IllustrationDT*: THE CONTACT STATED AN INDEPENDENT MECHANIC DETERMINED THE VEHICLE HAD OIL LEAKS FROM EVERY SEAL AND GASKET. OIL WAS ALL OVER THE ENTIRE BOTTOM OF THE VEHICLE. THE DEALERSHIP WAS NOT CONTACTED.
2001 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 2001 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
420–25K
6325–50K
7150–75K
4475–100K
38100–150K
22150K+
280 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports14 fire reports11 injury reports
Engine And Engine Cooling complaints
92 reports2001 VOLKSWAGEN PASSAT COOLANT WARNING LIGHT ILLUMINATED AND ENGINE SHUT OFF. ONCE THE VEHICLE WAS RESTARTED IT RAN AT REDUCED POWER. UPON INSPECTION MECHANIC DETERMINED THERE WAS A FAULTY SENSOR IN THE COOLING JACKET. *KB MOISTURE INVADED THE SENSOR, MIGRATED UP THE WIRING HARNESS AND DESTROYED THE COMPUTER WHICH MANAGED ALL …
Read full complaint
2001 VOLKSWAGEN PASSAT COOLANT WARNING LIGHT ILLUMINATED AND ENGINE SHUT OFF. ONCE THE VEHICLE WAS RESTARTED IT RAN AT REDUCED POWER. UPON INSPECTION MECHANIC DETERMINED THERE WAS A FAULTY SENSOR IN THE COOLING JACKET. *KB MOISTURE INVADED THE SENSOR, MIGRATED UP THE WIRING HARNESS AND DESTROYED THE COMPUTER WHICH MANAGED ALL ENGINE FUNCTIONS. THE CONSUMER WAS BILLED $3200. THE TECHNICIAN AT THE DEALER EXPLAIN THAT THIS WAS NOT AN UNCOMMON FAILURE. THE CONSUMER CONTACTED THE MANUFACTURER BUT THEY REFUSED TO PROVIDE ANY ASSISTANCE. *NM
WE HAVE A 2001 PASSAT AND PUT ABOUT 10K MILES/YEAR. THE CAR HAS BEEN SERVICED ABOUT TWICE EVERY YEAR AT OUR LOCAL VW DEALERSHIP SINCE WE BOUGHT IT NEW. WE ORIGINALLY BOUGHT THE CAR WITH SAFETY IN MIND. WHILE DRIVING ON THE INTERSTATE ABOUT A WEEK AGO, THE ENGINE LIGHT CAME ON. THE CAR SEIZED/STALLED AS I WAS GETTING OFF THE …
Read full complaint
WE HAVE A 2001 PASSAT AND PUT ABOUT 10K MILES/YEAR. THE CAR HAS BEEN SERVICED ABOUT TWICE EVERY YEAR AT OUR LOCAL VW DEALERSHIP SINCE WE BOUGHT IT NEW. WE ORIGINALLY BOUGHT THE CAR WITH SAFETY IN MIND. WHILE DRIVING ON THE INTERSTATE ABOUT A WEEK AGO, THE ENGINE LIGHT CAME ON. THE CAR SEIZED/STALLED AS I WAS GETTING OFF THE INTERSTATE. THIS COULD EASILY HAVE LED TO A SERIOUS ACCIDENT. I HAD THE CAR TOWED TO OUR DEALERSHIP. ONCE THEY REALIZED WHAT HAD HAPPENED, THEY BECAME VERY HOSTILE. THEY ASKED US FOR ALL OF OUR RECORDS. THEY HAD INCOMPLETE ONES FOR US AS THE DEALERSHIP HAD CHANGED HANDS A FEW YEARS AGO. WE HAVE ALMOST EVERY RECORD BUT THIS WILL NOT SUFFICE FOR THEM. THEY ARE ASKING FOR HALF OF THE 11K REPAIR BILL (AND SUGGESTED THAT WE REPAIR IT AND TRADE IN FOR ONE OF THEIR USED CARS). WHAT REALLY BOTHERS US IS THAT PART OF THE PROBLEM OF MISSING RECORDS IS DUE TO THE DEALERSHIP. THE OTHER ISSUE IS THAT WHEN THE CAR HAD FAILED, THE TOW GUY SHOWED ME THAT THE OIL CAP WAS ENCRUSTED WITH SLUDGE. WHEN I POINTED THIS OUT TO THE DEALERSHIP AND THAT WHILE THEY PROBABLY WOULD HAVE SEEN THIS AT THE LAST OIL CHANGE, THAT THEY ARE UNDER NO OBLIGATION TO INFORM THE CUSTOMER OF SUCH A POTENTIAL HAZARD. THIS IS A MAJOR SAFETY CONCERN AND VW/VW DEALERSHIPS SHOULD BE OBLIGED TO WATCH FOR THIS AND AT LEAST SUGGEST AN ENGINE FLUSH. AFTER TOO MUCH TRUST, WE ARE VERY DISAPPOINTED WITH VW FOR THIS. THEY SHOULD KNOW BETTER. *JB
