FELT STRONG GASOLINE SMELL INSIDE THE VEHICLE (NOT A RESULT OF ACCIDENT OR ANY OTHER OCCURRENCE.) THE PROBLEM WAS DIAGNOSED AS A FUEL TANK LEAK. THE GAS TANK HAD TO BE REPLACED. THE VW DEALER IN SUNNYVALE, CA, REFUSED TO PAY FOR THE COSTLY REPAIRS. *TR
NHTSA ODI #10255523
51,300 miles · Jul 21, 2008
Fuel System, Gasoline
VEHICLE LEAKED A LARGE AMOUNT OF FUEL (~4 GALLONS IN 3 DAYS). NO FIRE, BUT THERE IS NOW A LARGE HOLE IN MY DRIVEWAY. SHOP SAYS LEAK IS FROM TOP OF ENGINE. *TR
NHTSA ODI #10235175
Mileage unknown · Jul 9, 2008
Fuel System, GasolineFire
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT END OF THE VEHICLE. SHE PULLED OVER TO A LOCAL SERVICE STATION AND NOTICED THAT THE VEHICLE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE WAS EXTINGUISHED BY A REPRESENTATIVE AT THE SERVICE STATION. …
Read full complaint
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT END OF THE VEHICLE. SHE PULLED OVER TO A LOCAL SERVICE STATION AND NOTICED THAT THE VEHICLE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE WAS EXTINGUISHED BY A REPRESENTATIVE AT THE SERVICE STATION. WEEKS LATER, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY). SHE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
NHTSA ODI #10233674
Mileage unknown · Jul 3, 2008
Engine And Engine CoolingFuel System, Gasoline
2002 VOLKSWAGEN PASSAT WITH FUEL ODOR. CONSUMER STATES THAT SHE NOTICED A STRONG FUEL SMELL FILLING HER GARAGE. MECHANIC STATED THAT THERE WAS A CRACK IN THE FUEL TANK. MECHANIC STATED THAT THE CONSUMER HIT THE BOTTOM OF THE FUEL TANK ON SOMETHING. *KB THE CONSUMER STATED A FEW MONTHS AFTER THE FUEL TANK WAS REPLACED, THE TIMI…
Read full complaint
2002 VOLKSWAGEN PASSAT WITH FUEL ODOR. CONSUMER STATES THAT SHE NOTICED A STRONG FUEL SMELL FILLING HER GARAGE. MECHANIC STATED THAT THERE WAS A CRACK IN THE FUEL TANK. MECHANIC STATED THAT THE CONSUMER HIT THE BOTTOM OF THE FUEL TANK ON SOMETHING. *KB THE CONSUMER STATED A FEW MONTHS AFTER THE FUEL TANK WAS REPLACED, THE TIMING BELT FAILED. *JB
NHTSA ODI #10233910
76,000 miles · Jun 3, 2008
Fuel System, Gasoline
FOR THE PAST NINE MONTHS I HAVE SMELLED GAS WHEN I FILLED MY GAS TANK PAST HALF FULL. I CHECKED FOR RECALLS ON YOUR WEBSITE LAST MONTH AN CAME ACROSS THE VW PASSAT FUEL TANK SAFETY RECALL. SINCE MY CAR WAS AT THE DEALERSHIP TO TAKE CARE OF YET ANOTHER PROBLEM, I TOLD THEM ABOUT MY GAS SMELL PROBLEM AND INFORMED THEM ABOUT THE…
Read full complaint
FOR THE PAST NINE MONTHS I HAVE SMELLED GAS WHEN I FILLED MY GAS TANK PAST HALF FULL. I CHECKED FOR RECALLS ON YOUR WEBSITE LAST MONTH AN CAME ACROSS THE VW PASSAT FUEL TANK SAFETY RECALL. SINCE MY CAR WAS AT THE DEALERSHIP TO TAKE CARE OF YET ANOTHER PROBLEM, I TOLD THEM ABOUT MY GAS SMELL PROBLEM AND INFORMED THEM ABOUT THE RECALL. I TOLD THEM THAT IT ONLY OCCURS WHEN THE GAS TANK IS PAST HALF FULL AND TOLD THEM TO PUT GAS IN