NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Air complaints
29 reportsClear category filterMileage unknown · Jun 1, 2005
Service Brakes, Air
ABS LIGHT CAME ON, I TOOK IT TO AN INDEPENDENT VW MECHANIC AND WAS TOLD THE ABS CONTOL UNIT HAD FAILED AND THEREFORE THE ABS WOULD NOT FUNCTION. COST OF REPAIR $1500-$2000. AFTER RESEARCHING ON VW FORUMS I HAVE LEARNED THAT MANY PASSAT OWNERS HAVE THIS SAME PROBLEM. VW CUSTOMER CARE THANKED ME FOR CALLING AND THEY WOULD NOTE …
Read full complaint
ABS LIGHT CAME ON, I TOOK IT TO AN INDEPENDENT VW MECHANIC AND WAS TOLD THE ABS CONTOL UNIT HAD FAILED AND THEREFORE THE ABS WOULD NOT FUNCTION. COST OF REPAIR $1500-$2000. AFTER RESEARCHING ON VW FORUMS I HAVE LEARNED THAT MANY PASSAT OWNERS HAVE THIS SAME PROBLEM. VW CUSTOMER CARE THANKED ME FOR CALLING AND THEY WOULD NOTE THE PROBLEM.
NHTSA ODI #10123858
93,000 miles · Jun 1, 2005
Service Brakes, Air
FAILIURE OF ABS BRAKE MODULE ON A 2000 VW PASSAT (PN 8E0614111AH). MODULE FAILURE CAUSES REAR WHEELS TO LOCK DURING EMERGENCY BRAKING SITUATIONS.
NHTSA ODI #10123792
85,000 miles · May 29, 2005
Service Brakes, Air
(1) MY CAR IS A DAILY DRIVER. 2000 VW PASSAT GLS, 1.8T AUTO. (2) ABS MODULE DIED AT AROUND 85K, ABS NO LONGER WORKS AS A RESULT. APPARENTLY THIS HAS HAPPENED TO A LOT OF OTHER PASSAT OWNERS AS WELL. (3) I HAVE NOT CORRECTED THE FAILURE AS OF YET AS IT IS A VERY COSTLY REPAIR FROM THE VW DEALER. AROUND $1,500.00.
NHTSA ODI #10122406
52,600 miles · May 28, 2005
Service Brakes, Air
AS I WAS DRIVING ALONG I NOTICED MY BRAKES WHERE GETTING SPONGY. DROVE IT A LITTLE MORE, AND THE BRAKE LIGHT CAME ON AND WAS FLASHING . PULLED INTO THE CLOSEST PARKING LOT, CHECKED UNDER THE HOOD AND NOTICED BRAKE FLUID DRIPPING FROM THE ABS UNIT, AND THAT THE BRAKE RESERVOIR WAS BELOW THE MINIMUM LINE. HAD IT TOWED TO THE DEA…
Read full complaint
AS I WAS DRIVING ALONG I NOTICED MY BRAKES WHERE GETTING SPONGY. DROVE IT A LITTLE MORE, AND THE BRAKE LIGHT CAME ON AND WAS FLASHING . PULLED INTO THE CLOSEST PARKING LOT, CHECKED UNDER THE HOOD AND NOTICED BRAKE FLUID DRIPPING FROM THE ABS UNIT, AND THAT THE BRAKE RESERVOIR WAS BELOW THE MINIMUM LINE. HAD IT TOWED TO THE DEALER AND THEY HAD TO REPLACE THE ABS MODULE. MY CAR IS A 2000 VW PASSAT WITH 52,600 MILES
NHTSA ODI #10122393
94,395 miles · May 26, 2005
Service Brakes, Air
ABS LIGHTS ARE REPORTING FAILURE BUT BRAKE ACTIVITY APPEARS OKAY. DEALER SAYS NEW MODULE WILL BE NEEDED TO FIX PROBLEMS AT A COST OF $1,500. LOOKING FOR OPTIONS TO REPLACE/REBUILD ABS MODULE DUE TO EXPENSE OF TOTAL REPLACEMENT. BELIEVE NUMBER OF COMPLAINTS FOUND ON INTERNET SHOULD RESULT IN MANUFACTURER RECALL.