MECHANIC REFUSES TO REPAIR 2001 PASSAT ELECTRONIC CONTROL SYSTEM. *TS THE CONSUMER STATED THE PROBLEM HAD BEEN MIS-DIAGNOSED ON MORE THAN ONE OCCASION. THE VEHICLE HAD AN OIL HOSE LEAK. *JB
MY 2001 PASSAT------MY HUSBAND AND I WERE DRIVING ON THE FREEWAY, THE STOP ENGINE LIGHT APPEARED IN BIG RED LETTERING AND PROCEEDED TO SAY THAT THE OIL PRESSURE WAS LOW. WE GOT TO A GAS STATION AND CHECKED THE OIL AND IT LOOKED FINE. GOT HOME AND LOOKED AGAIN WITH BETTER LIGHTING, STILL THE SAME. WE HAD THE VEHICLE TOWED TO THE …
Read full complaint
MY 2001 PASSAT------MY HUSBAND AND I WERE DRIVING ON THE FREEWAY, THE STOP ENGINE LIGHT APPEARED IN BIG RED LETTERING AND PROCEEDED TO SAY THAT THE OIL PRESSURE WAS LOW. WE GOT TO A GAS STATION AND CHECKED THE OIL AND IT LOOKED FINE. GOT HOME AND LOOKED AGAIN WITH BETTER LIGHTING, STILL THE SAME. WE HAD THE VEHICLE TOWED TO THE DEALERSHIP. THERE THE SERVICE CENTER HAD TOLD US THAT THIS WAS DUE TO "OIL SLUDGE" AND WILL BE COVERED UNDER OUR EXTENDED WARRANTY IF DOCUMENTATION WAS PROVIDED FOR ALL OIL CHANGE SERVICES. NOT TO MENTION THE VEHICLE WAS PURCHASE IN 2001 WITH 6 MILES AND HAS ONLY GOT 53000 NOW IN 2006. I HAVE GOTTEN THE ROUTINE OIL CHANGES UP TO DATE AND THEY ARE REQUIRING ME TO SHOW PROOF OF ALL OIL CHANGES. I WOULD LIKE TO KNOW WHO KEEPS EVERY OIL CHANGE RECEIPT!!! THIS IS INSANE. I AM SO FED UP WITH THE WAY VW IS TAKING CARE OF THIS ISSUE, THEY ARE USING THIS AS AN EXCUSE SO THAT THEY DO NOT HAVE TO REPAIR MY VEHICLE. I AM STILL IN THE PROCESS OF TRYING TO FIND ALL THE "DOCUMENTATION" THAT IS NEEDED. I CAN NOT BELIEVE THAT LESS THAN 3 WEEKS OF MY LAST OIL CHANGE VW STILL WILL NOT PROVIDE ME WITH MODERATE SERVICE. I WILL NEVER, REPEAT NEVER BUY ANOTHER VEHICLE OR RECOMMEND VW TO ANYONE!! I HAVE READ ALL OTHER SIMILAR COMPLAINTS AND I CAN SEE THAT VW HAS NO REMORSE FOR THE FISHY SERVICE IT IS PROVIDING. I WILL TAKE THIS ACTION FURTHER. I JUST WONDER HOW MANY PEOPLE GOT THERE VEHICLES WITH THE "SLUDGE" COVERED UNDER WARRANTY??? WHY EVEN PURCHASE THE WARRANTY IF IT IS NOT COVERING THE PROBLEM??? *JB
ALL BOLTS HOLDING COMPRESSOR IN PLACE BROKE. *NM
MY 2001 VOLKSWAGEN PASSAT NEEDS A NEW ENGINE BECAUSE IT IS FILLED WITH SLUDGE. AFTER RESEARCHING THIS ON MY OWN I FOUND THAT THIS IS A COMMON PROBLEM WITH THE 1.8T ENGINE. VW ISSUED AN EXTENDED WARRANTY ON THAT ENGINE PROVIDED THE CONSUMER CAN PRODUCE OIL CHANGE RECEIPTS SHOWING THE CAR WAS MAINTAINED ACCORDING TO THE OWNERS MAN…