IT AND TEST IT. WHEN I PICKED UP THE CAR THEY HADN'T DONE THE GAS TANK TEST. THE SERVICE ADVISOR LOOKED UP THE RECALL AND FOUND INFORMATION ON THE GAS TANK SAFETY RECALL R5 AND PRINTED OUT A FAQ SHEET. HE INFORMED ME THAT THEY DIDN'T HAVE THE NEW TANK FOR THE RECALL AND HE EXPECTED THEM ON MAY 30TH. HE TOLD ME TO CONTACT HIM AND MAKE AN APPOINTMENT TO HAVE THE TANK REPLACED ONCE THEY HAD THE PARTS IN. I CALLED THE DEALER ON MAY 30TH AND MADE AN APPOINTMENT FOR TODAY JUNE 3RD. I BROUGHT MY CAR TO THE DEALERSHIP AND I WAS INFORMED BY ANOTHER SERVICE ADVISOR AND SHE COULDN'T FIND ANY VOLKSWAGEN RECALL COVERING MY VIN. THE SERVICE ADVISER I SPOKE TO WHEN I HAD PICKED UP MY CAR AFTER THE REPAIRS I HAD DONE IN MAY CAME OVER. HE RECALLED OBTAINING THE INFORMATION AND SEARCHED FOR IT AGAIN AND IT WASN'T LISTED. THEY LET ME CALL VOLKSWAGEN CUSTOMER SERVICE. THE VW CUSTOMER SERVICE REPRESENTATIVE SAID THAT THERE WASN'T A SAFETY RECALL ON THE MY VOLKSWAGEN W8. I TOLD HIM THAT IT SMELLS LIKE GAS WHEN THE GAS TANK IS FILLED PAST HALF FULL. HE SAID HE WOULD CONTACT THE SERVICE MANAGER AT THE DEALERSHIP I WAS AT AND SEE WHAT COULD BE DONE. I READ THE INFORMATION ON YOUR WEBSITE INVOLVING THIS RECALL AND IT SEAMS PRETTY CLEAR THAT ANY 1999- 2005 MODEL YEAR PASSAT WITH A GASOLINE ENGINE IS COVERED. I HAVE A 2002 VW PASSAT W8 WITH 4MOTION. ONE OF THE RESPONSES FROM VW LISTS VIN NUMBER RANGES, BUT MINE DOESN'T APPEAR TO BE WITHIN THAT RANGE. I THINK THAT VW ERRED IN THEIR INVESTIGATION AND DIDN'T LOOK INTO THE W8. *TR
NHTSA ODI #10229721
37,700 miles · May 6, 2008
Fuel System, Gasoline
I HAVE A 2002 VW PASSAT V6 GLX WAGON WITH 37,000 MILES. WHENEVER THE FUEL TANK IS FULL, OR NEAR-FULL, THERE IS A STRONG SMELL OF GASOLINE FROM THE RIGHT REAR SIDE. I HAVE HAD TO LEAVE MY GARAGE DOOR PARTIALLY OPEN BECAUSE OF THE DANGER OF IGNITING FUMES FROM THE PILOT LIGHTS OF MY HOME GAS WATER HEATER AND FURNACE IN THE GARAGE…
Read full complaint
I HAVE A 2002 VW PASSAT V6 GLX WAGON WITH 37,000 MILES. WHENEVER THE FUEL TANK IS FULL, OR NEAR-FULL, THERE IS A STRONG SMELL OF GASOLINE FROM THE RIGHT REAR SIDE. I HAVE HAD TO LEAVE MY GARAGE DOOR PARTIALLY OPEN BECAUSE OF THE DANGER OF IGNITING FUMES FROM THE PILOT LIGHTS OF MY HOME GAS WATER HEATER AND FURNACE IN THE GARAGE. I HAVE FOUND WET PATCHES SMELLING STRONGLY OF GASOLINE ON THE UNDERSIDE OF THE FUEL TANK. IT IS OBVIOUS THAT THE GASOLINE TANK IS LEAKING SOMEHOW AND PRESENTS A FIRE SAFETY ISSUE. I SUSPECT IT MIGHT BE THE SAME PROBLEM THAT IS BEING INVESTIGATED IN NHTSA ACTION NUMBER PE08008 EVEN THOUGH MY MODEL IS NOT AN ALL-WHEEL-DRIVE. MEANWHILE, WHENEVER THE VEHICLE IS PARKED, IN MY GARAGE OR OUT IN THE OPEN, THERE IS A CONSTANT DANGER OF FIRE BEING IGNITED. *TR
NHTSA ODI #10226866
100,000 miles · Apr 14, 2008
Fuel System, Gasoline
2002 PASSAT 4 MOTION V6 LEAKING GAS THEN FILLED UP OVER HALF A TANK? *TR