NHTSA ODI #10122235
85,000 miles · May 20, 2005
Service Brakes, Air
MANY AUDI AND VW MODELS MANUFACTURED STARTING IN THE LATER '90S AND CONTINUING TO PRESENT, USE THE BOSCH 5.3 ABS CONTROLLER, WHICH IS PRONE TO CATASTROPHIC FAILURE, OSTENSIBLY DUE TO DEFECTIVE DESIGN. THIS MODULE CONTROLS MULTIPLE BRAKE-RELATED FUNCTIONS INCLUDING THE ABS WHICH IS IMPORTANT FOR WINTER DRIVING, BUT THE MOST CRITI…
Read full complaint
MANY AUDI AND VW MODELS MANUFACTURED STARTING IN THE LATER '90S AND CONTINUING TO PRESENT, USE THE BOSCH 5.3 ABS CONTROLLER, WHICH IS PRONE TO CATASTROPHIC FAILURE, OSTENSIBLY DUE TO DEFECTIVE DESIGN. THIS MODULE CONTROLS MULTIPLE BRAKE-RELATED FUNCTIONS INCLUDING THE ABS WHICH IS IMPORTANT FOR WINTER DRIVING, BUT THE MOST CRITICAL FUNCTION OF THIS MODULE IS PROBABLY THE ELECTRONIC BRAKE FORCE DISTRIBUTION, OR EBD. THESE VEHICLES ARE DESIGNED SUCH THAT IF THE EBD IS INOPERATIVE, THE PROPORTION OF HYDRAULIC FORCE APPLIED TO THE REAR BRAKES DURING EMERGENCY BRAKING IS AS GREAT AS IT IS DURING MODERATE BRAKING EFFORT WHEN THERE IS MINIMAL TRANSFER OF VEHICLE WEIGHT TO THE FRONT WHEELS. THE EBD IS SUPPOSED TO ADJUST THE FRONT/REAR BRAKING DISTRIBUTION DYNAMICALLY ACCORDING TO THE MEASURE OF THE DECELERATION, SO THAT THE REAR WHEELS WILL NOT LOCK UP DURING EMERGENCY BRAKING. IF THIS MODULE SHOULD FAIL DURING EMERGENCY BRAKING ON DRY PAVEMENT, THE REAR WHEELS COULD LOCK UP AND CAUSE AN ACCIDENT WHICH COULD EASILY INCLUDE FATALITIES. THIS IS AN EXPENSIVE REPAIR FOR OWNERS, COSTING ROUGHLY $2000, AND MANY OWNERS HAVE PROBABLY PUT OFF THE REPAIR INDEFINITELY. EVIDENCE WHICH CAN BE FOUND THROUGH A SIMPLE WEB SEARCH, SUGGESTS THAT THE PROBLEM IS WIDESPREAD, AND THAT IF IT HAS NOT ALREADY LED TO SERIOUS ACCIDENTS, IT IS ONLY A QUESTION OF TIME. THIS PROBLEM IS GENUINE, AND VW/AUDI SHOULD BE COMPELLED TO TAKE IMMEDIATE CORRECTIVE ACTION.
