IllustrationRECALL 96V115000: THE VEHICLE DID NOT HAVE ANY HEAT, THE VEHICLE WAS CHECKED AND THE DEALER FOUND A FAULTY HEATING CORE. THE MANUFACTURER WAS AWARE OF THE PROBLEM AND INDICATED THAT THERE WAS A RECALL ON THE HEATER CORE, BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK *SC *JB
1990 Volkswagen Passat
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 1990 Volkswagen Passat are lower than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 34 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports3 fire reports1 injury reports
Engine And Engine Cooling complaints
12 reportsRECALL 96 V 115 000/ENGINE COOLING SYSTEM: VEHICLE EXPERIENCED OVERHEATING IN WHICH COOLANT / STEAM WAS COMING INTO VEHICLE. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT PART OF RECALL DUE TO VIN. *AK HEATING CORE FAILED AND LEAKED THROUGH THE VENTS. THE CONSUMER'S VEHICLE WAS EXCLUDED FROM R…
Read full complaint
RECALL 96 V 115 000/ENGINE COOLING SYSTEM: VEHICLE EXPERIENCED OVERHEATING IN WHICH COOLANT / STEAM WAS COMING INTO VEHICLE. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT PART OF RECALL DUE TO VIN. *AK HEATING CORE FAILED AND LEAKED THROUGH THE VENTS. THE CONSUMER'S VEHICLE WAS EXCLUDED FROM REPAIR WHILE THE SAME FAILURES AS IN THE RECALL OCCURED. *YH
WATER PUMP FAILED AND ENGINE OVERHEATED. CURRENTLY, THERE IS A LEAK. *AK
SPRING STRUTS AND STRUT MOUNTS FAILED. YH
THE ENGINE STALLS WHEN I APPLY QUICK BRAKES AT 50 MPH. ALSO, WHEN I LEAVE THE HIGHWAY, REDUCING VEHICLE SPEEC TO 30 MPH, UPON APPLYING BRAKING THE ENGINE FREQUENTLY STALLS. THIS IS AN DANGEROUS DRIVING CONDITION WHICH CAN CAUSE ACCIDENT/CRASH. THIS ALSO HAPPENS WHEN I APPLY QUICK BRAKES AT 30 MPH. THE LACK OF VACCUM PRESENT DUE…
Read full complaint
THE ENGINE STALLS WHEN I APPLY QUICK BRAKES AT 50 MPH. ALSO, WHEN I LEAVE THE HIGHWAY, REDUCING VEHICLE SPEEC TO 30 MPH, UPON APPLYING BRAKING THE ENGINE FREQUENTLY STALLS. THIS IS AN DANGEROUS DRIVING CONDITION WHICH CAN CAUSE ACCIDENT/CRASH. THIS ALSO HAPPENS WHEN I APPLY QUICK BRAKES AT 30 MPH. THE LACK OF VACCUM PRESENT DUE TO ENGINE STALLING CAUSES THE POWER BRAKES TO FAIL, REQUIRING EXCESSIVE FOOT PRESSURE AND EMERGENCY BRAKES ENGAGEMENT IN ORDER TO STOP THE VEHICLE. THIS VEHICLE HAD AN RECENT TUNE-UP WITHOUT ANY SUCCESS TO THE PROBLEM*AK.
CONSUMER WAS DRIVING AT 30 MPH AND NOTICED SMOKE COMING FROM THE ENGINE DUE TO THE OIL TOP BEING LEFT OFF WHICH CAUSED ANIT-FREEZE FLUID TO LEAK ONTO THE ENGINE. *AK
ENGINE OVERHEATS, CAUSING THE COOLANT PRESSURE TO RISE, RESULTING IN LEAKAGE. *AK
HEAD GASKET LEAKS, ALLOWING OIL TO RUN ONTO EXHAUST MANIFOLD AND BURNS, CAUSING CARBON MONOXIDE FUMES TO ENTE RVEHICLE; ALSO, HEAT EXHANGER LEAKS, CAUSING ODOR TO ENTER PASSENGER COMPARTMENT. COULD RESULT IN INJURY TO DRIVER'S FEET OR FOG UP WINDSHIELD.
THE HEATER EXCHANGER LEAKS AND ODER ENTERS PASSENGER COMPARTMENT. THIS LEAK COULD CAUSE INJURY TO THE DRIVER'S FEET OR CAUSE THE WINDSHIELD TO FOG OVER, INCREASING THE RISK OF AN ACCIDENT.
HEAD GASKET LEAKS ALLOW OIL TO RUN ONTO THE EXHAUST MANIFOLD AND BURN, CAUSING CARBON MONOXIDE TO ENTER THE PASSENGER COMPARTMENT. THERE IS ALSO A RISK OF FIRE IN THE ENGINE COMPARTMENT.
Official recalls
296V115000 · Engine And Engine Cooling:cooling System
Jul 1, 1996
IN THE EVENT THE ENGINE OVERHEATS AND THE VEHICLE IS OPERATED CONTINUOUSLY IN THAT CONDITION, THE COOLANT PRESSURE WILL RISE TO A LEVEL AT WHICH THE HEAT EXCHANGER COULD LEAK.
Consequence & remedy
Consequence: A LEAKING HEAT EXCHANGER WILL ALLOW HOT COOLANT TO ESCAPE CAUSING INJURY TO THE DRIVER'S FEET OR COULD STEAM UP THE INTERIOR OF THE VEHICLE TEMPORARILY IMPAIRING THE DRIVER'S VISIBILITY, INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE HEAT EXCHANGER ON THESE VEHICLES.
92V131000 · Vehicle Speed Control
Sep 15, 1992
THE VENTURI TUBE LOCATED IN THE THROTTLE VALVE HOUSING CAN BECOME LOOSE AND FALL AGAINST THE THROTTLE PLATE.
Consequence & remedy
Consequence: THE VENTURI TUBE CAN PARTIALLY BLOCK THE THROTTLE PLATEAND PREVENT IT FROM RETURNING TO ITS FULL IDLE POSITION, RESULTING IN UNWANTEDENGINE SPEED WHEN THE VEHICLE IS PLACED IN A FORWARD OR REVERSE GEAR.
Remedy: REPLACE THE PRESS-FIT VENTURI TUBE WITH A THREAD TYPE TUBE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.