NHTSA ODI #10224463
81,150 miles · Mar 10, 2008
Fuel System, Gasoline
AFTER A GAS FILL IN FEBRUARY 2008 A STRONG ODOR OF GASOLINE WAS EVIDENT. UPON INSPECTION, IT WAS NOTED THAT GAS WAS LEAKING ONTO THE PAVEMENT UNDER THE CAR. THE PROBLEM SEEMED TO RESOLVE ITSELF AFTER ABOUT 1/4 TANK OF GAS WAS BURNED. AFTER THE NEXT FILL, THE PROBLEM RECURRED. THE DEALERSHIP DETERMINED THAT A SENDING UNIT HAD…
Read full complaint
AFTER A GAS FILL IN FEBRUARY 2008 A STRONG ODOR OF GASOLINE WAS EVIDENT. UPON INSPECTION, IT WAS NOTED THAT GAS WAS LEAKING ONTO THE PAVEMENT UNDER THE CAR. THE PROBLEM SEEMED TO RESOLVE ITSELF AFTER ABOUT 1/4 TANK OF GAS WAS BURNED. AFTER THE NEXT FILL, THE PROBLEM RECURRED. THE DEALERSHIP DETERMINED THAT A SENDING UNIT HAD FAILED, WHICH WAS REPLACED. AGAIN THE PROBLEM RECURRED UPON FILLING THE GAS TANK. THE DEALERSHIP THEN DETERMINED THAT THERE WAS A BROKEN VENT ON THE FUEL TANK CAUSING THE LEAK WHICH REQUIRED A REPLACEMENT TANK. DURING ALL OF THIS THERE WAS NEVER A WARNING LIGHT THAT WOULD ALERT TO THE PROBLEM. *TR
NHTSA ODI #10220545
61,000 miles · Feb 11, 2008
Engine And Engine CoolingFuel System, GasolineFire
LAST SATURDAY (FEB.9, 2008) AROUND 11:00AM, WHILE I WAS PICKING UP MY TWO DAUGHTERS FROM BALLET SCHOOL (BOSTON BALLET, 19 CLARENDON STREET, BOSTON), THE CHECK ENGINE LAMP STARTED TO BLINK AND I COULD FEEL MY CAR (2002 PASSAT WAGON, ALL WHEEL DRIVE) WAS A LITTLE BIT SHAKING. AS THE CAR MANUAL SAYS, I DROVE IN LOW POWER TO THE CLO…
Read full complaint
LAST SATURDAY (FEB.9, 2008) AROUND 11:00AM, WHILE I WAS PICKING UP MY TWO DAUGHTERS FROM BALLET SCHOOL (BOSTON BALLET, 19 CLARENDON STREET, BOSTON), THE CHECK ENGINE LAMP STARTED TO BLINK AND I COULD FEEL MY CAR (2002 PASSAT WAGON, ALL WHEEL DRIVE) WAS A LITTLE BIT SHAKING. AS THE CAR MANUAL SAYS, I DROVE IN LOW POWER TO THE CLOSEST VOLKSWAGEN DEALERSHIP (BOSTON VOLKSWAGEN, 168 WESTERN AVENUE, ALLSTON). WHILE I WAS DRIVING TO THE DEALERSHIP, I SAW SOME SMOKE COMING OUT FROM THE FRONT HOOD (RIGHT FRONT SIDE). WE (MY DAUGHTERS, MY WIFE, AND MYSELF) GOT THE DEALERSHIP AROUND 11:30AM. A SALES CONSULTANT (MICHAEL PETERSANTE) AND ANOTHER PERSON THERE SAW MY CAR, AND SAID THAT MY CAR POSSIBLY WOULD CATCH ON FIRE. WE EVACUATED FROM THE CAR, THEY MOVED ALL THE CARS AROUND MY CAR TO THE OTHER PLACE. THE DEALER CALLED FOR A FIRE DEPARTMENT. BEFORE THE FIRE DEPARTMENT CAME IN, WHILE I WAS LOOKING AT MY CAR FROM THE INSIDE OF THE DEALERSHIP BUILDING, I COULD SEE THE FLAME COMING OUT ABOVE THE RIGHT FRONT WHEEL IN THE CAR (SOMEWHERE THE ENGINE IS LOCATED) AND SMOKE FILLING UP INSIDE OF MY CAR. THE FIRE DEPARTMENT (BOSTON FIRE-ENGINE 41, LADDER 14, UNIT D11) CAME AND PUT OUT THE FIRE. A POLICE OFFICER (BOSTON POLICE DISTRICT 14, 301 WASHINGTON STREET, BRIGHTON) CAME AFTER THE FIRE WAS EXTINGUISHED (ARRIVED AT 11:53AM), AND CHECKED OUT THE SCENE AND HAD MY CAR, WHOSE FRONT