Read full complaint
MY 2001 VOLKSWAGEN PASSAT NEEDS A NEW ENGINE BECAUSE IT IS FILLED WITH SLUDGE. AFTER RESEARCHING THIS ON MY OWN I FOUND THAT THIS IS A COMMON PROBLEM WITH THE 1.8T ENGINE. VW ISSUED AN EXTENDED WARRANTY ON THAT ENGINE PROVIDED THE CONSUMER CAN PRODUCE OIL CHANGE RECEIPTS SHOWING THE CAR WAS MAINTAINED ACCORDING TO THE OWNERS MANUAL. I SENT THEM THE PROPER RECEIPTS SHOWING MY CAR WAS MAINTAINED PROPERLY AND THEY STILL DENIED ME. MY CAR ONLY HAS ABOUT 43,000 MILES ON IT AND I JUST BOUGHT IT 10 MONTHS AGO. *JB
MY 2001 VOLKSWAGEN PASSAT HAD A TIMING BELT FAILURE DUE TO AN INTERNAL COMPONENT THAT CAUSED THE CAR TO JUST TURN OFF. THIS BELT DID NOT FAIL, BUT THE COMPONENT DID WHICH CAUSED IT TO FAIL. HERE IS THE CONCERN: JUST THINK IF YOU ARE TRAVELING IN BUMPER TO BUMPER TRAFFIC AND THIS PART FAILS, YOU ARE ALL DONE. YOU LOSE THE CAR, …
Read full complaint
MY 2001 VOLKSWAGEN PASSAT HAD A TIMING BELT FAILURE DUE TO AN INTERNAL COMPONENT THAT CAUSED THE CAR TO JUST TURN OFF. THIS BELT DID NOT FAIL, BUT THE COMPONENT DID WHICH CAUSED IT TO FAIL. HERE IS THE CONCERN: JUST THINK IF YOU ARE TRAVELING IN BUMPER TO BUMPER TRAFFIC AND THIS PART FAILS, YOU ARE ALL DONE. YOU LOSE THE CAR, NOTHING IS AVAILABLE TO GET YOU OVER TO A SAFE SPOT. ITS JUST A MATTER OF TIME WHEN SOMEONE IS TRAVELING AND THIS HAPPENS. NOTE - VOLKSWAGEN IS AWARE OF THIS ISSUE AND OFFERS A UPGRADE KIT TO REPLACE THIS PART. ALSO, NO WHERE IN THEIR SERVICE GUIDE LINES WILL YOU BE ABLE TO DETECT THIS PART THROUGH THE TECHS. I'M HOPING BY SUBMITTING THIS WE MAKE THEM ACCOUNTABLE AND TO CORRECT THIS ISSUE. I DO HAVE THE BELT WHICH SHOWS THAT IT DID NOT FAIL AS THEY PITCHED IT.*AK
PURCHASED THE VEHCILE (SECOND-HAND) FROM THE LEXUS DEALERSHIP ON VETERANS DRIVE IN METAIRIE,LA BACK IN MARCH 2004. HERE IS MY COMPLAINT: MY FAMILY EVACUATED FOR HURRICANE 'KATRINA' AND WE LEFT THE VW BEHIND AT THE HOUSE. WELL, IT SAT FOR ABOUT A MONTH. ONCE WE GOT BACK TO THE VEHICLE, WE NOTICED IT WAS NOT RUNNING GOOD A…
Read full complaint
PURCHASED THE VEHCILE (SECOND-HAND) FROM THE LEXUS DEALERSHIP ON VETERANS DRIVE IN METAIRIE,LA BACK IN MARCH 2004. HERE IS MY COMPLAINT: MY FAMILY EVACUATED FOR HURRICANE 'KATRINA' AND WE LEFT THE VW BEHIND AT THE HOUSE. WELL, IT SAT FOR ABOUT A MONTH. ONCE WE GOT BACK TO THE VEHICLE, WE NOTICED IT WAS NOT RUNNING GOOD AT ALL. VERY ROUGH. VERY DIFFERENT THAN BEFORE THE STORM. I CHECKED THE CAR OUT AND FOUND OUT IT WAS VERY LOW ON OIL. YET, WE HAVE NO OIL LEAKS. I COULD NOT EXPLAIN WHERE THE OIL HAD GONE. AND THE OIL IN THE CASE OF THE VEHICLE LOOKED "GRAINY" AND "SLUDGEY". WE THOUGHT IT WAS STORM RELATED AND FILED A CLAIM WITH STATE FARM. WE THEN TOOK IT TO THE LOCAL VW DEALER NEAR MY OFFICE TO HAVE TO LOCATE THE PROBLEM. THE VW SERVICE GUY SAID, YES, VOLKSWAGEN