NHTSA ODI #10121715
51,000 miles · Apr 29, 2005
Service Brakes, Air
ABS UNIT; ) FLASHING ABS AND BRAKE LIGHT IN CAR; 2)ABS WILL NOT WORK 3) I WILL HAVE TO REPLACE THE UNIT, THROUGH THE DEALER THE UNIT NEW COSTS APPROX $1200.00. 2000 VOLKSWAGON, PASSAT 2.8L. *AK
NHTSA ODI #10118665
68,615 miles · Mar 24, 2005
Service Brakes, Air
I AM ADDING MY VOICE TO THE LIST OF VW OWNERS HAVING TROUBLE WITH THEIR ABS MODULES. THE ELECTRONIC ABS SENSER HAD FAILED AND CAUSED THE DASH LIGHTS TO STAY ON CONSISTENTLY FOR TWO WEEKS NOW AND WILL REQUIRE A REPLACEMENT TO FIX. MEANWHILE I AM LEFT WITHOUT ABS AND FACE THE POTENTIAL OF A SERIOUS ACCIDENT IF I HAVE TO HARD BRA…
Read full complaint
I AM ADDING MY VOICE TO THE LIST OF VW OWNERS HAVING TROUBLE WITH THEIR ABS MODULES. THE ELECTRONIC ABS SENSER HAD FAILED AND CAUSED THE DASH LIGHTS TO STAY ON CONSISTENTLY FOR TWO WEEKS NOW AND WILL REQUIRE A REPLACEMENT TO FIX. MEANWHILE I AM LEFT WITHOUT ABS AND FACE THE POTENTIAL OF A SERIOUS ACCIDENT IF I HAVE TO HARD BRAKE TO AVOID AN ACCIDENT. I FIND THIS PROBELM ABSOLUTELY UNACCEPTABLE AND VW OF NORTH AMERICAN NEEDS TO TAKE SOME RESPONSIBILITY FOR THE PROBLEM. E.G. REPLACE THE DEFECTIVE PART!
NHTSA ODI #10114643
57,000 miles · Mar 17, 2005
Service Brakes, Air
WHILE DRIVING 55 MPH THE BRAKE LIGHT AND ABS LIGHT FLASHED AND A STOP CAR MESSAGES APPEARED ON THE INSTRUMENT PANEL. VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT THE ABS MODULE NEEDED TO BE REPLACED.*AK
NHTSA ODI #10115352
72,000 miles · Feb 28, 2005
Service Brakes, Air
ABS CONTROL UNIT AND PUMP FAILURE ON VW PASSAT 2000 @ 72K MILES. THIS IS NOT A STANDARD FAILURE IN MY MIND. THE CAR HAS NEVER BEEN IN AN ACCIDENT AND IT JUST OCCURED. SHOULD BE A RECALL ITEM FROM VW.
NHTSA ODI #10112319
NHTSA investigations
7EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
PE07024 · Passenger/engine Compartment Fires
Opened May 10, 2007 · Closed Sep 28, 2007
Status: closed (inferred from source dates) · Electrical System:ignition
MANY OF THE FIRE REPORTS ALLEGE THAT THE VEHICLE FIRE WAS ATTRIBUTED TO IGNITION COIL FAILURE.VW PROVIDED ADDITIONAL DATA REGARDING ITS ANALYSIS OF VEHICLE FIRES AND A DETAILED DESCRIPTION OF THE THREE DIFFERENT ENGINES AND IGNITION SYSTEMS FOR THE SUBJECT VEHICLES.ODIFINDS THE NEED TO FURTHER INVESTIGATE THIS ISSUE.TO FACILITATE ACQUISITION AND ANALYSIS OF ADDITIONAL INFORMATION, THIS INVESTIGATIONHAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-014).