PART (ENGINE COMPARTMENT) WAS ALL BROKEN AND CRUSHED WHILE THE WIRE WAS PUT OUT, BE TOWED. IT WAS HARD TO BELIEVE THAT A 5-6 YEARS OLD CAR CAUGHT ON FIRE WHILE I WAS DRIVING AND IN JUST 30 MINUTES REACHED TO SUCH SITUATION. FORTUNATELY, WE WERE CLOSE TO THE DEALERSHIP AND WERE ABLE TO GET THERE BEFORE THE WORST THING HAPPENS. AND AGAIN, VERY FORTUNATELY, MY FAMILY WAS ABLE TO GET AWAY TO THE SAFE PLACE BEFORE THE WORST THING HAPPENS. BUT IF IT HAPPENED 10 MINUTES EARLIER OR IF IT TOOK 10 MINUTES LONGER THAN ACTUALLY IT DID TO GET THERE, THINGS THAT I DON'T EVER WANT TO IMAGINE COULD HAPPEN TO MY FAMILY. *TR
NHTSA ODI #10217645
NHTSA investigations
9EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE10027 · Engine Compartment Fire
Opened Jul 26, 2010 · Closed Feb 7, 2011
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Additional source detail variants (2)
Electrical System
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
Engine And Engine Cooling
ODI has received 11 complaints alleging that a fire started in the engine compartment of the vehicle that may be related to ignition coil failure, and 9 complaints of ignition coil failure that did not result in a fire.Reports state that the vehicle hesitated or lost power, and the check engine or dashboard lights illuminated.The vehicles were repaired by replacing the faulty ignition coil(s). Some of the complaints indicated that the ignition coils were replaced more than once.The scope of PE10-027 focused on Model Years (MY)2002-2003 Passat vehicles.Volkswagen provided data regarding their analysis of the vehicle fires and faulty ignition coils for these vehicles as well as other MY Passat vehicles.ODI needs to further investigate this issue.To facilitate the acquisition and analysis of additional information, this investigation has been upgraded to an Engineering Analysis, EA11-002.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
PE07018 · Water/ice In Brake Booster
Opened Apr 3, 2007 · Closed Sep 4, 2007
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist:vacuum
DURING THIS INVESTIGATION, VOLKSWAGEN OF AMERICA (VW) IDENTIFIED A PROBLEM WITH WATER ACCUMULATION IN THE FRESH AIR PLENUM THAT COULD, IN CERTAIN CIRCUMSTANCES, RESULT IN REDUCED BRAKE POWER ASSIST IN MODEL YEAR (MY) 2002 PASSAT VEHICLES.VW INDICATED THAT PROBLEM IS CAUSED BY LEAVES AND OTHER DEBRIS CLOGGING THE PLENUM DRAINS, WHICH MAY RESULT IN WATER FILLING THE PLENUM TO THE LEVEL OF THE BRAKE BOOSTER AIR INTAKE.THE BOOSTER AIR INTAKE IS LOCATED IN THE FRESH AIR PLENUM IN THE MY 2002 PASSAT VEHICLES, BUT NOT IN THE MY 2001 OR 2003 VEHICLES WHICH DRAW BOOSTER AIR FROM THE CABIN.VW TESTING SHOWED THAT BRAKE ASSIST COULD BE REDUCED IF WATER ENTERS THE BOOSTER AND FREEZES.VW IS ADDRESSING THE PROBLEM WITH A SERVICE CAMPAIGN, WHICH BEGAN IN AUGUST 2007.THE FRESH AIR PLENUM IN THE SUBJECT VEHICLES