HAS IDENTIFIED A MECHANICAL PROBLEM WITH OUR MODEL VEHICLE WHERE THE TURBO CAN NOT HANDLE CONVENTIONAL MOTOR OIL. THEY WOULD FIX THAT FREE OF CHARGE....HOWEVER, THEY NEED THE LAST 12 MONTH HISTORY OF OUR OIL CHANGES. WELL, AT FIRST I THOUGHT THIS WOULD BE NO PROBLEM. WE HAVE ALWAYS GOTTEN OUR REGULAR OILL CHANGES SO THE RECEIPTS SHOULD BE HANDY. WELL, I DIDN'T TAKE INTO ACCOUNT THAT THE DESTRUCTION OF OUR NEW ORLEANS HOME BY HURRICANE KATRINA. OUR HOUSE WAS A TOTAL LOSS AND SO WERE THOSE RECEIPTS. I THINK WE MANAGED TO GET OUR HANDS ON TWO OF THEM. WELL, THAT'S NOT GOOD ENOUGH FOR VW. AS A MATTER OF FACT, THEY WON'T EVEN TAKE HAND-WRITTEN RECEIPTS FROM THE OIL CHANGE PLACES. I AM EXTREMELY ANGRY THAT THEY WILL NOT FIX AN EXISTING PROBLEM WITH THEIR VEHICLE WITHOUT THIS INFORMATION. THEY ACKNOWLEDGE THE FACT THAT IT'S THE VEHICLE MECHANISMS BUT THEY REFUSE TO FIX IT WITHOUT COPIES OF RECEIPTS I CAN NEVER PRODUCE. ALL OF NEW ORLEANS WAS DESTROYED. NOW, MY WIFE, WHO HAS TO COMMUTE 50 MILES EACH WAY TO WORK, HAS TO DRIVE HER UNSAFE VEHICLE AND ENDANGER HER LIFE BECAUSE VW REFUSES TO FIX A PROBLEM THEY ADMIT THEIR CAR HAS. WE HAVE NO RECOURSE BUT TO FILE THIS COMPLAINT WITH THE NHTSA. *NM
OIL PUMP FAILURE: THE WARNING LIGHT TURNED ON "STOP, OIL PRESSURE LOW" CONTACTED VW AND WAS TOLD THAT I NEEDED TO BRING THE CAR IN FOR AN INSPECTION. IT WAS DETERMINED THAT THERE WAS A SLUDGE BUILD UP IN THE OIL WHICH CAUSED THE OIL PUMP TO FAIL. RECENTLY VW HAS ISSUED A NEW WARRANTY FOR THE REPLACEMENT OF THE OIL PUMP DUE TO…
Read full complaint
OIL PUMP FAILURE: THE WARNING LIGHT TURNED ON "STOP, OIL PRESSURE LOW" CONTACTED VW AND WAS TOLD THAT I NEEDED TO BRING THE CAR IN FOR AN INSPECTION. IT WAS DETERMINED THAT THERE WAS A SLUDGE BUILD UP IN THE OIL WHICH CAUSED THE OIL PUMP TO FAIL. RECENTLY VW HAS ISSUED A NEW WARRANTY FOR THE REPLACEMENT OF THE OIL PUMP DUE TO THIS PROBLEM, ONLY IF YOU HAVE YOUR OIL RECEIPTS FROM DAY ONE. I WISH TO KEEP MY VW FOR A LONG TIME AND YES OIL WAS CHANGED ON A REGULAR BASIS, HOWEVER RECEIPTS ARE DIFFICULT TO FIND FROM DAY ONE. FROM MY FINDINGS AND WHAT MAKES SENSE IS THAT THE TURBO IS OVER HEATING THE OIL AND BUILDING UP A SLUDGE IN THE OIL. AS OF TODAY MY PUMP WAS REPLACED ALONG WITH THE CAM. THE DEALERSHIP DID THE NECESSARY WORK BUT HAS NOT REALLY INFORMED ME AS TO ANY FUTURE PROBLEMS THAT WILL ARISE. WHERE AS OTHER OIL REPAIR SHOPS KNOW OF VW WITH TURBO THAT HAVE FAILED AT 20,000 MILES AND THEN AGAIN AT 40,000 MILES. AS OF TODAY I QUESTION IF THE TURBO WAS INSPECTED FOR SLUDGE OR WAS AN OIL FLUSH DONE. *JB
Official recalls
308V156000 · Fuel System, Gasoline:delivery
Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V026000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Jan 25, 2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).