IllustrationABS LIGHT CAME ON. *TR
2001 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 2001 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
6325–50K
7150–75K
4475–100K
38100–150K
22150K+
280 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports14 fire reports11 injury reports
Service Brakes, Hydraulic complaints
48 reportsTL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE ABS WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND A TECHNICIAN ADVISED HIM THAT THE ABS WAS NOT FUNCTIONING. THE REPAIR WOULD COST A MINIMUM OF $1,000.00. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE MANUFACTURER…
Read full complaint
TL*THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE ABS WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND A TECHNICIAN ADVISED HIM THAT THE ABS WAS NOT FUNCTIONING. THE REPAIR WOULD COST A MINIMUM OF $1,000.00. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE CURRENT MILEAGE WAS APPROXIMATELY 99,000. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
I BROUGHT MY VEHICLE INTO FIRESTONE FOR A ROUNTINE TUNE-UP AND TO REPLACE MY AXLE. BECAUSE OF FIRESTONES MIS-DIAGNOSIS OF THE TUNE-UP, THEY DETERMINED IT WAS THE ENGINE COIL. MY VEHICLE HAD TO BE TOWED TO AUDI OF BROOKLINE FOR A COMPLETE DIAGNOSTIC AND THEY FOUND THIS.....A PRE-EXISTING CONDITION - E.C.M..THE ENGINE COIL WAS ONL…
Read full complaint
I BROUGHT MY VEHICLE INTO FIRESTONE FOR A ROUNTINE TUNE-UP AND TO REPLACE MY AXLE. BECAUSE OF FIRESTONES MIS-DIAGNOSIS OF THE TUNE-UP, THEY DETERMINED IT WAS THE ENGINE COIL. MY VEHICLE HAD TO BE TOWED TO AUDI OF BROOKLINE FOR A COMPLETE DIAGNOSTIC AND THEY FOUND THIS.....A PRE-EXISTING CONDITION - E.C.M..THE ENGINE COIL WAS ONLY A SYMPTOM OF THE BIGGER PROBLEM IN THE FAULTY E.C.M. MISFIRING. PRIOR TO BRINGING MY VEHICLE INTO FIRESTONE, IT WAS OPERABLE. BECAUSE OF THEIR TAMPERING WITH THE IGNITION COILS; MY VEHICLE WAS SUBSEQUENTLY DESTROYED. REGARDING THE DIAGNOSTIC REPORT, THE CURRENT AND PASSED CONDITION OF MY VEHICLE, WHICH IS NORMALLY A HEALTHY, SAFE, VEHICLE, IS AS FOLLOWS: "FUEL DELIVERY INSPECTION AT PRESENT TIME, IGNITION SYSTEM CHECK, AND POWER PROVIDED TO COILS TECH FOUND NO COMMUNICATION BETWEEN ENGINE CONTROL MODULE (E.C.M.) AND A.B.S. CONTROL MODULE BECAUSE A.B.S. CONTROL MODULE WAS DISCONNECTED. RECONNECT AND ACCESS A.B.S. SYSTEM AND FAULT DETECTED CUSTOMER AWARE OF THE A.B.S. PROBLEM AND WARNING HAS BEEN ON FOR A WHILE. THAT IS TRUE, AND NOT THE REASON FOR THIS LETTER. CONTINUED: FOUND E.C.M. FAULT FOR #3 IGNITION COIL OPEN CIRCUIT. PIN CHECK WIRES ON #3 IGNITION COIL PLUG #3 POST FROM CONNECTOR TO E.C.M. FOUND HEIGHT RESISTANCE IN WIRE, REPLACED #3 CONNECTOR