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03020 · Passenger Air Bag Lid Failure
Opened Oct 7, 2003 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Additional source detail variants (2)
Air Bags:frontal
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
Air Bags
THIS INVESTIGATION INVOLVES THE VOLKSWAGEN (VW) PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) LID UTILIZED IN MY 1998-2002 VW PASSAT.THE PSIR LID MAY DETACH FROM THE INSTRUMENT PANEL DURING AIR BAG DEPLOYMENT.THE OFFICE OF DEFECTS INVESTIGATION (ODI) OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) OPENED THE PRELIMINARY EVALUATION ON MAY 23, 2003 TO DETERMINE WHETHER ALLEGED PSIR LID DETACHMENT PRESENTS AN UNREASONABLE SAFETY RISK TO PASSENGERS IN THE VEHICLE.ODI?S INVESTIGATION REVEALS THAT DETACHMENT OF THE PSIR LID DURING AIR BAG DEPLOYMENT MAY OCCUR FOR TWO REASONS: 1) THE SHAPE OF THE PSIR LID, AND THE LENGTH OF THE ATTACHING TETHER, MAY SNAG THE AIR BAG DURING DEPLOYMENT APPLYING ADDITIONAL PRESSURE ON BOLTS THAT FASTEN THE LID TO THE INSTRUMENT PANEL (IP); AND/OR 2) THE ORIGINAL PSIR LID DESIGN (SUBJECT VEHICLES) UTILIZED SIX GRADE 4.8 MM CARBON STEEL TACK WELD BOLTS WHICH MAY NOT BE AS STRONG AS THE NEW DESIGN PSIR LID CONSISTING OF SIX GRADE 8.8 MM CARBON STEEL PRESS BOLTS THAT ARE HEAT TREATED.ODI CONCLUDES THAT DETACHMENT OF THE PSIR LID IS A DEFECT BECAUSE THE LID SHOULD REMAIN ATTACHED TO THE IP AFTER DEPLOYMENT OF THE AIRBAG.HOWEVER, AFTER ANALYZING VW?S RESPONSES, AND TEST DATA COLLECTED BY VW AND FAURECIA, THE PSIR LID SUPPLIER, ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND BECAUSE A DETACHED PSIR LID AND PARTS DO NOT PROJECT TOWARDS A PASSENGER DURING DEPLOYMENT OF THE AIRBAG.THE TEST DATA SHOWS THAT THE AIRBAG PUSHES A DETACHED PSIR LID UPWARDS INTO THE WINDSHIELD DURING DEPLOYMENT, AND AWAY FROM THE PASSENGER COMPARTMENT.IT IS HIGHLY UNLIKELY THAT A PASSENGER WOULD CONTACT THE PSIR LID OR ASSOCIATED PARTS DURING AIR BAG DEPLOYMENT.THEREFORE THIS ENGINEERING ANALYSIS (EA 03-020) IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. FOR A DETAILED DISCUSSION OF THE PSIR LID AND TESTING, SEE THE ATTACHED REPORT.
PE03021 · Passenger Sir Door Mounting Stud Failure
Opened May 23, 2003 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
ODI OPENED A PRELIMINARY EVALUATION (PE03-021) BASED ON TWO REPORTS OF FAILED BOLT STUDS THAT ATTACH THE PASSENGER SUPPLEMENTAL INFLATABLE RESTRAINT (PSIR) DOOR COVER TO THE INSTRUMENT PANEL (IP) ON THE VOLKSWAGEN (VW) PASSAT (MODEL YEARS 2000, 2002).VW HAS INDICATED TO ODI THAT IT HAS NO ADDITIONAL REPORTS.VW IMPLEMENTED A PROCESS CHANGE ON MARCH 1, 2002.THIS PROCESS CHANGE CONSISTED OF CHANGING THE BOLT APPLICATION THAT FASTENS THE PSIR DOOR TO THE IP FROM A WELD ON APPLICATION TO A PRESS ON APPLICATION.VW ALSO CHANGED THE MATERIAL OF THE BOLT.VW STATED THAT THE CHANGES WERE MADE TO EASE PRODUCTION BY ELIMINATING A WELDING PROCESS.ODI HAS UPGRADED ITS INVESTIGATION TO ENGINEERING ANALYSIS (EA03-020).
EA00028 · Fuel Tank Puncture
Opened Dec 28, 2000 · Closed Jan 29, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
PE00033 · Fuel Tank Puncture
Opened Aug 10, 2000 · Closed Dec 28, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
Illustration