IS AN ENCLOSED SPACE AT THE BASE OF THE WINDSHIELD FROM WHICH THE VEHICLE VENTILATION SYSTEM DRAWS THE FRESH AIR SUPPLY VIA A POLLEN FILTER.RAIN WATER THAT FLOWS OFF THE WINDSHIELD INTO THE PLENUM IS DRAINED THROUGH TWO VALVES LOCATED BELOW THE BATTERY AND BRAKE BOOSTER.STRAINERS AT THE BASE OF THE WINDSHIELD AND IN THE PANEL COVERING THE TOP OF THE PLENUM BLOCK LEAVES, PINE NEEDLES AND OTHER DEBRIS.OVER TIME, DEBRIS MAY ENTER THE PLENUM THROUGH OPENINGS IN THE PLENUM PANEL OR AROUND THE HOOD HINGES.IF CLOGGED DRAINS ALLOW APPROXIMATELY 3-4 GALLONS OF WATER TO ACCUMULATE IN THE PLENUM, THE WATER MAY ENTER THE BOOSTER THROUGH THE AIR INTAKE.WATER ACCUMULATION IN THE PLENUM MAY ALSO RESULT IN COMPLAINTS OF WET CARPETS IN THE VEHICLE INTERIOR IF THE WATER REACHES THE LEVEL OF THE FRESH AIR INTAKE/POLLEN FILTER. VW STATED THAT ITS TESTING SHOWED THAT BRAKE PERFORMANCE AND ACTUATING FORCE (I.E., PEDAL EFFORT) ARE NOT AFFECTED WHEN THE BOOSTER IS FILLED WITH THE MAXIMUM AMOUNT OF WATER POSSIBLE (UP TO THE HEIGHT OF THE BOOSTER ENGINE VACUUM CONNECTION, THROUGH WHICH WATER DRAWN INTO THE BOOSTER IS EVACUATED).VW'S TESTING SHOWED THAT BRAKE PERFORMANCE AND ACTUATING FORCE COULD BE AFFECTED BY WATER FREEZING IN THE BOOSTER.HOWEVER, WHEN TESTED WITH RELATIVELY LOW VOLUMES OF FROZEN WATER IN THE BOOSTER, VW SHOWED THAT THE EFFECTS WERE SIGNIFICANTLY LESS SEVERE THAN FOR CONDITIONS THAT RESULT IN A COMPLETE LOSS OF VACUUM ASSIST.WHILE VW INDICATED THAT THE EFFECTS WOULD BE MORE SEVERE WITH GREATER VOLUMES OF FROZEN WATER, IT MAINTAINED THAT THE CHANCES OF THIS OCCURRING WERE REMOTE AND WOULD BE READILY DISCERNABLE TO THE DRIVER UPON THE INITIAL BRAKE APPLICATION AFTER VEHICLE START-UP.ODI'S ANALYSIS OF COMPLAINTS AND WARRANTY DATA SHOWED DISPROPORTIONATE CONCENTRATIONS IN WINTER MONTHS AND IN NORTHERN STATES WITH COLDER WINTER CLIMATES. ODI IDENTIFIED THREE MINOR CRASHES RELATED TO THE ALLEGED DEFECT IN MY 2002 PASSAT VEHICLES.TWO OF THE CRASHES OCCURRED INGARAGES/DRIVEWAYS AND THE THIRD OCCURRED IN A DEALER SERVICE GARAGE.THERE WERE NO INJURIES ALLEGED IN THE CRASHES BUT A FOOT INJURY WAS ALLEGED IN A FOURTH INCIDENT WHERE EXCESSIVE BRAKE EFFORT REQUIRED DURING A HARD STOP. VOLKSWAGEN IS CONDUCTING A SERVICE CAMPAIGN TO REMEDY THIS CONDITION IN MY 2002 PASSAT AND AUDI A4 AND A6 VEHICLES.THE REMEDY PROCEDURE REQUIRES VW DEALERS TO INSPECT, CLEAN AND MODIFY THE AIR PLENUM DRAIN, AS WELL AS MODIFY THE SUNROOF DRAIN (IF EQUIPPED) AND INSTALL AN IMPROVED SEAL FOR THE POLLEN FILTER.IN ADDITION, VW HAS AGREED TO PROVIDE THE FOLLOWING INFORMATION TO ODI1. QUARTERLY COMPLETION REPORTS FOR ONE YEAR; AND 2. PROMPTLY REPORTING ALL CRASHES ATTRIBUTED TO THE ALLEGED DEFECT. THIS INVESTIGATION IS CLOSED BASED UPON THE ACTIONS TAKEN BY VW.THE CLOSING OF THIS INVESTIGATION DOES NOT C
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
Illustration