AND RE-TESTED OK. ALSO CLEAN AND REPLACE TERMINAL ON TOP OF VALVE COVER FOR PROPER GROUND. START ENGINE AND ROAD TEST VEHICLE, FOUND ENGINE MISFIRE ON #1, #2, #3, #4 IGNITION COILS". I HAVE TO REPLACE ALL 4 IGNITION COILS, CATAYLTIC CONVERTER, AND E.C.M. THIS IS THE SECOND IGNITION COIL REPLACED IN THE 1 YEAR I'VE OWNED THE VEHICLE. THIS CAR HAS MORE MECHANICAL ERRORS THAN IMAGINABLE. THE ESTIMATED COST OF REPAIRS IS IN THE THOUSANDS. I CAN'T AFFORD TO MAINTENANCE THIS TEMPERMENATL VEHICLE. I WILL HAVE TO JUNK THE CAR. I REFUSE TO FIX THIS VEHICLE. PUSHING FOR A RECALL!! *TR
FAILURE OF THE ABS CONTROL MODULE IN MY 2001 VW PASSAT. *TR
BRAKE ALARM LIGHT ON ALL THE TIME AND FLASHING ABS LIGHT AS WELL AS STOP. BRAKES HAVE BEEN CHECKED AND ARE FINE. DEALER SAYS IT NEEDS A REPLACEMENT ABS CONTROL MODULE - $1800. HAVE BEEN RESEARCHING THIS PROBLEM AND MANY OWNERS OF VW'S AND AUDIS IN MY YEAR RANGE HAVING SAME PROBLEM. *TR
FAILED ABS MODULE AT 120,000 MILES. TYPICALLY A $1000+ REPAIR. *TR
THE ABS LIGHT AND A BRAKE LIGHT ARE ON ON MY 2001 VOLKSWAGEN PASSAT FOR THE LAST EIGHT MONTHS. I HAVE BEEN SEARCHING AND LOOKS LIKE THERE HAS BEEN A LOT OF COMPLAINTS FOR THIS SAME PROBLEM. *TR
THE BRAKE LIGHTS ON MY 2001 VW PASSAT STOPPED WORKING. I CHECKED THE FUSES AND THE LIGHT BULBS; AND BOTH THE FUSES AND BULBS ARE GOOD. VW OF AMERICA RECALLED SEVERAL VW MODELS IN 2007 FOR BRAKE LIGHT FAILURE DUE TO A FAULTY BRAKE LIGHT SWITCH. HOWEVER VW OF AMERICA DID NOT RECALL THE PASSAT. I WHEN ON LINE TO A VW BLOG; AND FOUN…
Read full complaint
THE BRAKE LIGHTS ON MY 2001 VW PASSAT STOPPED WORKING. I CHECKED THE FUSES AND THE LIGHT BULBS; AND BOTH THE FUSES AND BULBS ARE GOOD. VW OF AMERICA RECALLED SEVERAL VW MODELS IN 2007 FOR BRAKE LIGHT FAILURE DUE TO A FAULTY BRAKE LIGHT SWITCH. HOWEVER VW OF AMERICA DID NOT RECALL THE PASSAT. I WHEN ON LINE TO A VW BLOG; AND FOUND LOTS OF OTHER VW PASSAT OWNERS WHO HAVE THE SAME PROBLEM WITH THEIR BRAKE LIGHTS. I ALSO FOUND OUT THAT VW WILL NOT REPLACE THE BRAKE LIGHT SWITCH FREE OF CHARGE ON THE PASSAT, BECAUSE THE PASSAT WAS NOT RECALLED. I WILL HAVE TO PAY OUT OF POCKET TO GET MY PASSAT REPAIRED. *TR
ABS MODULE FAULTY IN 2001 PASSAT STATION WAGON; BRAKE FAULT/ABS WARNING LIGHTS CAME ON REPEATEDLY. *TR
ABS ALARM GOES ON WITH INCREASING FREQUENCY. SAYS THAT THERE IS A BRAKE FAULT. BRAKES ARE APPARENTLY FINE, BUT THE PROBLEM IS WITH THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL UNIT. WHEN THIS ALARM IS ON, THE ABS MAY NOT BE WORKING. MANY PEOPLE REPORT THE SAME PROBLEM IN VW'S AND AUDI'S. *TR
Official recalls
308V156000 · Fuel System, Gasoline:delivery
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).